User`s manual

ManualsBrandsDyna-Glo ManualsElectric HeaterRA18LPA

Questions, problems, missing parts? Before returning to your retailer, call our customer

service department at 877-447-4768 8:30 a.m. – 4:30 pm CST, Monday – Friday

or email us at customerservice@ghpgroupinc.com

USER’S MANUAL AND OPERATING INSTRUCTIONS

&86

MODEL # RA18LPDG, RA18LPDGD,

RA18LPDGP, RA18LPA, RA18LPB, and RA18LPC

PROPANE CONSTRUCTION HEATER

CONSUMER: Retain this manual for future reference.

Dyna-Glo, Dyna-Glo Pro

Dyna-Glo Delux

CSA 2.14b-2009, ANS Z83.7b-2009

IMPORTANT: READ AND UNDERSTAND

THIS MANUAL BEFORE ASSEMBLING,

STARTING OR SERVICING HEATER.

IMPROPER USE OF HEATER CAN

CAUSE SERIOUS INJURY. KEEP THIS

MANUAL FOR FUTURE REFERENCE.

GENERAL HAZARD WARNING:

FAILURE TO COMPLY WITH THE

PRECAUTIONS AND INSTRUCTIONS PROVIDED

WITH THIS HEATER, CAN RESULT IN DEATH,

SERIOUS BODILY INJURY AND PROPERTY

LOSS, OR DAMAGE FROM THE HAZARDS OF

FIRE, EXPLOSION, BURN. ASPHYXIATION,

CARBON MONOXIDE POISONING, AND/OR

ELECTRICAL SHOCK.

ONLY PERSONS WHO CAN UNDERSTAND AND

FOLLOW THE INSTRUCTIONS SHOULD USE OR

SERVICE THIS HEATER.

IF YOU NEED ASSISTANCE OR HEATER

INFORMATION SUCH AS AN INSTRUCTION

MANUAL, LABELS, ETCETERA, CONTACT THE

MANUFACTURER.

CALIFORNIA PROPOSITION 65 WARNING:



















20-10-090 Printed in China Rev. 2011-01-10

Summary of content (19 pages)

PAGE 1
Dyna-Glo, Dyna-Glo Pro Dyna-Glo Delux PROPANE CONSTRUCTION HEATER USER’S MANUAL AND OPERATING INSTRUCTIONS MODEL # RA18LPDG, RA18LPDGD, RA18LPDGP, RA18LPA, RA18LPB, and RA18LPC & 86 CSA 2.14b-2009, ANS Z83.7b-2009 IMPORTANT: READ AND UNDERSTAND THIS MANUAL BEFORE ASSEMBLING, STARTING OR SERVICING HEATER. IMPROPER USE OF HEATER CAN CAUSE SERIOUS INJURY. KEEP THIS MANUAL FOR FUTURE REFERENCE.
PAGE 2
PAGE 3
PROPANE CONSTRUCTION HEATER TABLE OF CONTENTS General Safety Information .............................................................................. 3 - 4 Unpacking and Assembly .................................................................................
PAGE 4
PROPANE CONSTRUCTION HEATER GENERAL SAFETY INFORMATION Radiant Propane Construction Heaters The heater is designed and approved for use as a construction heater under ANS Z83.7b, CSA 2.14b. It is hard to anticipate every use which may be made of this heater. CHECK WITH YOUR LOCAL FIRE SAFETY AUTHORITY IF YOU HAVE QUESTIONS ABOUT APPLICATIONS. + 5 ; 5 < < = ; 5 ; Your local authority can advise you about these.
PAGE 5
PROPANE CONSTRUCTION HEATER GENERAL SAFETY INSTRUCTIONS Accidents are always tragic especially because so many of them could have been prevented with little care and judgment. There are some basic good practices, we hope you will follow for safe use of your heater.
PAGE 6
PROPANE CONSTRUCTION HEATER SPECIFICATIONS Vent Free Radiant Heater - Propane Vapor Only Fuel Type ............................................................................................................... Propane Vapor Only #; > = + = Min Operating Temperature ....................................................................................................
PAGE 7
PROPANE CONSTRUCTION HEATER CONTENTS 1. Unit 2. Rear Guard 3. Manual 4. Hardware Kit Includes: M8 Flat Washers(4) Locking Casters(2) & ' * + 10 Minutes Non Locking Casters(2) 14 mm Wrench(1) Tools Required: 14 mm Wrench (Included) UNPACKING THE HEATER 1. 2. % 4. Remove heater from carton. Remove all protective packaging applied to heater for shipment. ; \ = = \ 5 < ; Check heater for any shipping damage.
PAGE 8
PROPANE CONSTRUCTION HEATER PROPANE SUPPLY You must provide the propane gas and cylinder(s).
PAGE 9
PROPANE CONSTRUCTION HEATER UNPACKINGTO THE HEATER CONNECTING GAS SUPPLY ALWAYS USE A PROPANE (LP) CYLINDER THAT HAS A CONNECTION DEVICE IMPORTANT! THAT IS COMPATIBLE WITH THE HOSE AND REGULATOR ASSEMBLY SUPPLIED. THE PROPANE (LP) GAS PRESSURE REGULATOR AND HOSE ASSEMBLY SUPPLIED WITH THE HEATER MUST BE USED WITHOUT ALTERATION. BE SURE TO INSPECT THE REGULATOR HOSE BEFORE EACH USE. IF THE HOSE IS CUT OR FRAYED, REPLACE IT WITH THE MANUFACTURER SUGGESTED ASSEMBLY. CAUTION 1.
PAGE 10
PROPANE CONSTRUCTION HEATER PROPANE SAFETY Propane is safe to use when properly handled. Careless handling of the Propane gas tank could result in _ = >5 < | z =] = = < ;5 z ; ]5 ; = 5 \ \ ; diaphragm in regulator.
PAGE 11
PROPANE CONSTRUCTION HEATER LIGHTING INSTRUCTIONS 1. STOP! Read and head warnings and cautions on the side of the heater. 2. Check that the gas supply to the heater is on. 3. Push in gas control knob slightly and turn clockwise Note: knob cannot be turned from “PILOT” to “OFF” position to “OFF” position. (A) unless the knob is pushed in slightly. Do not force.
PAGE 12
PROPANE CONSTRUCTION HEATER SHUTDOWN INSTRUCTIONS 1. Push in gas control knob slightly and turn clockwise to “OFF” position. Do not force. (A) 2. Turn gas supply off by turning propane tank valve clockwise to close. * ; < * = Turn control knob clockwise to “PILOT” position. (B) STORAGE Never store a Propane gas tank inside a building or in the vicinity of any gas or oil burning appliance.
PAGE 13
PROPANE CONSTRUCTION HEATER MAINTENANCE 5 = [ [ = >5 = 5 = [ [ < least annually by a professional service person. More frequent cleaning may be required due to excessive debris. It is imperative that control compartments, burners and circulating air passageways of the heater be kept clean. Dust, lint, cobwebs or debris may affect heater performance.
PAGE 14
PROPANE CONSTRUCTION HEATER TROUBLESHOOTING Problem Possible Cause What To Do When ignitor is depressed there is no spark at ODS pilot. 1. Ignitor electrode positioned wrong. 2. Ignitor electrode broken. 3. Ignitor cable pinched or broken. 4. Ignitor cable not connected to ignitor electrode. 5. Ignitor defective. 1. Reposition ignitor electrode. 2. Replace electrode. 3. Free ignitor cable, if damaged, replace. 4. Connect cable to electrode. 5. Replace ignitor.
PAGE 15
PROPANE CONSTRUCTION HEATER TROUBLESHOOTING (continued) Problem Possible Cause What To Do Gas odor even when control knob is in OFF position. 1. Gas leaks. Refer to front of page Warnings. 2. Gas control defective. 1. Locate and correct leaks immediately. 2. Replace gas control Gas odor during combustion. 1. Foreign matter in gas or on burner ports. 2. Heater burning vapors form paint, impurities in air. 3. Gas leaks, refer to front page Warnings 1. Check gas passage way and burner. 2.
PAGE 16
WARRANTY LIMITED WARRANTY: This limited warranty is extended to the original retail purchaser of this Forced Air/Convection/Radiant Heater and warrants against any defect in materials and workmanship for a period of one (1) year from the date of retail sale. GHP Group, Inc., at it’s option, will either provide replacement parts or replace or repair the unit, when properly returned to the retailer where purchased or one of our service centers as directed by GHP Group, Inc.
PAGE 17
WARRANTY REGISTRATION IMPORTANT: We urge you to fill out your warranty registration card within fourteen (14) days of date of purchase. You can also register your warranty on the internet at www.ghpgroupinc.com. Complete the entire serial number. Retain this portion of the card for your records. GHP Group, Inc. 8280 Austin Ave. Morton Grove, IL 60053-3207 GHP Tel: (877) 447-4768 www.ghpgroupinc.com SAVE THIS CARD! Place Postage Stamp Here GHP Group, Inc.
PAGE 18
PROPANE CONSTRUCTION HEATER REPLACEMENT PARTS LIST RA18 SERIES Item/Model Number Part No. Item/Model Number 1. Lower Shield PT-N11B-8 10. Tilt Switch FD4 2. Guard Assembly PT-N11B-3 11. Gas Pipe PT-N11B-7 3. Front Panel PT-N11B-1 12. Regulator & Hose Assembly KR-106A 4. Reflector PT-N11B-2 13. Rear Chassis PT-N11B-4 5. ODS Assembly PT-N11B.6 14. Castor With Lock PT-N06-33 6. Burner Assembly PT-N11B.4 15. Castor Without Lock PT-N06-32 7. Gas Valve PT-N11B-13 16.
PAGE 19
PROPANE CONSTRUCTION HEATER EXPLODED PARTS DRAWING 18.Knob ? \ ] @ ' * 8. Piezo Ignitor ^ [ v 9. Knob Base 3. Front Panel >c J ' * >> $ > ` j ;{ ' * 13. Rear Chassis >J [ >? @ " ' * >^ _ ` >j _ ` 16.