Installation Sheet

ManualsBrandsElkay ManualsDrinking FountainsElkay 12-3/4" Outdoor Floor Mounted Single Drinking Station with Freeze Resistance - Vandal Resistant Bubbler

PAGE 1 96812C (Rev. SID - 1/11)

4590FR_FTN LK4590FR_FTN LK4590SFR_FTN

Owners Manual

4590 Freeze Resistant Barrier Free Stone Pedestal Fountain

4590 Fountains are among the easiest to install Fountains on the market today. To assure you

install these models easily and correctly, PLEASE READ THESE SIMPLE INSTRUCTIONS

BEFORE STARTING THE INSTALLATION. CHECK YOUR INSTALLATION FOR COMPLIANCE

WITH PLUMBING, ELECTRICAL, AND OTHER APPLICABLE CODES. After installation, leave

these instructions with the Fountain for future reference.

IMPORTANT

ALL SERVICE TO BE PERFORMED BY AN AUTHORIZED SERVICE PERSON

IMPORTANT

THE GROUNDING OF ELECTRICAL EQUIPMENT SUCH AS TELEPHONE, COMPUTERS, ETC. TO WATER LINES IS A

COMMON PROCEDURE. THIS GROUNDING MAY BE IN THE BUILDING OR MAY OCCUR AWAY FROM THE BUILDING. THIS

GROUNDING CAN CAUSE ELECTRICAL FEEDBACK INTO A FOUNTAIN, CREATING AN ELECTROLYSIS WHICH CAUSES A

METALLIC TASTE OR AN INCREASE IN THE METAL CONTENT OF THE WATER. THIS CONDITION IS AVOIDABLE BY USING

THE PROPER MATERIALS AS INDICATED. ANY DRAIN FITTINGS PROVIDED BY THE INSTALLER SHOULD BE MADE OF

PLASTIC TO ELECTRICALLY ISOLATE THE FOUNTAIN FROM THE BUILDING PLUMBING SYSTEM.

INSTALLER

STOP!

PLEASE READ THE FOLLOWING

INFORMATION.

• INSTALLATION INSTRUCTIONS FOR THE 4590FR FTN.

WITH 97243C SINGLE VALVE CONTROL ASSEMBLY ARE

LOCATED ON PAGES 2 - 5.

• INSTALLATION INSTRUCTIONS FOR THE 4590FR FTN.

WITH SANITARYFR1 VALVE ARE LOCATED ON PAGES

6 - 12.

Summary of content (12 pages)

PAGE 1
4590FR_FTN LK4590FR_FTN LK4590SFR_FTN Owners Manual 4590 Freeze Resistant Barrier Free Stone Pedestal Fountain STOP! PLEASE READ THE FOLLOWING INFORMATION. • INSTALLATION INSTRUCTIONS FOR THE 4590FR FTN. WITH 97243C SINGLE VALVE CONTROL ASSEMBLY ARE LOCATED ON PAGES 2 - 5. • INSTALLATION INSTRUCTIONS FOR THE 4590FR FTN. WITH SANITARYFR1 VALVE ARE LOCATED ON PAGES 6 - 12. INSTALLER 4590 Fountains are among the easiest to install Fountains on the market today.
PAGE 2
4590FR_FTN LK4590FR_FTN LK4590SFR_FTN Owners Manual 4590 Freeze Resistant Floor Mounted Barrier Free Stone Fountain with 97243C Single Valve Control Assembly IMPORTANT! INSTALLER PLEASE NOTE Do not pull up on lines coming out of the PVC column. This raises the water valve above the frost line with disastrous results. General Installation Tips 1. Be sure to flush water supply line before you connect it to the inlet fitting on Freeze Resistant Valve System. 2.
PAGE 3
4590FR_FTN LK4590FR_FTN LK4590SFR_FTN SITE PREPARATION DETAIL FOR THE 4590FR FTN. WHEN USING 97243C SINGLE VALVE CONTROL ASSY. LEGEND A = ACCESS PANEL B = REMOVABLE BOTTOM COVER C = 1" PVC DRAIN D = PRESSURE FITTING 1-1/4" x 3/4" E = CONNECTOR 1-1/4" TO 1-1/4" F = 1-1/4" DRAIN TUBE G = AIR CONTROL LINE H = 1/4" WATER LINE J = CONNECTOR FOR AIR CONTROL LINE FIG. 1 PAGE 3 96812C (Rev.
PAGE 4
590FR_FTN LK4590FR_FTN LK4590SFR_FTN INSTALLATION INSTRUCTIONS FOR INSTALLING 97243C SINGLE VALVE CONTROL ASSY. 1. Prepare trench for water supply and waste drain lines (if required by local codes). The hole should be deep enough to accommodate the PVC column and 5 cubic feet of porous fill (large broken rock). Additional porous fill may be required due to local ground conditions. (See Site Preparation Detail below). 2. Lay drain lines and water supply lines.
PAGE 5
4590FR_FTN LK4590FR_FTN LK4590SFR_FTN The following items are included with the 4590FR Fountain PARTS LIST ITEM NO. 1 2 3 4 5 6 7 8 9 10-A 10-B 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 *27 28 29 30 NS NS NS PART NO.
PAGE 6
4590FR_FTN LK4590FR_FTN LK4590SFR_FTN Owners Manual 4590 Freeze Resistant Barrier Free Stone Pedestal Fountain with SanitaryFR1 Valve IMPORTANT! INSTALLER PLEASE NOTE Tubing must be cut to the right length. Do not coil any excess tubing or it will cause valve to malfunction. General Installation Tips 1. Prepare trench for water supply and waste drain lines. The hole should be deep enough to accommodate the PVC column. Additional porous fill and drain pipe may be required due to local ground conditions.
PAGE 7
4590FR_FTN LK4590FR_FTN LK4590SFR_FTN SUGGESTED SITE PREPARATION DETAIL FOR THE 4590FR FTN. WHEN USING THE SANITARYFR1 VALVE FIG. 1 PAGE 7 96812C (Rev.
PAGE 8
4590FR_FTN LK4590FR_FTN LK4590SFR_FTN SUGGESTED SITE PREPARATION DETAIL FOR THE 4590FR FTN. WHEN USING THE SANITARYFR1 VALVE FIG. 2 LEGEND A = ACCESS PANEL B = REMOVABLE BOTTOM COVER 96812C (Rev.
PAGE 9
4590FR_FTN LK4590FR_FTN LK4590SFR_FTN FOUNTAIN CONNECTIONS PLUMBING CONDUIT (BY INSTALLER) TO VALVE FIG. 3 INSTRUCTIONS FOR CONNECTING TUBES FROM VALVE TO FOUNTAIN Step 1 - Insert the 1/8” O.D. tube (Label A) into the connector (provided with fountain). Insert the 1/8” O.D. tube coming from the fountain push button actuator into the connector. Trim any excess length. Step 2 - Secure the 1/8” O.D. tube (Label C) to the waste line assembly. This line is a vent line and should be open to the air.
PAGE 10
4590FR_FTN LK4590FR_FTN LK4590SFR_FTN Stream Height Adjustment 4 5 3, 11 12 See Detail B 5 14 2 10 15 FIG. 5 FIG. 4 6 13 6 15 5 13 Detail B 96812C (Rev.
PAGE 11
4590FR_FTN LK4590FR_FTN LK4590SFR_FTN The Following Items are included with the SanitaryFR1 Valve PARTS LIST ITEM NO. PART NO.
PAGE 12
4590FR_FTN LK4590FR_FTN LK4590SFR_FTN The Following Items are included with the 4590FR Fountain PARTS LIST ITEM NO. 18 19 20 21 22 23 24 25 26-A 26-B 27 28 29 30 31 32 33 34 35 NS NS NS NS PART NO. 100147140560 100322740560 101570540560 15013C 110544942550 110868642550 160270508640 170705042830 400942308640 98287C 45403C 45845C 56121C 600985451640 66346C 66461C 70683C 75588C 75589C 75565C 56092C 56123C 75539C DESCRIPTION Drain Gasket Gasket Drain Gasket Bubbler Tube Assy. Set Screw #8-32 x .