Use and Care Manual

TROUBLESHOOTING
1. Unitwillnotlight. 1. Valveonpropanecylindernotopen. 1. Opencylindervalvebyturningcounterclockwise.
2. Propanecylinderempty 2. Havecylinderrefilled.
3. Regulatornotin"High"position 3. Turnregulatorto"High"position.
4. Excessflowdevicetriggered. 4. Closecylidervalve,wait5minutesandreopenslowly.
5. DefectiveRegulator. 5. ReplaceRegulatorassembly.
2. Burnerwillnotstaylitwhen 1. Tiltswitchopen 1. Correctalignmentofunittoensureitisvertical.
gasvalveplungerreleased. 2. Wiringofthermocouple 2. Checkwiringconnectionsareproperlyengaged.
3. Defectivethermocouple 3. Replacethermocouple.
4. Defectivetiltswitch 4. Replacetiltswitch.
5. Defectivegasvalve 5. Replacegasvalveassembly.
3. Excessiveflamescomingout 1. Debrisorspiderwebsinmixingtube 1. Cleanburnertubewithbottlebrush,rinseinwater
ofburner,notglowingred. orburner. anddrainthoroughlybeforereintsalling.
2. Cloggedorifice 2. Removeandcleanusingcompressedair.
4. Piezowon'tspark. 1. Defectivepiezo 1. ReplacePiezo
(Somemodelsonly) 2. IgnitormisalignedwithThermocoupleshield 2. Realignignitorwiththermocoupleshield.
3. Wirefrayedordamaged. 3. Replacewire.
5. Flamesflashback/burninside 1. Debrisorspiderwebsinmixingtube. 1. Cleanburnertubewithbottlebrush,rinseinwater
themixingtube anddrainthoroughlybeforereintsalling.
2. Cloggedorifice 2. Removeandcleanusingcompressedair.
PROBLEM
POSSIBLECAUSE
CORRECTIVEACTION
REPLACEMENT PARTS LIST
15
PROPANE TANK TOP HEATER
TT15CPDG TT15CL/TT15CDGP TT30CPDG TT30CL/TT30CDGP
1 RegulatorAssembly TYQ‐14A TYQ‐14A TYQ‐14A TYQ‐14A
2 BurnerAssembly TT15‐00‐01 TT15‐00‐01 TT15‐00‐01 TT15‐00‐01
3 ThermocoupleAssembly TT15C‐11 TT15C‐11 TT15C‐11 TT15C‐11
4 GuardAssembly TT15C‐03 TT15C‐03 TT15C‐03 TT15C‐03
5 RearGuardAssembly TT15C‐04 TT15C‐04 TT15C‐04 TT15C‐04
6 SafetyShut‐offValve K‐80D‐A5‐0 K‐80D‐A5‐0 K‐80D‐A5‐0 K‐80D‐A5‐0
7 Manifold ‐‐ ‐‐ K‐80D‐A5‐02 K‐80D‐A5‐02
8 PiezoAssembly GL‐007 ‐‐ GL‐007 ‐‐
9 TankCollarBracket ‐‐ ‐‐ TT30C‐02 TT30C‐02
10 MountingBoltKnob ‐‐ ‐‐ TT30C‐3 TT30C‐3
11 GasHose ‐‐ ‐‐ QG‐008C QG‐008C
12 Handwheel QG‐010‐01 QG‐010‐01 QG‐010‐01 QG‐010‐01
13 Electrode TT15C‐14 ‐‐ TT15C‐14 ‐‐
14 TipOverSwitch TT15C‐08 TT15C‐08 TT15C‐08 TT15C‐08
15 SupportLeg TT15C‐02 TT15C‐02 ‐‐ ‐‐
PartNumber
ITEM DESCRIPTION
NEVER LEAVE THE HEATER
UNATTENDED WHILE BURNING!