Specifications

ManualsBrandsEljer ManualsHome building and Decor015-0005

INSTALLATION, OPERATING & MAINTENANCE

INSTRUCTIONS FOR PREMIERE SERIES

WHIRLPOOLS

SAVE THIS MANUAL - LEAVE WITH WHIRLPOOL OWNER FOR FUTURE USE

Date Purchased __________________ Purchased From ________________________________________________________

Installed by ________________________________________ Model Name and Number _________________________________

READ THESE INSTRUCTIONS COMPLETELY BEFORE INSTALLING THE PRODUCT. IF YOU

HAVE ANY QUESTIONS CALL 1-800-423-5537.

YOU MUST FOLLOW ALL INSTRUCTIONS IN THIS MANUAL. FAILURE TO FOLLOW AND

COMPLY WITH ALL INSTRUCTIONS WILL RESULT IN YOUR ASSUMPTION OF LIABILITY AND

CAN RESULT IN PRODUCT DAMAGE, PROPERTY DAMAGE AND/OR PERSONAL INJURY.

THIS PRODUCT COMPLIES WITH MANY NATIONALLY RECOGNIZED STANDARDS SUCH AS

ANSI Z124.1- 9, ASME A112, IAPMO AND UL 1795. YOU ARE RESPONSIBLE FOR ANY LOCAL

CODES THAT MAY APPLY.

THIS PRODUCT IS DESIGNED TO BE INSTALLED BY A LICENSED TRADESMEN.

LICENSED PLUMBERS AND ELECTRICIANS SHOULD BE EMPLOYED TO ENSURE PROPER

INSTALLATION. INSTALLERS ASSUME ALL LIABILITY FOR THE CORRECT INSTALLATION

PROCEDURES.

ONLY ACCESSORIES AUTHORIZED BY THE MANUFACTURER SHOULD BE USED WITH THIS

PRODUCT.

THIS PRODUCT IS DESIGNED FOR RESIDENTIAL USE AND USE BY HEALTHY INDIVIDUALS.

WARNING: TO REDUCE THE RISK OF INJURY, DO NOT PERMIT CHILDREN TO USE THIS

PRODUCT UNLESS THEY ARE CLOSELY SUPERVISED AT ALL TIMES.

IMPORTANT SAFETY INSTRUCTIONS:

WARNING! WHEN USING THIS PRODUCT, BASIC PRECAUTIONS

SHOULD ALWAYS BE FOLLOWED. READ AND FOLLOW ALL

INSTRUCTIONS PERTAINING TO RISK OF FIRE, ELECTRIC SHOCK,

OR INJURY TO PERSONS

WARNING: RISK OF ACCIDENTAL INJURY OR DROWNING; CHILDREN SHOULD NOT USE HYDRO-

MASSAGE BATHTUB WITHOUT ADULT SUPERVISION.

REV. 07-16-2008

-1-

Summary of content (9 pages)

PAGE 1
INSTALLATION, OPERATING & MAINTENANCE INSTRUCTIONS FOR PREMIERE SERIES WHIRLPOOLS SAVE THIS MANUAL - LEAVE WITH WHIRLPOOL OWNER FOR FUTURE USE Date Purchased __________________ Purchased From ________________________________________________________ Installed by ________________________________________ Model Name and Number _________________________________ READ THESE INSTRUCTIONS COMPLETELY BEFORE INSTALLING THE PRODUCT. IF YOU HAVE ANY QUESTIONS CALL 1-800-423-5537.
PAGE 2
WARNING: RISK OF ACCIDENTAL INJURY OR DROWNING; DO NOT USE HYDROMASSAGE BATH- TUB UNLESS ALL SUCTION GUARDS ARE INSTALLED TO PREVENT BODY AND HAIR ENTRAPMENT. WARNING: TO AVOID INJURY, EXERCISE CARE WHEN ENTERING OR EXITING THE HYDROMASSAGE BATHTUB. WARNING: RISK OF ACCIDENTAL INJURY OR DROWNING; DO NOT USE DRUGS OR ALCOHOL BEFORE OR DURING THE USE OF A HYDROMASSAGE BATHTUB EQUIPPED WITH HEATER TO AVOID UNCONSCIOUSNESS AND POSSIBLE DROWNING.
PAGE 3
• NEVER consume alcoholic beverages or drugs before or during the whirlpool tub use. • ALWAYS fill the tub to at least 3” above the highest jet prior to activating the whirlpool system. • The whirlpool tub is not designed to hold water continuously like pools or spas. • It is recommended not to use the whirlpool bath immediately after eating, particularly large meals. • It is advisable to keep a glass of cold water or non-alcoholic beverage near the whirlpool bath.
PAGE 4
Installation Procedures Installation must comply with local and national codes. INSTALLATION PLANNING AND PREPARATION 1. NEVER LIFT THE TUB BY THE PLUMBING. Doing so can result in leaks. 2. Check if the floor is level and of good quality. An uneven floor may impede proper installation of the product. The floor structure must be capable of supporting at least 100 pounds per square foot. a. Clean the area of any debris or trash. b. Use a 5 or 6 foot level and determine if the floor is level.
PAGE 5
2. Construct support framing (see WARNING next to diagram below) for the tub, allowing for a 16” X 20” access opening for servicing the pump/motor on whirlpool models. 3. DECK / PENINSULAR INSTALLATION - Deck surface can be any width. Allow for the thickness of the wall board and tile or other surface material between the deck (see “Height to Lip” illustration D & F above) and underside of the tub lip. 4.
PAGE 6
1.To install an in line heater, simply saw or cut out the center portion of the red heater blank at the breaking lines. The threaded pieces should remain on both sides of the pipe section. 2. Insert the in line heater and tighten the unions of the in line heater to the remaining threaded portion of the heater blank. Cleaning and Maintenance Pump and pipe circulation system should be flushed before first use and on a monthly basis when product is under normal use.
PAGE 7
TOTAL MASSAGE AND AIR BATH CONTROL PAD Total Massage units are a combination of a whirlpool and air bath. The Total Massage control pad contains six (6) buttons. The top three controls on the “Therapy Control Center” operate the whirlpool and the bottom three controls operate the air system. The whirlpool and air massages systems may be used at the same time if desired. The air bath is controlled by a three button control: 1. The first button switches the blower on or off.
PAGE 8
Whirlpool Troubleshooting (continued) WATER LEAKS: 1. Check compression fittings (union connectors) making sure they are properly aligned and secured. HAND TIGHTEN ONLY. DO NOT USE ANY TOOLS. 2. Make sure the O-ring is properly seated and not damaged. Do not run any pumps or heaters unless the tub is filled with water to a proper level. Damage due to dry running pumps is not covered under warranty.
PAGE 9
LIMITED WHIRLPOOL WARRANTY ELJER, INC. (“Eljer”, “we”, “us”, “our”) warrants to the original consumer/purchaser that the products covered below are free from defects in material and workmanship limited by time, remedy and the disclaimers indicated below. The Eljer, Inc. Limited Warranty will be effective upon receipt by Eljer, Inc., within 30 days of purchase, of a properly completed warranty registration card and a copy of the sales receipt.