Use and Care Manual

18
IMPORTANT!READANDFOLLOWALLINSTALLATIONANDMAINTENANCEINSTRUCTIONS,INCLUDINGCLEANINGTHEUNITASSPECIFIED,AND
REPLACINGGASKETSANNUALLY,ANDPARTSASNEEDED.
ENGLAND’SSTOVEWORKSISNOTRESPONSIBLEFORANYDAMAGEORINJURYINCURREDDUETONEGLECT,ORDUETOUNSAFEINSTALLATIONOR
USAGEOFTHISPRODUCT.CALLTECHNICALSUPPORTWITHANYQUESTIONS.



DAILYOPERATION
GettingStarted
 Checktoseethatthehopperiscleanandfreefromforeignmaterials.Besuretoconnectthisunittoaworking
outlet;werecommendusingasurgeprotectortohelpprotecttheelectroniccomponentsfromdamage.
 BEFOREyourfirstfire,dryrunyourunit(nopelletfuel
inthehopper)fortwentyminutes;pressingthe“ON”button
withtheunitpluggedinwillinitiatethedryrun.
 Whenthe“ON”buttonispressed:
 TopMountcontrolboards:theboardwillscrollthemessage“DIDYOUCLEANBURNPOTBEFORE
STARTING?HOLDONTOCONFIRM”.Pressandholdthe“ON”buttonfor3secondstostartthe
unit.
 SideMountboards:Afterafewseconds,theletters“SU”willappearinthedisplaywindows.
 Oncetheunitstarts,youshouldimmediatelyheartheexhaustblowerstartandoperatecontinuously.The
boardwilldisplaythelastsettingitwassettoforthedurationof
itsoperation,oruntilthesettingis
adjusted.(SideMountcont rol boards willcontinuetoshow“SU”).
 Afteraboutthreetofiveminutes,lookfortheredglowoftheigniterintheigniterportoftheburnpottobe
certainitisoperatingnormally.
 Holdthe
hopperlidswitch(See“IllustratedPartsDiagram”atrearofthismanual)downwithyourfingerand
checktoseethattheauge r is turning.Releasethehopperlidswitchandbecertainthattheaugerstops
turning.DONOTPUTYOURFINGERSINTHEHOPPERORNEARTHEROTATING
AUGER.
 TopMountboardsPleaseNote:Ifthelidswitchisleftdisengaged(notpresseddown)for60seconds,the
unitwillshutdownwithanerrormessageof“HOPPERLEFTOPEN.SHUTTINGDOWN–ifthishappens,the
unitmustbeallowedtoshutdownandthedry
runwouldthenneedtoberepeatedfromthebeginning.
 Notethatthefrontdoormustbeclosedfortheaugertocycle(theboardwillnotgiveavacuumlosserror,
astheboarddoesnotlookforthisuntilproofoffireismet,buttheaugerwill
notcycleifthedoorisopen).
 TopMountboards:Afterapproximatelytwentyminu tes,thecontrolboardshoulddisplay“FAILEDTOSTART
SHUTTINGDOWN”severaltimes,andthenitwillcontinuetodisplay“FAILEDTOSTART”.Tocleartheerror
messagesimplypressthe“OFF”button.
 SideMount
boardswilldisplay“E‐2”inthetwodisplaywindows(moreinformationonErrorCodes
canbefoundintheErrorCodesectionofthismanual).
 Atthispoint,thedryruniscompleteandyourpelletheatingapplianceisreadyfornormaloperation.
LightingaFire
 Inorderforthisstovetooperate,thehoppermustfirstbefilledwithpelletfuel.Liftthehopperlidandpourthe
pelletfueldirectlyintothehopper.Ofcourse,yourstoveshouldbeconnectedtoyourventingsystematthispoint.
 WerecommendusingonlypelletsmanufacturedbyPFICertifiedfacilities,sincepelletsbearingthePFI
stampofapprovalwillbelowinashandmoisture,highinBTU’s,anduniforminsizeandquality.
 Thispelletstovewillperformequallywellusingsoftwoodandhardwoodpellets,andalthoughthe
ashmaydiffer
slightlyinappearanceortexture,bothtypesofpelletswillburncleanlyandefficientlyinthisstove.
 Thispelletstoveisequippedwithanautomatic pelletignitionsystem.Simplypressthe“ON”button