Use and Care Manual

MAINTENANCE PAS-2620

24 X7502342500

IMPORTANT NOTE - Time intervals shown are maximum. Actual use and

your experience will determine the frequency of required maintenance.

MAINTENANCE PROCEDURE NOTES:

1Apply lithium based grease every 25 hours of use.

2Apply lithium based grease every 50 hours of use.

3Low evaporative fuel tanks DO NOT require regular maintenance to main-

tain emission integrity.

*Replacement is recommended based on the finding of damage or wear

during inspection.

Air Filter

Level 1

1. Close choke (COLD START [ ] position). This prevents dirt from

entering the carburetor throat when the air filter is removed. Brush

accumulated dirt from air cleaner area.

2. Remove air filter cover. Brush dirt from inside cover.

3 Months

Air Filter

Replace* 1

Fuel Filter

Inspect* 1

Fuel Cap Gasket

Inspect* 1

Spark Plug

Inspect/Clean/Replace* 1

Muffler Spark Arrestor

Inspect/Clean/Replace* 2

Cylinder Exhaust Port

Inspect/Clean/De-carbon 2

Drive Shaft (Flex Cable Models)

Grease1 2

Gear Housing Grease2 2

Yearly

Fuel Filter

Inspect/Replace* 1

Fuel Cap Gasket

Replace* 1

Parts Required: Tune Up Kit.

COMPONENT/SYSTEM

MAINTENANCE

PROCEDURE

REQ’D

SKILL

LEVEL