Operator’s Manual Original Operating Instructions WP4310 43cc Water Pump GAS/OIL RATIO 50:1 Get parts online at www.getearthquake.com P/N: OMWP4310 ECN: 10159 REV 2: 10/08/13 © 2014 Ardisam, Inc.
Operator’s Manual WP4310 43cc Water Pump 2 Check for parts online at www.getearthquake.
Operator’s Manual WP4310 43cc Water Pump INTRODUCTION Congratulations on your investment in quality. Thank you for purchasing a 1-Inch Pump from Earthquake®. We have worked to ensure that the pump meets the highest standards for usability and durability. With proper care, your1-Inch Pump will provide many years of service. Please read this entire manual before installation and use. Earthquake reserves the right to change, alter or improve the product and this document at any time without prior notice.
Operator’s Manual WP4310 43cc Water Pump SAFETY OWNER’S RESPONSIBILITY IMPORTANT SAFETY PRECAUTIONS It is the owner’s responsibility to accurately assemble the pump for safe and effective use. • Read and follow all safety instructions. • Carefully follow all assembly instructions. • Maintain the pump according to directions and schedule included in this Earthquake operator's manual. • Ensure that anyone who uses the pump is familiar with all controls and safety precautions.
Operator’s Manual WP4310 43cc Water Pump ENGINE SAFETY PRECAUTIONS Prevention of Gasoline Fires Warning Carbon Monoxide Poisoning All engine exhaust contains carbon monoxide. Carbon monoxide is a deadly, colorless, tasteless, odorless gas which may be present even if you do not smell or see engine exhaust. Levels of carbon monoxide, which can be deadly, can be present for days in an enclosed area that has poor ventilation.
Operator’s Manual WP4310 43cc Water Pump BURNS AND FIRES The muffler, muffler guard and other parts of the engine become extremely hot during the operation of the engine. These parts remain extremely hot after the engine has stopped. This engine is designed to operate using a catalytic converter which contributes to the engine’s compliance with the EPA. Prevention of Burns and Fires • Never remove the muffler guard from the engine.
Operator’s Manual WP4310 43cc Water Pump MIXING FUEL AND FILLING FUEL TANK CAUTION AVOID INJURY! NEVER STORE ENGINE WITH FUEL IN THE TANK INDOORS. FUEL AND FUEL VAPORS ARE HIGHLY FLAMMABLE. CAUTION AVOID INJURY! NEVER MIX FUEL AND OIL DIRECTLY IN ENGINE FUEL TANK. USE ONLY NONMETAL, PORTABLE FUEL CONTAINERS APPROVED BY THE UNDERWRITER’S LABORATORY (U.L.) OR THE AMERICAN SOCIETY FOR TESTING & MATERIALS (ASTM). CAUTION AVOID INJURY! AN ADULT MUST ALWAYS HANDLE AND FILL THE ENGINE WITH FUEL.
Operator’s Manual WP4310 43cc Water Pump OPERATION STARTING AND STOPPING ENGINE 9. After engine starts running, move choke lever to 1. Move engine to a well ventilated area or outdoor to prevent carbon monoxide poisoning. HALF CHOKE. 10. Move choke lever to OFF or RUN position and move throttle to desired speed. 2. Move to an area away from flames or sparks to avoid ignition of vapors if present. 3. Remove all debris from air cleaner holes and fuel cap to ensure proper air flow.
Operator’s Manual WP4310 43cc Water Pump MAINTENANCE AND STORAGE CAUTION TO PREVENT ACCIDENTAL STARTING: AVOID INJURY! ENGINE MUST BE TURNED OFF AND COOL, AND SPARK PLUG WIRE MUST BE REMOVED FROM SPARK PLUG BEFORE CHECKING AND ADJUSTING ENGINE OR EQUIPMENT. CAUTION AVOID INJURY! TEMPERATURE OF MUFFLER AND NEARBY AREAS MAY EXCEED 150° F (65° C). AVOID THESE AREAS. CAUTION AVOID INJURY! CHECK PUMP OFTEN FOR LOOSE NUTS AND BOLTS. KEEP THESE ITEMS TIGHTENED. PUMP MAINTENANCE 1.
Operator’s Manual WP4310 43cc Water Pump Cooling Fins • Cooling fins, air inlets and linkages must be free from any debris before each use. Air Filters • Never run engine without air cleaner properly installed. Added wear and engine failure may occur if air cleaner is not installed on engine. • Service air cleaner every 3 months or after 20 hours of operation. Clean more frequently if engine is operated in extremely dusty conditions. Steps for Cleaning Air Filters TRANSPORTING YOUR WATER PUMP 1.
Operator’s Manual WP4310 43cc Water Pump SERVICE, TROUBLESHOOTING AND REPAIR SERVICE INFORMATION ORDERING REPAIR PARTS Parts can be obtained from the store where your water pump was purchased or direct from the factory. To order from the factory, call or write to: IN CASE OF A SERVICE PROBLEM, DO NOT SEND UNIT BACK TO RETAILER. CONTACT ARDISAM, INC. AT 800-345-6007. WE WELCOME YOUR CALL. At Ardisam, we build quality and durability into the design of our products.
Operator’s Manual WP4310 43cc Water Pump SERVICE, TROUBLESHOOTING AND REPAIR CAUTION PRACTICE SAFETY AT ALL TIMES. ENGINE MUST BE TURNED OFF AND ALLOWED TO COOL, AND SPARK PLUG WIRE MUST BE DISCONNECTED BEFORE ATTEMPTING ANY MAINTENANCE OR REPAIR. TROUBLESHOOTING Problem Possible cause Engine will not start 1. Power switch off 2. Spark plug wire disconnected 3. Spark plug has no spark 1. Flip switch to on position 2. Connect spark plug wire to spark plug 3.
Operator’s Manual WP4310 43cc Water Pump WP4310 WATER PUMP ENGINE BREAKDOWN Check for parts online at www.getearthquake.
Operator’s Manual WP4310 43cc Water Pump 10 23 24 25 33 29 30 29 28 14 34 3 2 3 42 2 3 4 1 9 5 6 7 40 39 8 10 9 41 11 12 35 2 4 14 2 3 4 6 16 16 15 17 23 19 20 24 21 22 25 31 26 43 27 31 28 32 36 37 10 WP4310 WATER PUMP BREAKDOWN Check for parts online at www.getearthquake.
Operator’s Manual WP4310 43cc Water Pump WP4310 WATER PUMP PARTS LIST MINIMUM ORDER............................................................................................................$10.
Operator’s Manual WP4310 43cc Water Pump NOTES 16 Check for parts online at www.getearthquake.
Operator’s Manual WP4310 43cc Water Pump WARRANTY TERMS AND CONDITIONS PRODUCT WARRANTY: 1-YEAR LIMITED WARRANTY Ardisam, Inc. (Ardisam) warrants the product(s) under a one-year limited warranty to be free from defects in the material or workmanship or both for a period not exceeding twelve consecutive months from the date of original purchase by the first retail consumer or first commercial end user. “Consumer use“ means personal recreational use by a retail consumer.
Operator’s Manual WP4310 43cc Water Pump FEDERAL EMISSIONS CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGATIONS The United States Environmental Protection Agency (EPA), together with Ardisam, Inc. (Ardisam), are pleased to explain the Emission Control System Warranty on your small off-road engine (SORE). New small off-road engines must be designed, built and equipped to meet stringent anti-smog standards the federal government.
Operator’s Manual WP4310 43cc Water Pump shall be warranted for the ECS Warranty Period. A statement in such written instructions to the effect of “repair or replace as necessary” shall not reduce the ECS Warranty Period. Any such part repaired or replaced under the ECS Warranty shall be warranted for the remainder of the ECS Warranty Period.
Earthquake®, Division of Ardisam, Inc. 1160 8th Avenue, PO Box 666 Cumberland, WI 54829 800-345-6007 | Fax 715-822-2223 E-mail: info@getearthquake.com All weights, specifications and features are approximate and are subject to change without notice. Due to continuous product improvements, product images may not be exact. Items used for props not included. Some assembly may be required. Check for parts online at www.getearthquake.
