Installation Guide

ManualsBrandsEmberglow ManualsKitchenCanyon Campfire 18 in. Vented Natural Gas Fireplace Logs

FOR YOUR SAFETY

• If you smell gas:

1. Open windows;

2. Don’t touch electrical switches;

3. Extinguish any open ﬂ ame;

4. Immediately call your gas supplier.

• Do not store or use gasoline or ﬂ ammable vapors and liquids in the vicinity of this or any other

appliance.

• Do not place clothing or other ﬂ ammable material on or near the appliance.

• Children and adults should be alerted to the hazards of high surface temperature and should

stay away to avoid burns or clothing ignition.

• Young children should be carefully supervised when they are in the same room as the appliance.

PLEASE READ these instructions carefully before you begin to install this gas log set.

Model Numbers: CCF18NG and CCF24NG

INSTALLATION & OPERATION

INSTRUCTION FOR

FIREPLACE GAS LOG

Appliance for use with all styles and sizes of Dual Burner Natural Gas Log Sets.

Note: Installer should leave these instructions with the consumer to retain for future reference.

SURE HEAT MFG. 2008 Complies with ANSI Z21-84

Listed By

OMNI-Test Laboratores, Inc.

Portland

Oregon USA

Summary of content (6 pages)

PAGE 1
INSTALLATION & OPERATION INSTRUCTION FOR FIREPLACE GAS LOG Model Numbers: CCF18NG and CCF24NG Appliance for use with all styles and sizes of Dual Burner Natural Gas Log Sets. Note: Installer should leave these instructions with the consumer to retain for future reference. T I E R E D D U A L T I E R E D B U R N E R D U A L B U R N E R PLEASE READ these instructions carefully before you begin to install this gas log set. FOR YOUR SAFETY • • If you smell gas: 1. Open windows; 2.
PAGE 2
DUAL BURNER PART LIST Figure 1 GRANULES (HEAVY WEIGHT BAG) 1-6 GLOWING EMBERS (LIGHT WEIGHT BAG) 16 17 NUMBER OF LOGS ARE DETERMINED BY THE SIZE AND MODEL CHOSEN SETS RANGE FROM 4 TO 9 LOGS 18 19 20 12 7 10 21 LEFT SIDE KNOCKOUT PLUG TO 1/2” GAS LINE 8 13 FLARED END RIGHT SIDE KNOCKOUT PLUG 11 14 TO BURNER BAR 15 9 REF.
PAGE 3
1. This gas log set is only to be installed and burned in a fully vented fireplace with a fully functional damper and chimney that is free of any obstructions. The fireplace must be constructed of non-combustible materials and approved to burn wood. WARNING: Do not burn wood or other material in any fireplace fitted with a gas log set. 2. To operate this gas log set, the fireplace damper must be fully opened and locked. 3. The smallest or minimum dimension of the chimney flue must be 8 inches in diameter.
PAGE 4
D. Prefabricated fireplace. Refer to the manufactures fireplace instruction manual for specific information regarding the running of a gas line into that particular model. A typical prefab installation involves the insertion of a 1/2 inch gas pipe through the gas line tube provided by each manufacturer from outside the fireplace. The Knockout on the inside of the fireplace is removed as the gas pipe is punched through the fireplace. (See Figure 3.) E. Masonry fireplace.
PAGE 5
CONNECTING GAS SUPPLY TO BURNER ASSEMBLY (If a Safety Pilot Kit is to be used, please refer to separate installation instructions.) These instructions refer to Natural Gas applications installed without a Safety Pilot Kit. LP/NG Safety Pilot Kit available at your local store. A. Place burner pan assembly in the center of the fireplace. B. Attach brass 3/8” Flared to 1/2” gas valve (Part #13) to the 1/2 inch gas supply stub. C. Attach 3/8” flared tubing (Part #15) to burner pan assembly.
PAGE 6
MAINTENANCE Very little maintenance is required. The carbon deposit resulting from combustion is natural and adds to the realistic appearance of the set. If carbon becomes excessive it can be lightly brushed or vacuumed away. TROUBLE SHOOTING 1. Problem No Ignition Cause -Valve not on -gas line not clear 2.