Replacement Part List

*
· Do not overfill fuel tank. Fill tank to approximately 1.5 inches (38 mm) below top of neck to allow for fuel
expansion.
· Keep gasoline away from sparks, open flames, pilot lights, heat, and other ignition sources.
· Check fuel lines, tank, cap, and fittings frequently for cracks or leaks. Replace if necessary.
· If fuel spill, wait until it evaporates before starting engine.
1.
2.
3.
Clean the fuel cap area of dirt and debris. Remove the fuel cap.
Fill the fuel tank with gasoline. To allow for expansion of the gasoline, do not fill above the bottom of
the fuel tank neck.
Reinstall the fuel cap.
Maintenance
Use only original equipment replacement parts. Other parts may not perform as well,
may damage the unit, and may result in injury.
In addition, use of other parts may void your
warranty.
We recommend that you see any our agent for all maintenance and service of the engine and engine parts.
CAUTION: All the components used to build this engine must remain in place for proper operation.
WARNING
Unintentional sparking can result in fire or electric shock.
Unintentional start-up can result in entanglement, traumatic a
mputation, or laceration.
Fire hazard
Be
fore performing adjustments or repairs:
· Disconnect the spark plug wire and keep it away from the spark plug.
· Use only correct tools.
· Do not tamper with governor spring, links or other parts to increase engine speed.
· Replacement parts must be the same and installed in the same position as the original parts.
· Do not strike the flywheel with a hammer or hard object because the flywheel may later shatter during
operation.
When testing for spark:
· Use approved spark plug tester.
· Do not choke for spark with spark plug removed.
First 5 Hours of operation
•
Change Oil
E very 8 Hours of operation or Daily
•
•
Check engine oil level
Clean area a
round muffler and c
ontrols
E very 25 Hours of operation or Annually
•
Clean air filter
E very 50 Hours of operation or Annually
•
•
Change engine oil
Check muffler an
d spark arrester (
If installed)
Annually
•
•
•
Replace air filter
Replace spark plug
Clean air cooling system
Carburetor Adjustment
Never make adjustments to the carburetor. The carburetor was set at the factory to operate efficiently
under most conditions. However, if adjustments are required, see any our Authorized Dealer for
service.
8