Owner`s manual

30794-0-0812Page 28
IP OPERATING INSTRUCTIONS
Attention: For shipping purposes, the Electronic Control
Module and Receiver Plate assembly is loosely packaged
near the left side of the appliance. It is necessary that the re-
FHLYHUSODWHDVVHPEO\EHVHFXUHGWRWKHOHIWIURQWÀDQJHRIWKH
appliance at the time of installation. To secure, remove the
WZRORZHUVFUHZVLQWKHOHIWVLGHÀDQJHRIWKHDSSOLDQFHWKHQ
SODFH WKH UHFHLYHU SODWH DVVHPEO\ RYHU WKH OHIW IURQW ÀDQJH
and secure with the two screws previously removed.
5.25 VDC ELECTRONIC CONTROL VALVE
7KHHOHFWURQLFFRQWUROYDOYHV\VWHPLQFOXGHVWKHDELOLW\WRVZLWFK
WKHSLORWIURPDVWDQGLQJSLORWPRGHWRDQLQWHUPLWWHQWSLORWPRGH
 IPI Mode,QWKH,QWHUPLWWHQW3LORWPRGHZKHQWKHXQLWLV
WXUQHG21LWZLOOFDXVHVSDUNWRWKHSLORWOLJKWWKHSLORW
WKHQDOORZWKHEXUQHUWROLJKW:KHQWKHXQLWLVWXUQHGWR
2))ERWKWKHEXUQHUDQGSLORWZLOOEH2))
 CPI Mode,QWKH&RQWLQXHVV 3LORW PRGH WKH SLORW UH-
PDLQV21FRQWLQXRXVO\HYHQZKHQWKHEXUQHULVWXUQHG
OFF.
Note: $VPDOOWRJJOHVZLWFKLVORFDWHGRQWKHUHFHLYHUSODWHOHIW
VLGHRIXQLWWKDWLVXVHGWRVZLWFKIURP,3,XSZDUGSRVLWLRQWRWKH
&3,GRZQZDUGSRVLWLRQ6HH)LJXUH
:KHQWKHXQLWLVWXUQHGWR21WKHHOHFWULFDOFXUUHQWZLOOHQHUJL]H
DVSDUNWRWKHSLORWLJQLWHU2QFHWKHSLORWVHQVRUKHDWVXSDIWHUD
IHZVHFRQGVWKHYDOYHZLOOEHHQHUJL]HGDOORZLQJJDVWRÀRZWR
WKHEXUQHU
 )ROORZWKH 6$)(7<DQG/,*+7,1*,16758&7,216IRU,Q-
WHUPLWWHQW 3LORW FRQWUROV IRXQGLQWKLVPDQXDODQGRQODEHOV
IRXQGLQWKHFRQWUROFRPSDUWPHQWORFDWHGLQWKHORZHUFDYLW\
RIWKHDSSOLDQFH
 'XULQJWKHRSHUDWLQJVHDVRQRULQSRZHURXWDJHSHULRGVLWLV
UHFRPPHQGHGWKDWWKHSLORWUHPDLQLQWKH&3,VWDQGLQJSLORW
PRGH WR UHGXFH FROG VWDUW LVVXHV DQGRU FRQVHUYH EDWWHU\
EDFNXSSRZHUGXULQJDSRZHURXWDJH
 7KHJDVYDOYHKDVLQOHWDQGRXWOHWSUHVVXUHWDSVDVVKRZQLQ
)LJXUH5HIHUWRSDJHIRUJDVSUHVVXUHUHTXLUHPHQWV
Note: 7KH JDV FRQWURO KDV D PDQXDO +,/2 ÀDPH DGMXVWPHQW
NQREUHJXODWRUWKDWDOORZV\RXWRLQFUHDVHRUGHFUHDVH
WKHKHLJKWRIWKHEXUQHU ÀDPH6HH)LJXUH5RWDWH
WKH+,/2NQREFRXQWHUFORFNZLVHWR³+,´WRLQFUHDVHWKH
ÀDPHKHLJKWDQGFORFNZLVHWR³/2´WRGHFUHDVHWKHÀDPH
KHLJKW
OPTIONAL REMOTE CONTROLS
2SWLRQDOUHPRWHFRQWUROVDUHDYDLODEOHIRUXVHZLWKWKLVDSSOLDQFH
7KHUHLVDQDUHD RQ WKH 5HFHLYHU3ODWHEHWZHHQ WKH (OHFWURQLF
&RQWURO PRGXOH DQG WKH EDFNXS EDWWHU\ SDFN WKDW WKH 5HPRWH
5HFHLYHUVKRXOGEHSODFHG $ YHOFUR SDG LVSUHDWWDFKHGWRWKH
SODWHDVVHPEO\IRUTXLFNDWWDFKPHQWRIWKHUHPRWHUHFHLYHU
7RFRQQHFWWKHUHPRWHUHFHLYHUWRWKHDSSOLDQFH¿UVWGLVFRQQHFW
WKH212))VZLWFKZLUHVIURPWKHZKLWHDQGJUHHQZLUHFRQQHF-
WRUVDQGFRQQHFWWKHZLUHVIURPWKHUHPRWHUHFHLYHUWRWKHJUHHQ
DQGZKLWHZLUHFRQQHFWRUV6HH)LJXUH
)ROORZ WKH LQVWUXFWLRQV LQFOXGHG ZLWK WKH UHPRWH FRQWURO IRU SUR-
JUDPPLQJDQGRWKHURSHUDWLRQDOLQIRUPDWLRQ
MANUAL ON/OFF OPERATIONAL SWITCH
NOTE: ADDITIONAL ON/OFF SWITCH & WIRING INCLUDED
TO INSTALL SWITCHTO SIDE OF SURROUND PANEL.
DFC
ELECTRONIC
CONTROL
MODULE
OPTIONAL
REMOTE
CONTROL
RECEIVER
LOCATION
AA (4)
BATTERY
BACKUP
IPI
CPI
PILOT SELECTOR SWITCH
IPI - INTERMITANTPILOT(UP)
CPI - CONTINUOUS PILOT(DOWN)
RECEIVER PLATE
SPARK ROD
GROUND
9 PIN CONNECTOR
PILOT
SENSOR
MANUAL
HI/LO
REGULATOR
GAS VALVE
OUTLET
PRESSURE
TAP
INLET
PRESSURE
TAP
IGNITOR
SENSOR
PILOT
ASSEMBLY
Figure 30