Operator’s Manual Original Operating Instructions 3365 Series Front-Tine Tiller Model 3365B Briggs & Stratton 6.75 ft-lb Gross Torque Model 3365CE Briggs & Stratton 6.75 ft-lb Gross Torque 3365PSCE Briggs & Stratton 8.5 ft-lb Gross Torque Model 3365PS Briggs & Stratton 6.75 ft-lb Gross Torque GAS/OIL RATIO 50:1 Get parts online at www.getearthquake.com P/N: 14183 ECN: 9633/4 REV2: 01/03/13 © 2013 Ardisam, Inc.
Operator’s Manual Front Tine Tiller 3365 Series INTRODUCTION Congratulations on your investment in quality. Thank you for purchasing an Earthquake™ Front Tine Tiller. We have worked to ensure that your tiller meets the highest standards for usability and durability. With proper care, your front tine tiller will provide many years of service. Read this entire manual before installation and use.
Operator’s Manual Front Tine Tiller 3365 Series WARNINGS AND SAFETY PRECAUTIONS OWNER’S RESPONSIBILITY Accurate assembly and safe and effective use of the rototiller is the owner’s responsibility. • Read and follow all safety instructions. • Carefully follow all assembly instructions. • Maintain the tiller according to directions and schedule included in this Earthquake operator’s manual. • Ensure that anyone who uses the tiller is familiar with all controls and safety precautions.
Operator’s Manual Front Tine Tiller 3365 Series d. Replace gasoline cap securely and clean up spilled fuel before restarting. • IMPORTANT THE RIGHT AND LEFT SIDES OF YOUR ROTOTILLER ARE DETERMINED FROM THE OPERATING POSITION AS YOU FACE THE DIRECTION OF FORWARD TRAVEL. Never attempt to make any adjustments while the engine is running. OPERATION • Do not operate the tiller under the influence of alcohol or drugs. • Never operate the tiller without guards, covers, and hoods in place.
Operator’s Manual Front Tine Tiller 3365 Series SAFETY DECALS This rototiller unit has been designed and manufactured to provide you with the safety and reliability you would expect from an industry leader in outdoor power equipment manufacturing.
Operator’s Manual Front Tine Tiller 3365 Series UNPACKING AND ASSEMBLY IMPORTANT UNPACK TILLER AND ASSEMBLE 1. Open top of carton and remove handlebar assembly. 2. Find parts packet. Parts packet for 3365B/3365CE contains: 6 - 5/16-18 x 1-3/4” bolts 6 - 5/16” spring lock washers 2 - hand knobs 4 - locknuts 2 - hairpins 2 - 12mm flat washers 1 - detent pin L R THE RIGHT AND LEFT SIDES OF YOUR ROTOTILLER ARE DETERMINED FROM THE OPERATING POSITION AS YOU FACE THE DIRECTION OF FORWARD TRAVEL.
Operator’s Manual Front Tine Tiller 3365 Series FEATURES (3365B/3365CE) The advantage of the EARTHQUAKE™ gear drive front tine rototiller over other front tine tillers is the exclusive unfolding and flexible drag bar. This gives the tiller its stability and versatility. For easy transport, fold the wheels under the engine. During operation, the wheels unfold back and the drag bar folds down. The long length between the tines and the drag bar make this the most comfortable front tine tiller on the market.
Operator’s Manual Front Tine Tiller 3365 Series CONTROLS CAUTION DRIVE SAFETY CONTROL LEVER Pulling down on the drive safety control lever engages the tines. Releasing the drive safety control lever disengages the tines to a neutral position. THIS INFORMATION IS PROVIDED HERE ONLY TO INTRODUCE THE CONTROLS. DO NOT START THE ENGINE AT THIS TIME. STARTING AND OPERATING INSTRUCTIONS ARE GIVEN ON PAGE 10. PLEASE READ THIS SECTION AND ALL OPERATING AND SAFETY INSTRUCTIONS BEFORE STARTING YOUR TILLER.
Operator’s Manual Front Tine Tiller 3365 Series OPERATION PRE-START INSPECTION 1. Make sure all safety guards are in place and all nuts and bolts are secure. 2. Check oil level in engine crankcase. See your engine manual for procedure and specifications. 3. Inspect air cleaner for cleanliness. See your engine manual for procedure. 4. Check the fuel supply. Fill the fuel tank no closer than one inch from top of tank to provide space for expansion. See your engine manual for fuel recommendations. 5.
Operator’s Manual Front Tine Tiller 3365 Series For model 3365PSCE only. The controls required to start and run the rototiller are located on the handle. A more detailed description of engine operation and all related precautions and procedures can be found in the engine manufacturer’s manual that accompanies each tiller. COLD STARTS 1. Move the throttle control to the FAST position. WARNING EXTREME CAUTION MUST BE TAKEN IN SELECTING TILLING DEPTH.
Operator’s Manual Front Tine Tiller 3365 Series MAINTENANCE AND STORAGE MAINTENANCE SCHEDULE Your rototiller has been designed and produced by the industry’s leading manufacturer of outdoor power equipment to provide you with years of reliable operation. Keeping your tiller in top running condition will prolong its life, and help you obtain optimum performance. Please read this normal care schedule, and note the recommended care operating intervals to extend the life of your unit.
Operator’s Manual Front Tine Tiller 3365 Series CHECK BELT TENSION Belt tension may decrease over time. It must be adjusted within the first half hour of operation and checked after every two hours of operation. Proper adjustment will assure long belt life. Too much or too little belt tension will cause premature belt failure. To check and adjust the forward belt tension: WARNING CHECK FORWARD BELT TENSION REGULARLY. TOO MUCH OR TOO LITTLE TENSION WILL CAUSE PREMATURE BELT FAILURE. 1. Turn off engine.
Operator’s Manual Front Tine Tiller 3365 Series ENGINE MAINTENANCE Refer to the engine manual included in your parts packet for information on engine maintenance. Your engine manual provides detailed information and a maintenance schedule for performing the following tasks: IMPORTANT ENGINE IS SHIPPED FROM FACTORY WITHOUT OIL. YOU MUST ADD ENGINE OIL BEFORE STARTING ENGINE. 1. Check oil level before each use or after every eight hours of operation.
Operator’s Manual Front Tine Tiller 3365 Series STORAGE WARNING PREPARE FOR STORAGE Follow the steps below to prepare your tiller for storage. Read your engine manual for detailed instructions on preparing the engine for storage. 1. Protect wheels and axles from rust: DO NOT STORE TILLER IN AN UNVENTILATED AREA WHERE FUEL FUMES MAY REACH FLAME, SPARKS, PILOT LIGHTS OR AN IGNITED OBJECT. DRAIN FUEL OUTDOORS AWAY FROM ANY IGNITION SOURCES. USE ONLY APPROVED FUEL CONTAINERS.
Operator’s Manual Front Tine Tiller 3365 Series TROUBLESHOOTING AND REPAIR TROUBLESHOOTING GUIDE While normal care and routine maintenance will extend the life of your rototiller, prolonged or constant use may eventually require that service be performed to allow it to continue operating properly. The troubleshooting guide below lists the most common problems, causes and remedies. WARNING PRACTICE SAFETY AT ALL TIMES.
Operator’s Manual Front Tine Tiller 3365 Series PARTS BREAKDOWN 3365B/3365CE HANDLEBAR PARTS 3 2 4 9 11 10 5 1 7 7 6 12 8 13 REF. NO. PART # DESCRIPTION REF. NO. PART # DESCRIPTION 1 3108A CABLE ASSEMBLY W/FERRULE 2 3170 NUT, PUSH 3/8” DIA.
Operator’s Manual Front Tine Tiller 3365 Series 3365PS HANDLEBAR PARTS 16 15 11 10 12 14 5 13 6 7 8 9 17 19 1 4 3 18 2 REF. NO. PART # DESCRIPTION QTY. 1 1501 BOLT, SOC FLG HEX HD 5/16-18 X 3/4” GR5 4 2 2104 NUT, BI-WAY HEX LOCK 3/8-16 4 3 3108A CABLE ASSEMBLY W/FERRULE 1 4 3358 MOUNT, HANDLEBAR 1 5 3359 HANDLEBAR WELDMENT 1 6 503 BOLT, HH 5/16-18 X 1-1/2” 1 7 504 LOCK WASHER, SPRING 5/16” 2 8 53606 NUT, HEX NYLOC 10-24 1 9 53607 NUT, HEX JAM 5/16-24 2 REF.
Operator’s Manual Front Tine Tiller 3365 Series 3365PSCE HANDLEBAR PARTS 19 18 14 13 15 17 8 2 3 16 9 1 10 11 12 20 22 4 7 6 21 5 REF. NO. PART # DESCRIPTION 1 331059 BOLT, HEX 2 W1265V0913 NUT, HEX 3 3310118 4 REF. NO.
Operator’s Manual Front Tine Tiller 3365 Series TINES & TRANSMISSION PARTS 13 15 1 19 17 14 20 16 7 22 18 17 23 6 3 9 5 4 8 4 2 8 21 11 11 10 21 12 REF. NO. PART # DESCRIPTION 1 1511 BOLT, SFHH 1/4-20 X 7/8” 2 1601 3 QTY. REF. NO. PART # DESCRIPTION QTY.
Operator’s Manual Front Tine Tiller 3365 Series 3365B/3365CE/3365PS/3365PSCE MOTOR MOUNT AND HOOD PARTS 28 46 18 24 48 47 38 45 29 37 44 14 10 38 Model 3365PS, 3365B, 3365CE Drive Pulley 30 1 16 26 15 34 2 35 5 4 23 25 27 36 13 43 40 28 36 33 8 3 17 39 30 42 9 30 41 20 MODEL 3365PS, 3365PSCE BUMPER 22 12 7 21 12 7 6 19 31 11 Check for parts online at www.getearthquake.
Operator’s Manual Front Tine Tiller 3365 Series 3365B/3365CE/3365PS/3365PSCE MOTOR MOUNT AND HOOD PARTS REF. NO. PART # DESCRIPTION REF. NO. PART # DESCRIPTION QTY.
Operator’s Manual Front Tine Tiller 3365 Series FRONT TINE ROTOTILLERS Warranty Terms and Conditions PRODUCT WARRANTY: 1-YEAR LIMITED WARRANTY Ardisam, Inc., a manufacturing company, warrants this EARTHQUAKE™ FRONT TINE ROTOTILLER to be free from defects in the material or workmanship for a period of one year from the date of purchase. During the one-year warranty of this product, Ardisam will furnish, at their discretion, parts and labor to correct any defect caused by faulty material or workmanship.
Operator’s Manual Front Tine Tiller 3365 Series Check for parts online at www.getearthquake.
Earthquake™, Division of Ardisam, Inc. 1160 8th Avenue, PO Box 666 Cumberland, WI 54829 800-345-6007 | Fax 715-822-2223 Email: info@getearthquake.com All weights, specifications and features are approximate and are subject to change without notice. Due to continuous product improvements, product images may not be exact. Items used for props not included. Some assembly may be required. Check for parts online at www.earthquake.
