ENGLISH Owner’s Manual MAC 33cc 2-Cycle Cultivator Model #: 31452 50:1 SERIAL NO. DATE OF PURCHASE: THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY INFORMATION. PLEASE READ AND KEEP FOR FUTURE REFERENCE. Get parts or technical assistance online at www.GetEarthquake.
Owner’s Manual MAC 2-CYCLE CULTIVATOR STOP! ACTIVATE YOUR WARRANTY BEFORE USE All products must be registered within 30 days from the date of purchase in order to be covered under warranty. For more information regarding Warranty and Registration please review the Warranty and Registration terms and conditions expressed in the warranty insert. INTRODUCTION Thank you for purchasing your product from Earthquake®.
Owner’s Manual MAC 2-CYCLE CULTIVATOR WARNINGS AND SAFETY PRECAUTIONS OWNER’S RESPONSIBILITY Accurate assembly and safe and effective use of the machine is the owner’s responsibility. • Read and follow all safety instructions. • Carefully follow all assembly instructions. • Maintain the machine according to directions and schedule included in this Earthquake® operator’s manual. • Ensure that anyone who uses the machine is familiar with all controls and safety precautions.
Owner’s Manual MAC 2-CYCLE CULTIVATOR GENERAL SAFETY RULES • Read, understand, and follow all instructions on the machine and in the manual(s). Be thoroughly familiar with the controls and the proper use of the machine before starting. Know how to stop the machine and disengage the controls quickly. • Use this equipment for its intended purpose only. • Familiarize yourself with all of the safety and operating decals on this equipment and on any of its attachments or accessories.
Owner’s Manual MAC 2-CYCLE CULTIVATOR WARNING ENGINES GIVE OFF CARBON MONOXIDE, AN ODORLESS, COLORLESS, POISONOUS GAS. CARBON MONOXIDE MAY BE PRESENT EVEN IF YOU DO NOT SMELL OR SEE ANY ENGINE EXHAUST. BREATHING CARBON MONOXIDE CAN CAUSE NAUSEA, FAINTING OR DEATH, IN ADDITION TO DROWSINESS, DIZZINESS AND CONFUSION. IF YOU EXPERIENCE ANY OF THESE SYMPTOMS, SEEK FRESH AIR AND MEDICAL ATTENTION IMMEDIATELY. HOT GASES ARE A NORMAL BY-PRODUCT OF A FUNCTIONING INTERNAL COMBUSTION ENGINE.
Owner’s Manual MAC 2-CYCLE CULTIVATOR • Test the fuel cap for proper installation before starting and using engine. • Stop the engine (motor) when leaving the operating position, before unclogging the tines, and when making any repairs, adjustments and inspections. • Always run the engine with fuel cap properly installed on the engine. • Stop the engine (motor) when leaving the machine unattended.
Owner’s Manual MAC 2-CYCLE CULTIVATOR PREVENTION OF BURNS AND FIRES walk-behind tiller. GASOLINE FIRES AND HANDLING FUEL SAFELY • Use extra care in handling gasoline and other fuels. They are flammable and vapors are explosive. • When storing extra fuel be sure that it is in an appropriate container and away from any fire hazards. • Prevent fire and explosion caused by static electric discharge. Use only nonmetal, portable fuel containers approved by the Underwriter’s Laboratory (U.L.
Owner’s Manual MAC 2-CYCLE CULTIVATOR • Follow manufacturer’s recommendations for safe loading, unloading, transport and storage of machine. SAFETY DECALS A B C This cultivator unit has been designed and manufactured to provide you with the safety and reliability you would expect from an industry leader in outdoor power equipment manufacturing.
Owner’s Manual MAC 2-CYCLE CULTIVATOR FEATURES ON/OFF SWITCH U-TURN™ HANDLEBAR STORAGE POSITION TOOL-LESS HEIGHT ADJUSTMENT SEE THROUGH FUEL TANK TOOL-LESS REPLACEABLE & REVERSIBLE TINES FRONT BUMPER (TRANSPORT & STORAGE) FIGURE 1 SPECIFICATIONS ENGINE DISPLACEMENT 33cc SPARK PLUG GAP 0.028 inch FUEL TANK CAPACITY 33 fl-oz TRANSMISSION Bronze gear drive OIL/GAS RATIO 50:1 - 2.
Owner’s Manual MAC 2-CYCLE CULTIVATOR UNPACKING AND ASSEMBLY CARTON CONTENTS CULTIVATOR ASSEMBLY • Hardware Parts Bag: • A - (4) Three-Knob Nut • B - (4) Curved Washer • C - (4) Saddle Bolt • D - (1) Hairpin • Manual Parts Bag • Left Middle, Right Middle and U-Turn™ Handlebar Assembly • “A” and “B” Tine Sets • Bottle of 2-cycle Engine Oil NOTICE HANDLE CULTIVATOR WITH CARE. DO NOT DAMAGE CABLE WHEN TRANSPORTING OR OPERATING.
Owner’s Manual MAC 2-CYCLE CULTIVATOR 4. Attach the U-turn™ handlebar assembly to the middle handlebars using the two remaining three-knob nuts, saddle bolts, and curved washers. DO NOT over-tighten the three-knob nuts. SEE FIGURE 4. U-TURN™ HANDLEBAR ASSEMBLY RIGHT MIDDLE HANDLEBAR WARNING DO NOT STORE ENGINE INDOORS WITH FUEL IN THE TANK. FUEL AND FUEL VAPORS ARE HIGHLY FLAMMABLE. NEVER MIX FUEL AND OIL DIRECTLY IN ENGINE FUEL TANK.
Owner’s Manual MAC 2-CYCLE CULTIVATOR OPERATION before refilling the fuel tank. 2. Move to a well ventilated area, outdoors, away from flames and sparks. 3. Clean debris from area around the fuel cap. 4. Loosen fuel cap slowly. Place the cap on a clean, dry surface. 5. Carefully add fuel without spilling. 6. Do not fill fuel tank completely full, allow space for fuel to expand. IMPORTANT 7. Immediately replace fuel cap and tighten. Wipe off spilled fuel and allow to dry before starting engine.
Owner’s Manual MAC 2-CYCLE CULTIVATOR between the tine blades. 3. WARNING Insert the hairpins into the holes at each end of the tine shaft to lock the tines into place. MAKE SURE THE UNIT IS IN A STABLE POSITION BEFORE PULLING THE STARTER HANDLE. NOTE: Tines can be reversed so the pointed tip of the tines are directed forward - for more aggressive digging. In this arrangement, tines are positioned left to right D, C, B, A as viewed from the user’s position.
Owner’s Manual MAC 2-CYCLE CULTIVATOR DO NOT attempt to start engine in the following ways: ON/OFF SWITCH RECOIL HANDLE RUN POSITION • DO NOT use starting fluid. • DO NOT spray flammable liquids or vapors into air cleaner, carburetor or spark plug chamber. • DO NOT remove spark plug and attempt to start engine. Flammable fuel can spray out & ignite from a spark from spark plug.
Owner’s Manual MAC 2-CYCLE CULTIVATOR 2. Keep all screws, nuts, and bolts tight. 2. 3. For cold weather operation, store the unit in a cool environment. Transferring the unit from a cold to a warm place can cause the build up of harmful condensation. Disconnect the spark plug cap, and clean any debris from around the spark plug area. 3. Remove spark plug and replace if any of the following occur; pitted electrodes, burned electrodes, cracked porcelain, or deposits around electrodes. 4.
Owner’s Manual MAC 2-CYCLE CULTIVATOR foam filter with warm water and mild soap. SEE FIGURE 10. 4. After cleaning, thoroughly oil the foam filter with 30 or 40 weight motor oil and squeeze out any excess oil before reinstalling it. Make sure to press the foam filter evenly into place over the filter reinforcement plate to ensure that the foam is fully seated into its sealed position. 5. Replace the air filter cover so that it fully snaps into place and is secured by the latch tab.
Owner’s Manual MAC 2-CYCLE CULTIVATOR STEPS FOR LONG-TERM STORAGE 1. Mix an appropriate amount of fuel stabilizer to fresh gasoline, in the ratio recommended on the stabilizer packaging. Run the engine for five minutes to distribute the stabilizer mixture throughout the fuel system. This will prevent gum, varnish and corrosion build up in your fuel system during long-term storage for up to 12 months. 2. Store cultivator in the storage position. SEE FIGURE 11. 3.
Owner’s Manual MAC 2-CYCLE CULTIVATOR TROUBLESHOOTING GUIDE TROUBLESHOOTING GUIDE While normal care and routine maintenance will extend the life of your cultivator, prolonged or constant use may eventually require that service be performed to allow it to continue operating properly. The troubleshooting guide below lists the most common problems, causes and remedies. PROBLEM POSSIBLE CAUSE REMEDY/ACTION Engine will not start 1. Power switch off 1. Flip switch to ON or RUN position 2.
Owner’s Manual MAC 2-CYCLE CULTIVATOR BORDER EDGER KIT INSTALLATION (OPTIONAL ACCESSORY) CAUTION BE AWARE THAT THE CULTIVATOR COULD UNEXPECTEDLY BOUNCE UPWARD, OR JUMP FORWARD IF THE TINES STRIKE CONCRETE, PAVEMENT, OR OTHER HARD SURFACES OR HARD OBSTACLES BURIED UNDER GROUND. BORDER EDGER WHEEL The Border-Edger Kit is a useful tool for making clean cuts in the lawn along the borders of gardens, flower beds, walkways, and driveways for a well manicured look.
Owner’s Manual MAC 2-CYCLE CULTIVATOR DRAG STAKE MOUNT KIT INSTALLATION (OPTIONAL ACCESSORY) IMPORTANT THE DRAG STAKE MOUNT KIT IS REQUIRED TO USE THE DK43 DETHATCHER KIT. The Drag Stake Mount Kit is very effective for adding stability and depth control to your cultivator. The Drag Stake Mount Kit is a mandatory accessory for using the DK43 Dethatcher Kit. 1. Flip the ON/OFF switch to the OFF or STOP position. Remove the cultivating tines or other working tools. 2.
Owner’s Manual MAC 2-CYCLE CULTIVATOR DETHATCHER KIT INSTALLATION (OPTIONAL ACCESSORY) LEFT DETHATCHER ASSEMBLY BOLT HAIR PIN IMPORTANT THE DRAG STAKE MOUNT KIT IS REQUIRED TO USE THE DK43 DETHATCHER KIT. The Dethatcher Kit is very effective for lifting away the excessive matted layers of thatch that can prevent moisture, oxygen and nutrients from penetrating the soil and can harbor disease and insects. Use in Spring, Summer, and Fall to bring life and color back to your lawn.
Owner’s Manual MAC 2-CYCLE CULTIVATOR NOTES 22 Get parts online at www.GetEarthquake.
Owner’s Manual MAC 2-CYCLE CULTIVATOR NOTES Get parts online at www.GetEarthquake.
ARDISAM, INC. 1160 Eighth Avenue PO Box 755 Cumberland, WI 54829 Phone: (800) 345-6007 Fax: (715) 822-2124 www.GetEarthquake.
