INSTRUCTION MANUAL GAS COOKTOP Appliance Class: 3 Empava Item #: 12 " : EMPV-12GC29 Distributed by: Empava Appliances Inc. 15253 Don Julian Rd, City of Industry, CA 91745 USA www.empava.com The instructions shall be marked with directions to the installer to leave them with the appliance and to the consumer to retain them for future reference.
WARNING:This appliance can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved. Children shall not play with the appliance. Cleaning and user maintenance shall not be made by children without supervision. ——If the supply cord is damaged, it must be replaced by the manufacturer.
Contents ◆ Cooktop Description ◆ Important Information ◆ Operation ◆ Maintenance and Cleaning ◆ Troubleshooting ◆ Instructions for the Installer ◆ Important safety requirements ◆ Installation This appliance shall be installed in accordance with the regulations in force and only used in a wellventilated space. Read the instructions before installing or using this appliance.
Cooktop Description EMPV-12GC29 Operating Instructions: Knob 1 is for burner 4 Knob 2 is for burner 3 Figure 1 1.burner 4—11500Btu/hr in 5.15" 2.burner 3—4000Btu/hr in 1.77" Total heat input: 15500Btu/hr Important Information Read the instructions before installing or using this appliance. Children should be supervised to ensure that they do not play with the appliance. These instructions are only valid if the country symbol appears on the appliance.
➢ The appliance must be isolated from the gas supply piping system by closing its individual manual shut-off valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1/2 psi (3.5 kPa). ➢ Always check for the validity of the pressure regulator. Technical specification of the pressure regulator: i. Refer to TECHNICAL DATA in this manual. ii. Max. consumption: 2.5kg/h. iii. Should be certified according to ANSI Z21.1 / CSA 1.1 and comply with local code.
Service ➢ The gas cooktop should only be repaired or serviced by an authorized Service person and only genuine approved spare parts should be used. Environmental Information ➢ After installation, please dispose of the packaging with due regard to safety and the environment. ➢ When disposing of an old appliance, make it unusable, by cutting off the cable. ➢ The symbol on the product or on its packaging indicates that this product may not be treated as household waste.
CAUTION: Accessible parts may be hot when the grill is in use. Young children should be kept away" As shown in Figure 12, place the burner onto the burner base one by one and stuck, rotate left and right to check if the burners are in place, the burner is placed correctly when it cannot be rotated. Finally center placed the burner cap on the burner. If you cannot light the flame even after several attempts, check the "cap" and “crown” (see diagram – figure 10) if they are in the correct position.
Re-ignition: If the flame is out for certain reasons, the safety device will cut off the gas power automatically. Turn the switch to " largest flame " position, then ignite again, you should wait for 30 seconds when you do that; Due to the air in the tong, there may be unsmooth ignition, revolve the switch to " largest flame " position and ignite again. Maintenance and Cleaning Before any maintenance or cleaning can be carried out, you must DISCONNECT the gas cooktop from the electricity supply.
Trouble Shooting Problem Corrective action • There is no spark when lighting the gas • Check that the unit is plugged in and the electrical supply is switched on • Check that the RCCB has not tripped (if fitted) • Check the mains fuse has not blown • Check the burner cap and crown have been replaced correctly, e.g. after cleaning. • The gas ring burns unevenly • Check the main jet is not blocked and the burner crown is clear of food particles.
Maximum Gas Supply Pressure: 14 in wc. Gas supply pressure for checking regulator setting: NG gas pressure at 5.0 in wc LPG gas pressure at 11 in wc. Important safety requirements Location The cooktops may be located in a kitchen, a kitchen/diner or bed sitting room, but not in a bathroom, shower room or garage. Before making the cut out in the worktop ensure that there is a minimum distance of 2.17” between the rear edge of the cooktops and the wall. A minimum distance of 3.
WARNING: The use of a gas cooking appliance results in the production of heat and moisture in the room in which it is installed. Ensure that the kitchen is well ventilated especially when the appliance is in use. Keep natural ventilation holes open or install a mechanical ventilation device. Prolonged intensive use of the appliance may call for additional ventilation, for example opening of a window, or more effective ventilation, for example increasing the level of mechanical ventilation where present.
Propane Gas Conversion Operating Instructions NG Figure 14 Gas type Propane (Parts list) NG (Parts list) Nozzles Dia. (mm) Power (Btu/hr) Quantity Nozzles Dia. (mm) Power (Btu/hr) Quantity Ultra rapid burner 1.01 11500 1 1.64 11500 1 Auxiliary burner 0.62 4000 1 0.94 4000 1 Washer 1 1 Connector nut 1 1 Barb connector for hose 1 1 Figure 15 1) Air supply valve and cooktop valve need to be closed, unplug the power plug for AC model.
8) Similarly, when use in NG status, turn the marked NG arrow upwards and tighten it to the screw cap (see Figure 18). Repeat the above operation. The outlet pressure requires to be 4 ± 1in wc. 9) After the conversion is completed, the conversion label in the accessory bag needs to be attached next to the original label.
wooden strips; in the case of a joining cabinet surface, remember to leave a space of at least 1.77” x 22.05” at the back. When installing on a built-in oven without forced ventilation, ensure that there are air inlets and outlets for ventilating the interior of the cabinet adequately.
Electrical connections Any electrical work required to install this gas cooktop should be carried out by a qualified electrician or competent person. Check the last letter of your model to know the electrical supply type: A is for AC,D is for DC. See PAGE 1 to check the electrical supply of your model The GAS COOKTOP MUST BE EARTHED If the cooktops to be connected to a 120V, 60 Hz AC electrical supply.
Simply fill in the fields below and print form. Send Completed Form to: Customer Service:(888)-682-8882 Empava Appliances Inc. Warranty/ Registration Dept. 15253 Don Julian Rd City of Industry,CA,91745 WARRANTY CARD PLEASE READ AGREEMENT BEFORE SIGNING Click Here Keep this copy for yourself.
