Owner's Manual

ManualsBrandsEngland's Stove Works ManualsStoveEngland's Stove Works 18-TR

Table Of Contents

INSTALLATION & OPERATION MANUAL
- NOTE: IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN IT
  - Questions? Need Parts or Options? http://www.englanderstov
    - CAUTION: This unit must be installed in accordance with thes
- Non-Effected Facility 35 to 1 Air to Fuel Ratio
  - SAFETY NOTICE
    - Existing Flue System
    - Flue Size
      - Installation of a New Flue System
DEALER INFORMATION
UNIT INFORMATION
(Please be sure to refer to sticker on back of manual or box
IMPORTANT NOTICE

INSTALLATION & OPERATION MANUAL

MODEL NUMBERS: 18-TR 50-SHW10 50-TRW10

18-TRD 50-SHW10D 50-TRW10D

(NOTE: MANUAL ALSO APPLIES TO 50-SHW10DL)

Thank you for purchasing this product from a fine line of heating equipment. We wish you many

years of safe heating pleasure with your new heating appliance.

Save These Instructions.

NOTE: IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN IT TO THE

DEALER. CONTACT CUSTOMER SERVICE @ 1-800-245-6489.

Questions? Need Parts or Options? http://www.englanderstoves.com/

Please Note the Following Precautionary Statements:

England’s Stove Works highly recommends the use of smoke detectors and Carbon

Monoxide detectors with any hearth product, including this unit. Follow all manufacturer’s

instructions when using smoke or Carbon Monoxide detectors.

CAUTION: This unit must be installed in accordance with these instructions and must comply with

local building and fire codes. Failure to do so could result in a chimney or house fire.

Keep children, furniture, fixtures, and all combustible materials away from any heating

appliance. Maintain a minimum clearance of 30 inches (6” if using a heat shield) from

the firebox and 18 inches from flue pipe to any combustibles, unless you are using

shielded or double wall pipe.

DO NOT INSTALL THIS UNIT IN A MOBILE HOME!!!

READ THESE INSTRUCTIONS CAREFULLY BEFORE INSTALLING THIS MODEL.

SAVE THIS MANUAL FOR FUTURE REFERENCE.

Non-Effected Facility 35 to 1 Air to Fuel Ratio

SAFETY NOTICE

IF THIS STOVE IS NOT PROPERLY INSTALLED, A HOUSE FIRE MAY RESULT. FOR

YOUR SAFETY, FOLLOW THE INSTALLATION DIRECTIONS. CONTACT YOUR

LOCAL BUILDING OR FIRE OFFICIALS CONCERNING RESTRICTIONS AND

INSTALLATION INSPECTIONS IN YOUR AREA.

Rev. 8/06

Summary of content (13 pages)

PAGE 1
INSTALLATION & OPERATION MANUAL MODEL NUMBERS: 18-TR 50-SHW10 50-TRW10 18-TRD 50-SHW10D 50-TRW10D (NOTE: MANUAL ALSO APPLIES TO 50-SHW10DL) Thank you for purchasing this product from a fine line of heating equipment. We wish you many years of safe heating pleasure with your new heating appliance. Save These Instructions. NOTE: IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN IT TO THE DEALER. CONTACT CUSTOMER SERVICE @ 1-800-245-6489. Questions? Need Parts or Options? http://www.englanderstoves.
PAGE 2
A letter from our Technical Support department: Thank you for purchasing this fine product from England’s Stove Works! England's Stove Works was started, and is still owned by, a family that believes strongly in a "Do It Yourself" spirit – that’s one reason you found this product at your favorite “Do It Yourself” store.
PAGE 3
SECTION I: FLUE SYSTEM A. Existing Flue System If you have chosen a freestanding unit, this stove is designed to connect to an existing flue system, such as masonry or a pre-manufactured Class A flue system. If you have a masonry flue system, the inner liner should be inspected carefully for cracks; if there is no liner in your chimney, we recommend you install a steel liner or have one installed. If you have an existing pre-manufactured system the inner liner should be inspected for warping or buckling.
PAGE 4
Installation using UL Approved PreManufactured Chimney Installation Using a Masonry Chimney *IMPROPER INSTALLATION: The manufacturer will not be held responsible for damage caused by the malfunction of a stove due to improper installation. Call (800-245-6489) and/or consult a professional installer if you have any questions.
PAGE 5
2. Pre-Manufactured Flue System: In the past few years pre-manufactured flue systems have become very popular, because this type system is easily installed and, when done correctly, is very safe. There are many pre-manufactured flue systems on the market, and when making your choice it should be U.L., B.O.C.A. or I.C.B.O. approved. Any of these systems are constructed of the proper materials and meet the proper safety standards. Your local dealer normally handles an approved brand of flue pipe.
PAGE 6
B. Wall Protection Your unit can be placed within thirty inches (30”) of a combustible wall such as paneling, wallpaper or drywall. In some areas local codes may require thirty-six inches (36”) from a combustible, therefore it is very important that you check with local officials. If you need to place your unit closer to a combustible wall, some protection will be necessary.
PAGE 7
For proper operation the chimney connector should be as short as possible and never exceed a six foot (6’) horizontal run. Horizontal runs of chimney connector pipe should have an upward slope of one quarter of an inch (1/4”) per foot. You will need to maintain eighteen inches (18”) of clearance from the wall and ceiling unless you are using double wall or shielded pipe.
PAGE 8
SECTION V: OPERATING INSTRUCTIONS A. Building a Fire This unit has a 35 to 1 air to fuel ratio since there is no draft adjustment on the stove. The combustion air control is the six inch (6”) flue damper, which is placed in the middle of the first pipe section. CAUTION: NEVER USE KEROSENE, GASOLINE, DIESEL FUEL, CHARCOAL LIGHTER FLUID, LANTERN FUEL OR ANY OTHER FLAMMABLE LIQUID TO LIGHT OR RE-KINDLE A FIRE. NOTICE: Your new unit and the connector pipe may smoke for short period of time.
PAGE 9
Caution: The ash dump plate can be extremely hot!! Never remove red-hot ashes from the stove; allow ashes to cool before dropping into the ash pan. Ashes should be placed in a metal container with an airtight lid. The ashes should be placed on a noncombustible surface and completely away from any combustible materials. The ashes should remain in the airtight container until they have completely cooled. SECTION VI: CARE AND MAINTENANCE A.
PAGE 10
SECTION VII: CHIMNEY AND FLUE PIPE MAINTENANCE A. Chimney Maintenance Cleaning your chimney is not a difficult task, however, we highly recommend a professional be contacted for this job. Not only can he clean the system, but he will also be able to perform a complete inspection of it. A professional can spot problems that you may overlook. B. Flue Pipe Maintenance When connecting your unit to the flue system, 24 gauge or thicker pipe should be used.
PAGE 11
SECTION IX: WHAT CAUSES CREOSOTE ? Creosote is caused by the condensation of the vapor that exists in the escaping smoke -- the moisture level of your fuel will determine the density of this vapor. A severe downdraft as discussed previously will also cause creosote. Moisture will form at the coolest point in your chimney system and at this point will tend to form creosote. The ash is picked up by the moisture in the system and will build up or run back down the inside of your flue.
PAGE 12
Have this information on hand if you phone the factory or your dealer regarding this product. Retain for your files: Model Number __________________________ Date of Purchase ________________________ Date of Manufacture _________________ Serial #_____________________ LIMITED 5 YEAR WARRANTY FROM THE DATE OF PURCHASE TO THE ORIGINAL OWNER The manufacturer extends the following warranties: Five Year Period: 1. Carbon steel and welded seams in the firebox are covered for 5 years against splitting. 2.
PAGE 13
WARRANTY REGISTRATION for England’s Stove Works Purchased by (Name) ______________________________________________ Address _________________________________________________________ City ________________________ State __________ Zip _________________ Telephone _______________________________________________________ Email Address ___________________________________________________ DEALER INFORMATION Purchased From (Dealer) ___________________________________________ Address ___________________________________