Instructions / Assembly

ManualsBrandsDurastall ManualsBath32 in. x 32 in. x 75 in. Shower Stall with Standard Base in White

INSTALLATION INSTRUCTIONS

INSTRUCCIONES PARA LA INSTALACIÓN

INSTRUCTIONS D’INSTALLATION

ROUGH-IN

ENCUADRE PRELIMINAR

SCHÉMA DE MONTAGE

NOTE: It is recommended to locate the shower valve

in a side wall not more than 16" back from front of the

cabinet. If cabinet is to have a door, mount hinge on

opposite side from shower valve.

NOTA: Se recomienda colocar la válvula de la ducha en una

pared lateral a no más de 16" (40 cm) detrás del frente de la

cabina. Si la cabina tiene puerta, coloque la bisagra en el lado

opuesto a la válvula de la ducha.

Remarque : il est recommandé d’installer le robinet de douche

sur un panneau latéral à un maximum de 16 po (40 cm) de

l’avant de la cabine. Si la cabine sera munie d’une porte,

installez les charnières du côté opposé à celui du robinet.

Español

*1 Orificio de 1" pulg

de diámetro

*2 Vea la nota

*3 (Dos orificios) 1

pulg de diámetro

*4 Frente

*5 Modelos 30, 68, 70

Français

*1 Trou de 1 po

*2 Voir la note

*3 2 trous de 1

*4 Avant

*5 Modèles 30, 68, 70

NOM. SIZE

Tamaño Nominal

Dimensions Nom.

MODEL NO.

Número de

Modelo

N° de

Modèle

DIMENSION

Dimensión

Dimension

A B C D

30"

73" 30

" 30

" 15

32"

" 32

" 16

32"

" 32

" 16

Models:

Modelos:

Modèles:

30 68 70

DURASTALL

Shower Stall

Cabina de Ducha

Cabine de Douche

ASSEMBLY / INSTALLATION / REPAIR PARTS

PARA ENSAMBLAR / INSTALACIÓN / PIEZAS DE REPARACIÓN

POUR SE RÉUNIR / INSTALLATION / PIÈCES DE RÉPARATION

(

30"

)

68/70

(

32"

)

With Standard Base

Con plato de ducha estándard

Avec base standard

READ ALL INSTRUCTIONS CAREFULLY AND INSPECT PRODUCT FOR DAMAGE BEFORE STARTING YOUR INSTALLATION.

LEA TODAS LAS INSTRUCCIONES DETENIDAMENTE Y VERIFIQUE QUE EL PRODUCTO NO ESTÉ DAÑADO ANTES DE COMENZAR LA INSTALACIÓN.

VEUILLEZ LIRE ATTENTIVEMENT TOUTES LES INSTRUCTIONS ET VÉRIFIER QUE LE PRODUIT N’EST PAS ABÎMÉ AVANT DE PROCÉDER À L’INSTALLATION.

INCLUDED IN CARTON: EN EL PAQUETE SE INCLUYE: CONTENU :

One (1) shower cabinet Una (1) cabina para ducha Une (1) module de douche

One (1) shower ﬂoor Un (1) piso de la ducha Un (1) bac à douche

One (1) shower valve Una (1) válvula para ducha Une (1) valve de douche

One (1) drain assembly Un (1) dispositivo de drenaje Un (1) tuyau d'évacuation

One (1) safety hand rail Un (1) con baranda de seguridad Un (1) barre d’appui

TOOLS AND MATERIALS REQUIRED FOR INSTALLATION:

HERRAMIENTAS Y MATERIALES PARA LA INSTALACIÓN DEL PRODUCTO:

OUTILS ET MATÉRIEL NÉCESSAIRES À L’INSTALLATION :

Screwdrivers (standard & Phillips) Destornilladores (estándar y Phillips) Tournevis (standard et cruciforme)

Drill Taladro Perceuse

Hole saws (1" and 1

") Sierras de perforación (1" y 1

") Scie-cloche (1 po et 1

po)

Adjustable wrench Llave ajustable Clé à molette

Open-end wrench set Juego de llaves de boca Jeu de clés plates

Level Nivel Niveau

Tape measure Cinta métrica Mètre ruban

Pliers Alicates Pinces

Hacksaw or sabre saw – ﬁne tooth Segueta o sierra eléctrica de dientes ﬁnos Scie à métaux ou scie sauteuse à dents ﬁnes

Caulking (waterproof)

Masilla (prueba del agua) Mastic (preuve de l’eau)

Pipe cement/primer (PVC) Cemento para tuberías /imprimador (PVC) Colle pour tuyau de PVC

Summary of content (6 pages)

PAGE 1
INSTALLATION INSTRUCTIONS INSTRUCCIONES PARA LA INSTALACIÓN INSTRUCTIONS D’INSTALLATION n Models: Modelos: Modèles: 30 68 70 DURASTALLCabina de Ducha Shower Stall Cabine de Douche ® ASSEMBLY / INSTALLATION / REPAIR PARTS 30 (30") 68/70 (32") n PARA ENSAMBLAR / INSTALACIÓN / PIEZAS DE REPARACIÓN POUR SE RÉUNIR / INSTALLATION / PIÈCES DE RÉPARATION With Standard Base Con plato de ducha estándard Avec base standard n n Read all instructions carefully AND INSPECT PRODUCT FOR DAMAGE before starting
PAGE 2
INSTALLATION 1. Hold the center panel upright with your left hand. Let the bottom rest on the floor. With the right hand, angle the corner lock strip and engage it to the left side of the center panel at the top. (Make sure the smooth side of the panel is to the inside.) Align the top of the lock strip to the top of center panel. Use the palm of your hand, push or tap the lock strip onto the panel, down about 10 inches from the top. Then take a hammer and strike the lock strip starting at the top.
PAGE 3
4. Position Safety Rail inside cabinet so that each end is located between the two ribs on the inside of the front support extrusions. Use a #10 x 5/8" Truss Head Screw to secure both ends of the Safety Rail through the pre-punched holes in the front supports. Position side and rear mounting pods of Safety Rail onto previously installed mounted screws. Place a 1/4" – 20 Flanged Nut on each mounting screw and tighten securely using a 7/16" wrench. (Fig. 4) 4.
PAGE 4
7. Set Top Frame in place and secure to panels and front supports following the same procedure previously used for securing the base. 7. Coloque el marco superior en su lugar y asegúrelo a los paneles y los soportes frontales usando el mismo procedimiento que usó para asegurar el plato. 7. Mettez le dessus de cabine en place et fixez-le aux panneaux et aux supports avant en procédant comme pour la base. 8. Set Threshold in place between the front support extrusions.
PAGE 5
Drain assembly / base installation MONTAJE DEL DESAGÜE / INSTALACIÓN DEL PLATO DE LA DUCHA n TUYAU D’ÉVACUATION / INSTALLATION DE BASE A. Check shower base carefully making sure it is not damaged. A. Asegúrese de que el plato de la ducha no esté dañado. A. Examinez la base de cabine soigneusement pour vous assurer qu’elle n’est pas endommagée. B. Assemble drain to shower base (see illustration below) using all washers provided.
PAGE 6
CARE & CLEANING CUIDADO Y LIMPIEZA ® SOIN ET NETTOYAGE ® The surface of your DURASTALL Shower Stall may be cleaned with a mild soap solution in warm water using a soft cloth. When using a cleaner product, carefully read the label to ensure that the cleaner is safe for use on the material. Stubborn stains can be cleaned using “Soft Scrub®” by Clorox® or a powdered detergent such as “Spic-n-Span®.” Do not allow cleaners to sit or soak on the surface.