MSDS

Unusual Fire and Explosion Hazards
Hydrogen and oxygen gases are produced in the cells
during normal battery operation (hydrogen is flammable
and oxygen supports combustion). These gases enter the
air through the vent caps. To avoid the chance of a fire or
explosion, keep sparks and other sources of ignition away
from the battery.
SECTION 6 : Accidental release measures
a.
Remove combustible materials and all sources of ignition. Cover sills with soda ash (sodium
carbonate) or quicklime (calcium oxide). Mix well. Make certain mixture is neutral then
collect residue and place in a drum or other suitable container. Dispose of a hazardous
waste.
b.
Wear acid-resistant boots, chemical face shield, chemical splash goggles, and
acid-resistant gloves.
Do not release un-neutralized acid.
SECTION 7 : Handling and storage
Hygiene Practices:
Following contact with internal battery components, wash hand thoroughly before eating, drinking,
or smoking.
Respiratory Protection:
Wear safety glasses. Do not permit flames or sparks in the vicinity of battery(s). If battery
electrolyte (acid) comes in contact with clothing, discard clothing.
Other Handling and Storage Precautions:
None Required.
SECTION 8: Exposure controls / Personal protection
Engineering Controls:
Store lead/acid batteries with adequate ventilation. Room ventilation is required for batteries
utilized for standby power generation. Never recharge batteries in an unventilated, enclosed
space.
Work Practices:
Do not remove vent caps. Follow shipping and handling instructions that are applicable to the
battery type. To avoid damage to terminals and seals, do not double-stack industrial batteries.
Respiratory Protection:
None required under normal handling conditions. During battery formation (high-rate charge
condition), acid mist can be generated which may cause respiratory irritation. Also, if acid spillage
occurs in a confined space, exposure may occur. If irritation occurs, wear a respirator suitable for
protection against acid mist.
Eyes and Face:
Chemical splash goggles are preferred. Also acceptable are "visor-gogs" or a chemical face
shield worn over safety glasses.