SDS

Material Name: Bio-Penetrating Lubricant (BPL) (Food Grade) 11 oz. Aerosol Page 3 of 7
Issue Date: 15 May 2015
SECTION 3 –COMPOSITION/INFORMATION on INGREDIENTS
This material is considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200).
Components
CAS-No
Weight %
Trade Secret
Carbon Dioxide
124-38-9
1-10%
Oil Biobased vegetable
120962-03-0
90-99%
YES
SECTION 4 –FIRST AID MEASURES
Eye contact: Flush eye with water for 15 minutes. If symptoms persist, call a physician.
Skin contact: Wash off immediately with soap and plenty of water. Remove and wash contaminated clothing before
re-use. If skin irritation persists, call a physician.
Inhalation: Move to fresh air. If breathing is difficult, give oxygen. If not breathing, give artificial respiration. If
symptoms persist, call a physician.
Ingestion: Do not induce vomiting. Risk of product entering the lungs on vomiting after ingestion. If conscious,
drink plenty of water. Obtain medical attention.
Most important symptoms and effects, both acute and delayed
Symptoms No information available.
Indication of any immediate medical attention and special treatment needed
Notes to physician: Treat symptomatically.
SECTION 5 – FIRE-FIGHTING MEASURES
Suitable extinguishing media:
Water fog. Foam. Dry chemical powder. Carbon dioxide (CO2).
Unsuitable extinguishing media Do not use a solid water stream as it may scatter and spread fire
Specific hazards arising from the chemical
Contents under pressure. Pressurized container may rupture when exposed to heat or flame. During fire, gases hazardous to health
may be formed.
General fire hazards
In case of fire: Stop leak if safe to do so. Move containers from fire area if you can do so without risk. Containers should be cooled
with water to prevent vapor pressure build up.
Extremely flammable aerosol. Contents under pressure. Pressurized container may rupture when exposed to heat or flame.
Special protective equipment for firefighters:
Firefighters must use standard protective equipment including flame retardant coat, helmet with face shield, gloves, rubber boots, and
in enclosed spaces, SCBA.
SECTION 6 –ACCIDENTAL RELEASE MEASURES
Personal precautions, protective equipment and emergency procedures
Personal precautions: Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Keep out of low
areas. Many vapors are heavier than air and will spread along ground and collect in low or confined areas (sewers, basements, tanks).
Wear appropriate protective equipment and clothing during clean-up. Emergency personnel need self-contained breathing equipment.
Do not touch damaged containers or spilled material unless wearing appropriate protective clothing. Ventilate closed spaces before
entering them. Local authorities should be advised if significant spillages cannot be contained. For personal protection, see section 8
of the SDS.
Environmental precautions
Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Keep combustibles (wood, paper, oil, etc.)
away from spilled material. Stop the flow of material, if this is without risk. Wipe up with absorbent material (e.g. cloth, fleece).
Clean surface thoroughly to remove residual contamination. For waste disposal, see section 13 of the SDS.
Avoid discharge into drains, water courses or onto the ground.
Methods and material for containment and cleaning up