Troubleshooting guide

G
lass top
Glass topGlass top
Glass top
• P
ersistent stains may require vigorous rubbing with nylon
scourer or creamed powder cleansers. Household enamel
cleaners are available, follow the manufacturer instructions
in their use. Harsh abrasive cleaners, powder cleaners,
steel wool or wax polishes should not be used.
• Do not use the glass top as a work table.
Burner caps & crowns
Burner caps & crownsBurner caps & crowns
Burner caps & crowns
• These can all be lifted off and removed for separate
cleaning.
• Ensure burner caps and crowns are thoroughly dried
after cleaning or spillage.
• When cleaning the burner, ensure that all the flame ports,
injector hole and other holes are free of any blockage.
(Fig 13,14)
•
I
f necessary, use a matchstick or brush tocar ports.
• A
fter cleaning, ensure the burner caps are
reassembled properly into position.
• After cleaning service, when assembling the burner
crown and caps, care must be taken to ensure the spark
plug is not knocked. The spark plug will crack if knocked
and may give rise to flame ignition problem.
What to do if
Phenomenon Reason Solution
Burner will not light...
Air in gas line Purge gas line
Blockage
in lin
e
Tr
ace
back
&
c
l
ear
Ignition not sparking Check lead & electrode
Battery is dead Replace battery
Burner not fitted correctly Fit burner in correct position
Burner lights back to injector...
Excessive lint up of
burner
Excessive gas pressure
mixing tube Remove & clean burner
Check gas regulator pressure &
adjust if necessary
Burner has explosive ignition...
Excessive gas pressure Check gas regulator pressure &
adjust if necessary
lgnitor not sparking...
Electrode gap excessive
lgnitor connections loose
Battery is dead
Check gap, adjust if not between
4-5 mm
Check connections to ignitor,
replace if faulty
Change a new battery
WARNING:-
Do not spray aerosols in the vicinity of this hob while in operation. Some propellant gases can break down when
heated and produce corrosive vapours which will attack some materials.
Articles which are made from flammable materials should not be stored in drawers or cupboards immediately below
this hob.
Do not store articles within 50mm of the base.
Do not touch spark ignitor while lighting the burner.
Where this appliance is installed in a marine craft or in caravans, it shall not be used as a space heater.