Drawing : - TPC224 Issue :-7 Date : - 10/12/13 TRITON INDUSTRIAL DEHUMIDIFIER OWNER’S MANUAL www.eipl.co.
Drawing : - TPC224 Issue :-7 Date : - 10/12/13 TRITON PACKAGE CONTENTS Item Description Quantity 11393GR-US Dehumidifier 1 3086144 Quick release hose coupling 1 3944110 PVC Tube – 3/8” I/D 7.
Drawing : - TPC224 Issue :-7 Date : - 10/12/13 INTRODUCTION Designed for a wide range of applications, the Triton dehumidifier is a super high capacity industrial unit which provides fast and efficient drying.
Drawing : - TPC224 Issue :-7 Date : - 10/12/13 SPECIFICATIONS MODEL: TRITON HEIGHT: 29” (736mm) WIDTH: 20” (508mm) DEPTH: 15” (381mm) WEIGHT: 75 lbs (34Kg) AIRFLOW: 282 CFM (476 M3/hr) POWER SUPPLY: 110V/ 60Hz/ 1 ph FINISH: Powder-coated Epoxy OPERATING RANGE: 33°F – 95°F REFRIGERANT: R-407c (16.2 oz) "This product contains fluorinated greenhouse gases covered by the Kyoto Protocol. The refrigeration system is hermetically sealed.
Drawing : - TPC224 Issue :-7 Date : - 10/12/13 OPERATION The following procedures should be followed to test the Triton for correct operation: 1. After unpacking, examine all external features to confirm damagefree shipment. Report all defects and damage at once. Connect the power cable to a grounded 15 Amp electrical outlet. 2. Check dehumidification process as follows: CAUTION: DO NOT REMOVE COVERS WHEN UNIT IS IN OPERATION A. Place unit on a level surface. B. Start up unit by switching to “ON”. C.
Drawing : - TPC224 Issue :-7 Date : - 10/12/13 ROUTINE MAINTENANCE WARNING: ENSURE THAT THE POWER CORD TO THE MACHINE HAS BEEN DISCONNECTED BEFORE CARRYING OUT ROUTINE MAINTNENANCE To ensure continued full efficiency of the dehumidifier, maintenance procedures should be performed as follows: 1. Replace or clean the inlet air grille as required. Clean the surface of the evaporator and condenser coils by blowing the dirt out from behind the fins with compressed air.
Drawing : - TPC224 Issue :-7 Date : - 10/12/13 REPAIRS 1. Should an electrical component fail, consult the Factory Service Center to obtain the proper replacement part. 2. If refrigerant gas is lost from the machine, it will be necessary to use a refrigeration technician to correct the fault. Contact the Factory Service Center prior to initiating this action. Any competent refrigeration technician will be able to service the equipment. The following procedure must be used: a.
Drawing : - TPC224 Issue :-7 Date : - 10/12/13 TROUBLESHOOTING SYMPTOM CAUSE Unit inoperative 1. No power to unit Little or no airflow 1. Loose fan on shaft 2. Fan motor burnt out 3. Dirty refrigeration coils 4. Loose electrical wiring Little or no water extraction 1. Insufficient air flow 2. Compressor fault 3. Loss of refrigerant gas Little or no defrost when required 1. Faulty timer 2. Faulty by-pass valve Unit vibrates excessively 1. Loose compressor 2.
Drawing : - TPC224 Issue :-7 Date : - 10/12/13 TRITON SPARE PARTS LIST DESCRIPTION NUMBER PART NUMBER QUANTITY Compressor 1 (RGA5456EXA) 3022170 1 N/A 1 3030908 1 Compressor Overheat 2 Protector 3 Compressor Capacitor Evaporator/Condenser 4 Coil 2139330 1 5 Grille Filter 2013831 1 6 Filter Dryer 3020901 1 7 Fan Motor 3035788 1 8 By-pass Valve 3020811 1 9 Electronic Timer 1609850 1 10 Axial Fan 3040129 1 11 Rocker Switch 3035914 1 12 Thermistor Assy 3035142
Drawing : - TPC224 Issue :-7 Date : - 10/12/13 20 Wheel 3050110 2 21 1” Starlock Washer 3082601 4 22 Condensate Pump 3160129 1 23 Purge Switch 3036779 1 24 Quick Disconnect 3086144 1 25 Snap Hose Clip 3086135 1 26 Hose Clip Snapper 3086136 1 27 Self Locking Pin-1/4x1.5 3087723 1 Spare parts available online www.EIPLDIRECT.
Drawing : - TPC224 Issue :-7 Date : - 10/12/13 Ebac LIMITED WARRANTY Our products carry a one-year unconditional warranty against any defects in workmanship or material. This warranty will cover all parts and labour required to repair your Ebac product. This warranty is invalid if the unit has been abused, damaged, whether intentional or accidental, or if any modifications have been made to the unit.
Drawing : - TPC224 Issue :-7 Date : - 10/12/13 Page 12 of 16
Drawing : - TPC224 Issue :-7 Date : - 10/12/13 Page 13 of 16
Drawing : - TPC224 Issue :-7 Date : - 10/12/13 Page 14 of 16
Drawing : - TPC224 Issue :-7 Date : - 10/12/13 Page 15 of 16
Drawing : - TPC224 Issue :-7 Date : - 10/12/13 UK Head Office American Sales Office German Sales Office Ebac Industrial Products Ltd St Helens Trading Estate Bishop Auckland County Durham DL14 9AD Ebac Industrial Products Inc 700 Thimble Shoals Blvd. Suite 109, Newport News Virginia, 23606-2575 USA Ebac Industrial Products Ltd. Gartenfelder Str.
