Operating instructions

ManualsBrandsDyna-Glo ManualsHeating SystemRA125LPDGD

—

Printed in China

SIZE AND CAPACITY OF PROPANE

GAS CYLINDERS

NOTE: Chart above shows number of

100 pound tanks needed to operate this

heater at a given temperature.

Less gas is vaporized at lower

temperatures. You may need two or

more 100 pound tanks, or one larger

tank in colder weather. Your local

propane gas dealer will help you select

the proper supply system.

General Safety Information

Make sure you read and thoroughly

understand these safety and operating

instructions. Keep these instructions for

future reference. They are your guides

to safe and proper operation of this

heater.

Indicates an

imminently

hazardous situation which, if not

avoided, WILL result in death or

serious injury.

Indicates a

potentially

hazardous situation which, if not

avoided, COULD result in death or serious

injury.

Indicates a

potentially

hazardous situation which, if not

avoided, MAY result in minor or

moderate injury.

Always turn off

heater at control

knob and then close LP cylinder when not

in use.

Do not operate this

heater until you have

read, and thoroughly understand these

safety and operating instructions. Failure

to comply with the precautions and

instructions provided with this heater can

result in death, serious bodily injury,

property loss or damage from the

hazards of fire, explosion, burns, or

electrical shock. Only persons who can

read and understand these instructions

should use or service this heater. Not for

residential, household or recreational

vehicle use. Please read this manual.

Consumer: Retain this manual for

future reference.

Dyna-Glo

Delux Propane

Gas-Fired Radiant Heater

Operating Instructions & Parts Manual RA125LPDGD

Please read and save these instructions. Read carefully before attempting to assemble, install, operate or maintain the product described. Protect yourself and

others by observing all safety information. Failure to comply with instructions could result in personal injury and/or property damage! Retain instructions for

future reference.

Description

Dyna-Glo Delux Model RA125LPDGD heater is a 125,000 BTU/Hr construction

heater.

This heater uses propane gas for combustion. It is primarily intended for

temporary heating of well-ventilated buildings under construction, alteration

or repair. This heater should be utilized in sheltered, well-ventilated areas,

but never in occupied dwellings.

Fuel Consumption Manifold Inlet Gas Supply Dimensions

Model BTU/Hr Maximum Pressure Pressure Ignitor Gap Weight (Lbs) L x W x H (in.)

RA125LPDGD 50,000 to 5.77 lbs/hr 11” W.C. Min. 5 psi 0.19“ 20.3 (heater) 16.3 x

16.3 x 29.8

125,000 Max. Bottle Pressure

Fuel Type – Propane Only Ignition Type – Piezo Minimum Operating Temp. – -20°F (-29°C)

Specifications

Temperature

(°F) at Tank

No. of Tanks Needed

50,000 BTU/Hr 100,000 BTU/Hr

1 2

20 1 2

10 1 3

0 1 3

-10 2

Use Larger

Tank

-20 2

Use Larger

Tank

Figure 1 – Model

RA125LPDGD

Unpacking

1. Remove heater, accessories and all

hardware from the shipping carton.

NOTE: Save the box and packaging

materials for future use. After

unpacking unit, inspect carefully for any

damage that may have occurred during

transit. Check for loose, missing or

damaged parts. Shipping damage claim

must be filed with carrier.

GHP Group, Inc.

8280 Austin Avenue

Morton Grove, IL 60053

CSA 2.14b-2009, ANS Z83.7b-2009

Construction Heater

C US

PROFESSIONAL GRADE

Rev 2012-06-08

Summary of content (9 pages)

PAGE 1
RA125LPDGD Operating Instructions & Parts Manual Please read and save these instructions. Read carefully before attempting to assemble, install, operate or maintain the product described. Protect yourself and others by observing all safety information. Failure to comply with instructions could result in personal injury and/or property damage! Retain instructions for future reference.
PAGE 2
RA125LPDGD Dyna-Glo Delux Operating Instructions and Parts Manual Dyna-Glo Delux Propane Gas-Fired Radiant Heater ® E N G L I S H General Safety Information (Continued) General Hazard Warning: Failure to comply with the precautions and instructions provided with this heater, can result in death, serious bodily injury and property loss or damage from hazards of fire, explosion, burn, asphyxiation, carbon monoxide poisoning, and / or electrical shock.
PAGE 3
Dyna-Glo Delux Operating Instructions and Parts Manual Model RA125LPDGD General Safety Information (Continued) 10. Use this heater only as described in this manual. Any other use not recommended by the manufacturer may cause a fire or injury to persons. 18. The heater, other than a heater with an integral propane gas cylinder, must be located at least (i) 6 ft. (1.83 m) in the U.S.; or (ii) 10 ft. (3 m) in Canada, from any propane gas cylinder. 11. Provide adequate ventilation.
PAGE 4
RA125LPDGD Dyna-Glo Delux Operating Instructions and Parts Manual Dyna-Glo Delux Propane Gas-Fired Radiant Heater ® E N G L I S H Operation (Continued) LEAK CHECKING TO RESTART HEATER 6. If burner does not light, turn heater control knob to “OFF” position and repeat step 5. Keep control knob depressed for approximately 10 to 15 seconds, then release control knob. 1. With heater gas valve knob still in OFF position, turn ON tank valve and check for leaks with soap solution.
PAGE 5
Dyna-Glo Delux Operating Instructions and Parts Manual Model RA125LPDGD Maintenance (Continued) 2. Inspect heater before each use. Check connections for leaks. Apply a 50/50 solution of dish soap and water. Bubbles forming show a leak that must be corrected. Correct leaks at once. 3. Inspect regular hose assembly before each use. If hose is highly worn or cut, replace with hose specified by manufacturer. 4.
PAGE 6
RA125LPDGD Dyna-Glo Delux Operating Instructions and Parts Manual For Repair Parts, call 1-877-447-4768 Please provide following information: -Model number -Serial number (if any) -Part description and number as shown in parts list 1 E N G L I S H 2 3 12 10 11 4 5 6 9 8 20 7 19 13 21 16 14 15 17 18 Figure 4 – Repair Parts Illustration for Propane Gas-Fired Radiant Heater For Technical Support or Troubleshooting, Call: 1-877-447-4768, 8:30 am - 4:30 pm CST 6 www.ghpgroupinc.
PAGE 7
Dyna-Glo Delux Operating Instructions and Parts Manual Model RA125LPDGD Repair Parts List for Propane Gas-Fired Radiant Heater Reference Number Description Part Number for Model: RA125LPDGD Quantity 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 5002854 2315528 2315519 2315522 2315545 2315546 2315640 2315517 2315642 2201584 2201583 2315520 5002851 2101451 5050685 2304948 2315525 2315526 2315527 5002721 5002758 Top Cover Guard Emitter Nozzle Nozzl
PAGE 8
Warranty Dyna-Glo Delux Operating Instructions and Parts Manual RA125LPDGD LIMITED WARRANTY: This limited warranty is extended to the original retail purchaser of this Forced Air/Convection/Radiant Heater and warrants against any defect in materials and workmanship for a period of one (1) year from the date of retail sale. GHP Group, Inc.
PAGE 9
WARRANTY REGISTRATION IMPORTANT: We urge you to fill out your warranty registration card within fourteen (14) days of date of purchase. You can also register your warranty on the internet at www.ghpgroupinc.com. Complete the entire serial number. Retain this portion of the card for your records. GHP Group, Inc. 8280 Austin Ave. Morton Grove, IL 60053-3207 GHP Tel: (877) 447-4768 www.ghpgroupinc.com 8280 Austin Avenue M o r t o n G rove , I L .