SDS

ManualsBrandsEnpac ManualsSafety & SecurityHand Carried Spill Kit, Universal, Up To 6 Gallon Capacity

Table Of Contents

SAFETY DATA SHEET

SECTION 1: IDENTIFICATION OF PRODUCT AND COMPANY INFORMATION

PRODUCT NAME:

PRODUCT USE:

COOLANTS AND SOLVENTS

SPECIFIC PRODUCT TYPE: ABSORBENT PADS

COMPANY INFORMATION: ENPAC, LLC PHONE: 440-975-0070

FAX:

34355 MELINZ DRIVE 440-975-0047

EASTLAKE, OH 44095 EMER: 440-975-0070

SECTION 2: HAZARDS IDENTIFICATION

THIS PRODUCT IS NOT DANGEROUS IN ITS UNUSED FORM AND CONTAINS NO HAZARDOUS INGREDIENTS. NOT WHMIS REGULATED.

SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS

MATERIALS PERCENT CAS #

POLYPROPYLENE: >97% 9003-07-0

SURFACTANT: < 1% 9004-34-6

GRAY PIGMENT < 1% NONE

YELLOW PIGMENT < 1% NONE

GREEN PIGMENT < 1% NONE

ORANGE PIGMENT < 1% NONE

SECTION 4: FIRST AID MEASURES

NO SPECIAL PROCEDURES REQUIRED

SECTION 5: FIRE AND EXPLOSION HAZARD DATA

FLASH POINT: >315 DEGREES CELCIUS ( ASTM D93)

FLAMMABLE LIMITS: NOT YET DETERMINED

EXTINGUISHING MEDIA: WATER, FOAM, CO2, DRY CHEMICAL

SPECIAL FIRE FIGHTING PROCEDURES: STANDARD PROCEDURE FOR CLASS A FIRES

UNUSUAL FIRE AND EXPLOSION HAZARD: SOME CARBON MONOXIDE UNDER LEAN OXYGEN CONDITIONS

SECTION 6: ACCIDENTAL RELEASE MEASURES

NO SPECIAL STEPS ARE TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED

SECTION 7: HANDLING AND STORAGE

STORE IN DRY AREA. DO NOT STORE NEAR OPEN FLAME, HIGH HEAT OR STRONG OXIDANTS. POLYPROPYLENE, WHEN

HEATED, BECOMES VERY STICKY AND WILL BURN. USE SELF-CONTAINED AIR MASK TO ENTER SMOKY AREA IN THE

EVENT OF FIRE.

SECTION 8: EXPOSUR CONTROLS/PERSONAL PROTECTIVE EQUIPMENT

EXPOSURE LIMITS: OSHA PEL: N/A ACGIH TLV: N/A

RESPIRATORY PROTECTION: NONE REQUIRED

VENTILATION: NONE REQUIRED

PROTECTIVE GLOVES: NONE REQUIRED ONLY IF MOLTAN

EYE PROTECTION: NONE REQUIRED

OTHER PROTECTIVE EQUIPMENT (SPECIFY): NONE REQUIRED

SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES

COLOR:

DENSITY: 0.04 - 0.06 gram/cc

ODOR: CITRUS (IN ORANGE ABSORBENT)

SPECIFIC GRAVITY: 0.88 - 0.92

FLASH POINT: NOT APPLICABLE

BOILING POINT: NOT APPLICABLE

MELTING POINT: > 160 DEGREES CELSIUS

GRAY, YELLOW, GREEN, ORANGE

UNIVERSAL POLYPROPYLENE ABSORBENTS

SORBENT MEDIA USED TO ABSORB LEAKS AND SPILLS WHICH INCLUDE BUT NOT LIMITED TO OIL, WATER,

Summary of content (7 pages)

PAGE 1
SAFETY DATA SHEET SECTION 1: IDENTIFICATION OF PRODUCT AND COMPANY INFORMATION PRODUCT NAME: UNIVERSAL POLYPROPYLENE ABSORBENTS PRODUCT USE: SORBENT MEDIA USED TO ABSORB LEAKS AND SPILLS WHICH INCLUDE BUT NOT LIMITED TO OIL, WATER, COOLANTS AND SOLVENTS SPECIFIC PRODUCT TYPE: COMPANY INFORMATION: ABSORBENT PADS PHONE: FAX: EMER: ENPAC, LLC 34355 MELINZ DRIVE EASTLAKE, OH 44095 440-975-0070 440-975-0047 440-975-0070 SECTION 2: HAZARDS IDENTIFICATION THIS PRODUCT IS NOT DANGEROUS IN ITS UNUSED FORM
PAGE 2
SOLUBILITY IN WATER: INSOLUABLE PERCENT VOLATILE: NOT APPLICABLE EVAPORATION RATE: NOT APPLICABLE VAPOR PRESSURE ( mm Hg): NOT APPLICABLE VAPOR DENSITY (Air = 1): NOT APPLICABLE AUTO IGNITION TEMPERATURE >675 DEGREES FAHRENHEIT SECTION 10: STABILITY AND REACTIVITY DATA STABILITY: STABLE INCOMPATIBILITY (conditions to avoid): NONE INCOMPATIBILITY (materials to avoid): NITRIC ACID, PERCHLORIC ACID, SULFURIC ACID OR 98% SULFURIC ACID HAZARDOUS DECOMPOSITON: WHEN HEATED, IT MAY EMIT TOXIC HA
PAGE 3
SAFETY DATA SHEET — 16 Sections SECTION 1 — CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Product Identifier [WHMIS Classification] Perlite, Expanded, ENSORB Super Absorbent Not Applicable Product Use Industrial Absorbent Manufactured For: ENPAC, LLC Street Address 34355 Melinz Parkway City, State, Postal Code Eastlake, Ohio 44095 Emergency Telephone 440-975-0070 Date SDS Prepared 1/1/2018 SECTION 2 — HAZARDS IDENTIFICATION Route of Entry Skin Contact Skin Absorption Eye Contact Inhalation Ing
PAGE 4
SECTION 4 — FIRST AID MEASURES Skin Contact Use moisture renewing lotions if dryness occurs. Eye Contact Flush eyes with generous quantities of water or eye rinse solution. Consult physician if irritation persists. Inhalation Remove to fresh air. Blow nose to evacuate dust. Ingestion Drink generous amounts of water to reduce bulk and drying effects.
PAGE 5
SECTION 8 — EXPOSURE CONTROL / PERSONAL PROTECTION Exposure Limits ACGIH TLV OSHA PEL Other (specify) Specific Engineering Controls (such as ventilation, enclosed process) Adequate ventilation and appropriate local exhaust where needed to keep dust level below PEL. Personal Protective Equipment Gloves Respirator Eye Footwear Clothing Other If checked, please specify type Eye: Goggles to protect from dust. Skin: No special equipment is required.
PAGE 6
SECTION 10 — STABILITY AND REACTIVITY Chemical Stability If no, under which conditions? Yes No Incompatibility with Other Substances Yes If yes, which ones? No Reacts with Hydrofluoric Acid to form Silicon Tetrafluoride gas Reactivity and under what conditions? No dangerous reactions known. Hazardous Decomposition Products None SECTION 11 — TOXICOLOGICAL INFORMATION Effects of Acute Exposure Potential irritant for skin contact, eye contact or inhalation.
PAGE 7
SECTION 12 — ECOLOGICAL INFORMATION Aquatic Toxicity Generally considered inert. Perlite has no negative ecological effect and may be used as a soil container. SECTION 13 — DISPOSAL CONSIDERATIONS Waste Disposal Not considered hazardous waste by the RCRA (40 CFR Part 261). Place waste and spillage in closed containers. Dispose in accordance with Federal, State and Local regulations. SECTION 14 — TRANSPORT INFORMATION Special Shipping Information No known shipping regulations.