Installation Guide

TROUBLESHOOTING
1. Unitwillnotlight. 1. Valveonpropanecylindernotopen. 1. Opencylindervalvebyturningcounterclockwise.
2. Propanecylinderempty 2. Havecylinderrefilled.
3. Regulatornotin"Low"position 3. Turnregulatorto"Low"position.
4. Excessflowdevicetriggered. 4. Closecylidervalve,wait5minutesandreopenslowly.
5. DefectiveRegulator. 5. ReplaceRegulatorassembly.
2. Burnerwillnotstaylitwhen 1. Tiltswitchopen 1. Correctalignmentofunittoensureitisvertical.
gasvalveplungerreleased. 2. Wiringofthermocouple 2. Checkwiringconnectionsareproperlyengaged.
3. Defectivethermocouple 3. Replacethermocouple.
4. Defectivetiltswitch 4. Replacetiltswitch.
5. Defectivegasvalve 5. Replacegasvalveassembly.
3. Excessiveflamescomingout 1. Debrisorspiderwebsinmixingtube 1. Cleanburnertubewithbottlebrush,rinseinwater
ofburner,notglowingred. orburner. anddrainthoroughlybeforereinstalling.
2. Cloggedorifice 2. Removeandcleanusingcompressedair.
4. Piezowon'tspark. 1. Defectivepiezo 1. ReplacePiezo
(Somemodelsonly) 2. Ignitormisalignedwithburnermesh. 2. Realignignitorwithburnermesh.Thesparkgap
3. Wirefrayedordamaged. shouldbe0.15''(4mm).
3 Replacewire.
5. Flamesflashback/burninside 1. Debrisorspiderwebsinmixingtube. 1. Cleanburnertubewithbottlebrush,rinseinwater
themixingtube anddrainthoroughlybeforereintsalling.
2. Cloggedorifice 2. Removeandcleanusingcompressedair.
PROBLEM
POSSIBLECAUSE
CORRECTIVEACTION
REPLACEMENT PARTS LIST
15
PROPANE TANK TOP HEATER
1 Regulator Assembly TYQ-14A
2 Gas Hose QG-008C
3 Piezo Ignitor GL-007
4 Valve Cable TT15C-12
5 Tip Over Switch
KW-16B
6 Thermocouple Bracket TT15C-05
7 Thermocouple Shield TT360C.08
8 Thermocouple TT15C-11
9 Electrode Assembly TT360C.10
10 Guard Assembly TT360C.05
11 Burner Assembly (Incl. Upper Reflector) TT360C.00
12 Reflector – Lower TT360C.03
13 Nozzle TT360C.09
14 Safety Shutt-off Valve K-80D-A5-0
15 Tank Collar Bracket TT360C.07
16 Mounting Bolt Knob TT30C-3
17 Mounting Plate TT360C.06
18 Piezo Mounting Bracket TT15C-07
ITEM DESCRIPTION PART NUMBER
NEVER LEAVE THE HEATER
UNATTENDED WHILE BURNING!