Instruction manual

ManualsBrandsEmerson ManualsHousehold AppliancesHSP2600

READ AND SAVE THESE INSTRUCTIONS

Installation Instructions* for

High-Capacity Steam Humidiers

(Models HSP2000 and HSP2600)

Also includes:

Programmable Flushing Timer

Installation Instructions

Operating and Maintenance Instructions

CONTRACTOR: Read these instructions before install-

ing or servicing humidier

HOMEOWNER: Save this manual for future reference.

*See “Wiring Instructions for High-Capacity Steam Humidiers” separately

Model No:

Mfg. Date (see label on unit):

Installation Date:

Summary of content (11 pages)

PAGE 1
READ AND SAVE THESE INSTRUCTIONS Installation Instructions* for High-Capacity Steam Humidifiers (Models HSP2000 and HSP2600) Also includes:  Programmable Flushing Timer Installation Instructions  Operating and Maintenance Instructions CONTRACTOR: Read these instructions before installing or servicing humidifier HOMEOWNER: Save this manual for future reference. Model No: Mfg.
PAGE 2
Table of Contents For the Contractor: Page CONTRACTOR: How To Install a White-Rodgers ComfortPlus Steam Humidifier.................. 3 • Safety Precautions................................................................................. 3 • Tools & Materials Needed...................................................................... 4 Selecting a Location..................................................................................... 4 Mounting the Humidifier (Options A-C).......................
PAGE 3
Tools and Materials Needed 1. 2. . 4. 5. 6. 7. 8. 9. 10. 11. 12. 1 . Safety glasses Tin snips or aviation snips Electric drill 3/8" and 7/64" drill bits Pliers Screwdrivers (medium flat point and Phillips #1) Level Hammer Small adjustable wrench Center punch Knife Wire and hardware to connect fan control Additional relay(s) CAUTION: For all installation configurations, the mounting area must be strong enough to support the humidifier’s weight when it is full of water (approximately 18 lbs.
PAGE 4
5. Adjust the water level. (See Nos. 7 & 8 in “Plumbing and Setting the Water Level”, pages 8 & 9.) Option C requires duct reinforcement to hold the humidifier securely in place. 6. Slide the flanges of the humidifier reservoir into the mounting bracket until the reservoir’s front flange comes in contact with the edge of the duct. DANGER: Wear safety glasses when cutting or drilling. Do not cut or drill into any air conditioning components or electrical enclosures during installation.
PAGE 5
Plumbing and Setting the Water Level NOTE: Use copper tubing only to plumb the humidifier. 1. Select the nearest cold water pipe and install the saddle connector and needle valve (provided) by following the instructions supplied with the valve. WARNING: Do not use any line connected to an air conditioner. CAUTION: To prevent valve seat damage, never adjust the humidifier’s water level without supporting the float arm. Make adjustments in small increments.
PAGE 6
How To Install the Programmable Automatic Flushing Timer The Humidifier Automatic Flushing Timer automatically flushes accumulated mineral deposits from all central-system steam- and reservoir-type humidifiers. This enables homeowners to enjoy the benefits of healthful, humidified air without the hassles of frequent maintenance due to mineral buildup. The flushing timer is set at the factory to flush the humidifier every two hours for a duration of 10 seconds, using only about 1.5 gallons of water per day.
PAGE 7
. Inside, on the circuit board, locate the red switch block which contains two switches, numbered 1 and 2. NOTE: The switches are pre-set in the 10-second mode, with the #1 switch in the ON position and the #2 switch in the OFF position, as shown at right. (Both switches in the ON position will also produce a 10-second flush.) 4. To reprogram the flushing timer to 20-second flushes every 2 hours, move the #1 switch to the OFF position and the #2 switch to the ON position, as shown at left.
PAGE 8
Troubleshooting PROBLEM EVIDENCE SOLUTIONS Low Humidity Low water level (less  See Plumbing and Setting than 2-3/8" deep) Water Level, Steps 7 & 8, pgs.
PAGE 9
Parts for Models HSP2000 and HSP2600 (cont’d.) Item Part Name Part No.
PAGE 10
How To Extend the Life of Your Humidifier Mineral buildup on the humidifier’s heating element is harmful to the unit. Therefore, routine maintenance is vital to the effectiveness and longevity of your humidifier. The normal service interval will vary from one-to-three months (i.e., one or two cleanings during a typical humidification season, plus a thorough cleaning at the end of the season).
PAGE 11
If you have questions about your White-Rodgers ComfortPlus Humidifier, or to learn which White-Rodgers IAQ products are right for your home, contact your local heating and air conditioning contractor: 8100 W. Florissant Ave. St. Louis, MO 63136-9022 Web: www.white-rodgers.com Part No.