Double-Wall, Close Clearance Connectors A member of M&G Group ® DVL Installation Instructions
A MAJOR CAUSE OF VENT RELATED FIRES IS FAILURE TO MAINTAIN REQUIRED CLEARANCES (AIR SPACES) TO COMBUSTIBLE MATERIALS. IT IS OF THE UTMOST IMPORTANCE THAT DVL (CLOSE CLEARANCE CONNECTOR) BE INSTALLED ONLY IN ACCORDANCE WITH THESE INSTRUCTIONS. NOTE: Read through all of these instructions before beginning your installation. Failure to install as described in this instruction will void the manufacturer’s warranty, and may have an effect on your homeowner’s insurance and UL listing status.
DVL Double-Wall, Close Clearance Stovepipe For the most up-to-date installation instructions, see www.duravent.com CONTENTS LISTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 PERMITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 CLEARANCE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 APPLICATION . . . . . . . . . . . . . . . . . . . . . . . . .
LISTING: UL and cUL listed by UL file # 14089 For installation in the United States and Canada PERMITS: Contact local Building or Fire Officials about permits, restrictions, and installation inspection in your area. curing of the finish and will disappear after a few uses of the appliance. Chimney Adapter Elbow Telescoping pipe or Adjustable pipe Pipe CLEARANCE: 6” clearance to walls 8” clearance to ceiling Clearances are measured at a 90 degree angle to the pipe.
DVL Pipe Length Finishing Collar Figure 4 Figure 2 INSTALLATION: 1. Attaching DVL to a DuraVent Chimney • Trim Ring Adapters (Figure 2) Insert inner sleeve into outer sleeve (if applicable). Slide Ring over lower portion of adapter. Insert large end of adapter’s inner sleeve over the chimney’s inner sleeve in the support box or wall thimble. Screw the Trim Plate to the support box or wall thimble.
Figure 6 5. Telescoping Pipe (Figure 6) Slide upper section of pipe onto lower section of pipe until desired length is obtained. Screw Telescoping pipe to lock pipe to desired length. 6. Elbows Elbows can be used anywhere in-line. Elbows are adjustable. Figure 7 7.
or soot has built up. If creosote or soot has accumulated, it should be removed to reduce the risk of chimney fire. 3. Have your connector and chimney cleaned by a professional chimney sweep if you have doubts about your ability to clean it. Use a plastic, wood or flexible steel brush. 4. When burning Coal clean the chimney thoroughly within 48 hours of shutting down the stove for the season. Check the chimney lining for sulfuric acid corrosion regularly. 5. Do not use chemical chimney cleaners.
M&G DuraVent Warranty M&G DuraVent, Inc. (“DuraVent”) provides this limited lifetime warranty for all of its products to the original purchaser, with the exception of Ventinox (lifetime), DuraBlack (five years) and all Termination Caps (five years). Subject to the limitations set forth below, DuraVent warrants that its products will be free from substantial defects in material or manufacturing, if properly installed, maintained and used.