RENOWN SI 50 Owners handbook and Installation instructions
iot n u c RENOWN SI 50 Introduction nI This gas cooker has been designed and manufactured to all the necessary British Standards. It also carries the C.E. mark. The cooker complies with European Council Directive 90/396/EEC. It is important that you understand how to use and care for the cooker properly before you use it for the first time. We have written this booklet with your safety in mind. Read the booklet thoroughly before you use the cooker.
Contents Contents RENOWN SI 50 Page Lighting the cooker 4 The grill 7 The hotplate 9 The oven 12 Oven cooking chart 15 Slow cooking 18 Care and cleaning 20 Installing the cooker 23 General information 25 What is wrong and why? 27 Servicing 28 Installation Instructions 29 Technical data 30 Safety requirements/ventilation 31 Location of appliance/installation 32 Testing 34 3
Lighting the cooker RENOWN SI 50 Lighting the cooker The ignition system works by means of a battery. Details on how to replace the battery are given on page 25. Hotplate To light Push in the control knob and turn to the large flame symbol (highest setting), and press the ignition button immediately. When the burner has lit release the button. Warning: If the ignition button is not pressed immediately a build up of gas may cause the flame to spread.
Grill To light: 1 Push in the control knob and turn it to the large flame symbol (highest setting), and press the ignition button immediately. When the burner has lit release the button. Warning: If the ignition button is not pressed immediately a build up of For your safety gas may cause the flame to spread from the grill cavity. Never cover the grill pan or grid with foil as this can lead to grill fires. Oven To light: 1 Open the oven door.
Lighting the cooker RENOWN SI 50 To turn off any burner 1 Push in the control knob and turn it to the off position. This is shown by a large dot. For your safety When you are lighting any burner check that it has lit before you leave the cooker. When you are turning off a burner, do not leave the cooker until the flame has gone out.
The grill The grill is a high-speed grill. The instructions below tell you how to vary the heat setting and how to change the height of the grid to suit the food you are cooking. You should remember to turn the food regularly. You should not use the grill to keep food warm as it will continue to cook the food. For your safety You must keep the grill door open when the grill burner is lit. Caution Accessible parts may be hot when the grill is used. Young children should be kept away.
The grill RENOWN SI 50 General Natural Gas Models only The grill pan handle can be removed. To put the handle on to the pan you should put the chrome bracket over the cut out in the pan and then slide the handle on to the left as far as the bump on the pan. When you are not using the grill you should remove the handle and store the pan on the shelf in the grill. Turn the grill burner off before you store the pan. Remember that the pan will get hot when you are using the oven. L.P.
The hotplate If you have any trouble lighting a hotplate burner turn all hotplate control knobs off and make sure the hotplate burner parts have been replaced correctly. See page 21 for more information. Heat control The hotplate control knobs turn to the left from 'OFF' to 'HIGH' and then to 'LOW'. You can adjust the heat by turning the control between the highest and lowest settings. These are shown as a large and a small flame symbol.
The hotplate RENOWN SI 50 For your safety 1 Take care to avoid burns and scalds when you are reaching across the hotplate. 2 Use pans with flat bases. They are more stable than pans which are warped. 3 Do not use pans with very heavy handles which cause the pan to tip. 4 Put pans on the centre of the burners. 5 Position pan handles so they cannot be accidentally knocked. 6 Take extra care when you are deep fat frying. Do not cover the pan with a lid. Do not leave a pan unattended.
Helpful hints 1 Keep flames under the base of the pans. If the flames lick round the sides of the pans you are wasting gas. 2 Only heat the amount of liquid you need. Do not overfill pans. 3 Cover pans with a lid whenever possible. The food will heat up more quickly and there will be less steam in the kitchen. 4 Try cooking more than one vegetable in the same pan, for example potatoes and carrots. 5 Cut vegetables into smaller pieces. This way they will cook more quickly.
The oven RENOWN SI 50 The oven Before you use the oven you should wipe it out with a damp cloth to remove any dust. Heat zones There are zones of heat within the oven. The temperature in the middle is the gas mark you have chosen. The top of the oven is slightly hotter and the lower shelf slightly cooler. The base of the oven is quite a lot cooler. You can make use of these heat zones when you are cooking foods that need different temperatures all at the same time.
Baking trays and dishes For your safety Never place cooking dishes, trays and so on over the oven burner. This will damage the cooker as well as the ovenware and possibly the floor covering underneath the cooker. Leave a gap of 13mm (½") between all dishes and the sides of the oven so the heat can circulate properly. Do not push dishes too far back as food will burn if it overhangs the burner flames. For the best results we recommend that you use a baking tray which is 310mm (12") square.
The oven RENOWN SI 50 Condensation Condensation may form on the cooker. This is quite normal and nothing to worry about. The condensation forms when heat and moisture are present, for example during cooking. Whenever possible try to make sure that food which contains a lot of moisture, for example casseroles, are covered. If you do notice any condensation, wipe it up straight away.
Oven cooking chart Shelf position Approximate cooking time Beef 5 4 Rare: Medium: Well Done: 20 mins. per ½kg (1lb) and 30 mins. 25 mins. per ½kg (1lb) and 25 mins. 30 mins. per ½kg (1lb) and 30 mins. Lamb 5 4 Medium: Well Done: 25 mins. per ½kg (1lb) and 25 mins. 30 mins. per ½kg (1lb) and 30 mins. Pork and Veal 5 4 Medium: Well Done: 30 mins. per ½kg (1lb) and 30 mins. 35 mins. per ½kg (1lb) and 35 mins.
Oven cooking chart Gas mark Shelf position Approximate cooking time Chicken Turkey below 4.5kg (10lbs) over 4.5kg (10lbs) Duck and duckling 5 4 4 5 4 4 4 or 5 4 20 mins. per ½kg (1lb) and 20 mins. 25 mins. per ½kg (1lb) and 25 mins. 15 mins. per ½kg (1lb) and 15 mins. 25 mins. per ½kg (1lb) Stuffed poultry Cook as above but calculate weight including stuffing. Food Poultry: The times given above are for open roasting in a preheated oven.
Food Gas mark Shelf position Approximate cooking time Plate tart (shortcrust) Fruit pie (shortcrust) Mince pies (flan pastry) 6 6 5 2 2 2&4 25 -35 mins. 25-35 mins. 15-25 mins. Puddings: Milk pudding Baked sponge pudding Baked custard 2 4 3 3 4 4 2 hrs. 45-60 mins. 50-60 mins. Yeast mixtures: Bread 0.45kg (1lb loaves) 0.90kg (2lb loaves) Rolls and buns 8* 8* 8* 3 3 2 30-40 mins. 30-40 mins. 10-20 mins.
Slow cooking RENOWN SI 50 Slow cooking The slow cook setting gives a very low heat in the oven. It is particularly useful when cooking soups, stews and casseroles because the long slow cooking will make cheaper, tougher cuts of meat more tender. You need to cook food at gas mark 6 for 30 minutes before you turn the oven down to a slow cook setting. This makes sure that the temperature of the food gets hot enough to start the food cooking.
Soups, casseroles and stews l l l Do not cook casseroles over 3kg (6lb). Bring to the boil on the hotplate then cook on slow cook. Cook in the middle of the oven or above. Vegetables l l l l Cut into small pieces. Dried beans must be pre-soaked then boiled in an open pan for 15 minutes before adding to any dish. Place vegetables under meat in casseroles. Cook for 30 minutes at gas mark 6, then reduce to the slow cook setting.
Care and cleaning RENOWN SI 50 Care and cleaning For your safety For hygiene and safety reasons you must keep this gas cooker clean. A build up of fat or other foodstuff could cause a fire. Try to mop up spills and splashes as soon as they happen. But be careful as parts of the cooker will be hot. Do not use any polishes, caustic cleaners, abrasives, washing soda or soap except those recommended.
You can wash the removable parts in very hot soapy water. You may use mild abrasives. Make sure that the electrode and the hole and slots in the crown are not blocked with food or cleaning materials. Clean the burner crowns by soaking them in very hot soapy water. You can remove any stubborn stains by scouring with a soap filled pad such as 'Brillo'. If you look after the burner crowns in this way they will stay reasonably clean. However the surface will dull with time.
Care and cleaning RENOWN SI 50 The oven The inside of the oven is finished in vitreous enamel. You should clean the oven regularly using hot soapy water and mild abrasives or a soap filled pad such as 'Brillo'. If you use any oven cleaners they must have the Vitreous Enamel Development Council (VEDC) seal of approval. Follow the instructions on the cleaning agent and protect the oven burner with aluminium foil to prevent it becoming blocked.
Installing the cooker For your safety This cooker must be installed and serviced by a competent person as stated in the Gas Safety (Installation & Use) regulations current editions. It is important that the cooker is suitable for your gas supply. Your installer should check the data badge. Ensure that a stability bracket is fitted. Location For your safety The use of a gas cooking appliance results in the production of heat and moisture in the room in which it is installed.
Installation RENOWN SI 50 Positioning The diagram shows how close to the cooker cupboards, shelves, curtains and so on can be fitted. Check the diagram and carefully read the instructions to make sure your cooker is fitted safely. If you are in doubt your installer will give you advice. Do not fit any materials which may catch fire for example wood or curtains behind the cooker. l l l l Base units which are higher than the hotplate must be 100mm away.
General information For your safety Do not block any of the cooker vents. Never line any part of the cooker with aluminium foil. Don't let items which can catch fire or electric mains leads such as kettle flexes trail over any part of the cooker. Moving your cooker You may damage some soft or badly fitted floor coverings when you move the cooker. The floor covering under the cooker should be securely fixed so it does not ruck up when you move the cooker across it.
General information RENOWN SI 50 For your safety Do not try to disconnect the cooker from the gas supply if the supply pipe does not have a bayonet connection, as described in the installation instruction. If this is the case contact the person who installed the cooker. Reversing the oven door You can turn the oven door around so that it opens on the other side. Your supplier can arrange this.
?y RENOWN SI 50 What is wrong and why? d w h a n We strongly recommend that you carry out the following checks on your cooker before calling a Service Engineer. w or n g Problem The oven, grill or hotplate will not light. si Check h l l l If only the hotplate burners will not light make sure that the burner parts have been placed correctly. See instructions on page 21.
g RENOWN SI 50 vr ic ni Servicing e S For your safety Maintenance work must only be done by a competent person. Do not try to repair the cooker yourself. This could be dangerous. It is dangerous to alter or modify the product in any way. We recommend that your cooker has an annual gas safety check carried out by our approved service organisation. Before you call a service engineer check through the 'What is wrong and why?' information on page 27.
RENOWN SI 50 INSTALLATION INSTRUCTIONS Serial number on front frame. Data badge on top rear of panel. For your safety Natural Gas and L.P. Gas versions of this appliance are available. Check that this model is suitable for the type of supply available. In the interest of safety this appliance must be installed and/or serviced by a competent person, as stated in the Gas Safety (Installation and Use) Regulations Current Editions.
R E N O W N S I 50 TECHNICAL DATA DIMENSIONS Height to hotplate Space for fixing at hotplate level Minimum space above hotplate Space for fixing above hotplate level Weight of appliance Minimum distance from rear wall Height 907mm (nominal) Width 498mm Depth 600 mm (to front of door panel) 2mm minimum clearance 787mm (If a cooker hood is fitted refer to the cooker hood installation instructions). See important note "Location of Appliance", page 32. 48.4kg.
R E N O W N S I 50 MAIN OVEN Heat Input Injector Marking Flame Supervision Device Thermostat Thermostat By-pass Marking Natural Gas 2.4kW (8189Btu/h) 108 Diamond'H' GSD 100/28 Diamond'H' 1100 126/B2 69 L.P. Gas 2.4kW (172.4 g/h) 78 Diamond 'H' GSD-100-30 Diamond'H' 1100-98/B2 78 GENERAL Ignition Spark Gap H. T. Spark 3-4mm IMPORTANT - SAFETY REQUIREMENTS This appliance must be installed in accordance with the Gas Safety (Installation and Use) Regulations Current Editions.
R E N O W N S I 50 LOCATION OF APPLIANCE 787 787 This appliance must not be installed in a bed-sitting room of volume less than 20m³ or in a bathroom or shower room. It is essential that the appliance is positioned as stated below (see Fig 1) i.e. shelves, wall cabinets and cooker hoods must be fitted a minimum of 787mm directly above the top of hotplate and 400mm above the hotplate when fitted in line with the outside of the appliance.
R E N O W N S I 50 2. LEVELLING THE APPLIANCE Adjustable levelling feet at the front and at the rear are provided on the base of the appliance. Adjustment to suit floor conditions is obtained by rotating in or out the hexagonal feet from the underside of the appliance. A spirit level should be placed on one of the oven shelves to confirm that the appliance is correctly levelled. 3.
R E N O W N S I 50 Fig.4 400 700 The gas bayonet connector must be fitted in the shaded area indicated in Fig. 4. Take into account that it must be possible to pull the appliance forward sufficiently. The hose must not get caught on the stability bracket. IMPORTANT: FLEXIBLE TUBING USED MUST COMPLY WITH BS. 669 CURRENT EDITION. L.P.G. FLEXIBLE CONNECTIONS MUST BE OF A TYPE SUITABLE FOR L.P.G. AND CAPABLE OF OPERATION UP TO 50 mbar AND TO CARRY A RED STRIPE, BAND OR LABEL.
R E N O W N S I 50 9. CHECKING THE MAIN OVEN 1. Turn the oven thermostat knob to Mk 9 and press the ignition button. As soon as the burner is alight the button can be released. There should now be a low gas rate to the burner, which is the F.S.D. by pass rate. When the F.S.D. phial has heated up it opens the F.S.D. valve which allows the main gas supply to the oven burner. Set the oven control to Mk 2, close the oven door and check that after about 10 minutes the flame size has reduced.
RENN OO WTNESSI 50
RENN OO WTNESSI 50 37
RENN OO WTNESSI 50 RENOWN 50 SI - 311475201 38
Contents Check List No. OFF DESCRIPTION 2 Oven Shelves 1 P.C. Guarantee Card 1 Hotplate Operation Card 1 Grill Pan Trivet (small wire) 1 Grill Pan ( fixed handle) (L.P. Gas model only) 1 Red Screw Pack (L.P.
This handbook was correct on the date it was printed. But this handbook will be replaced if the specification or appearance change as the cooker is improved. Description No. Off Maker's Part Number 1 2 1 1 1 2 1 2 354000610 354000609 354000608 359039100 337000302 337000402 337000502 359033202 Burner Cap - Rapid Burner Cap - Normal Burner Cap - Simmer Burner Crown - Rapid - N.G. Burner Crown - Rapid - L.P.G.