Owner`s manual

8
Operating Instructions
For Your Safety, Read Safety Precautions And
Lighting Instructions Before Operating
tuRn off unit:
FlipswitchtoOFFtoturnoffburnersonly.
Ifthereplaceistobeturnedofffortheseason,orforservicing,turnthegasshutoffvalvetoOFF.If
theunitisgoingtobeserviced,turnofftheelectricalpowertotheunitaswell.
NOTE: Whentheunitisturnedonforthersttime,itshouldbeturnedontohigh,withthefanOFF,
forthersttwotofourhours. Thiswillcurethepaint,logs,gasketmaterial,andotherproductsused
inthemanufacturingprocess.Itisadvisedthatadoororwindowbeopened,astheunitwillstartto
smoke,whichcanirritatesomepeople.Aftertheunithasgonethroughtherstburn,turntheunitOFF,
includingthepilot,andlettheunitgetcompletelycold.Thenremovetheglassandcleanitwithagood
gasreplaceglasscleaner,availableatyourlocalEnvirodealer.See“Door remoVal”and“cleanIng the
glass” sections.
bLoweR sPeeD:
Theblowerwillcomeononlywhenthereplaceisuptotemperature(approximately
20minutes).Turningthefancontrolknobwillchangethespeedofthefan.Toturn
thebloweroff,turntheknobCOUNTER-CLOCKWISEuntilit“clicks”off(Figure6).
Itisadvisablenottooperatetheblowerbelow
1
/3speedasitputsastrainonthe
windingsoftheblowerandrunningthebloweratlowerspeedscouldalsocause
premature fan failure.
noRmaL sounDs DuRing oPeRation:
Table 2: Normal Sounds.
Component Sound & Reason
Focus & Fascia Creakingwhenheatinguporcoolingdown.
Burner Lightpoporpoofwhenturnedoff;thisismorecommonwithLPunits.
TemperatureSensor Clinkingwhenitsensestoturnthebloweronoroff.
PilotFlame Quietwhisperwhilethepilotameinon.
Blower/Fan Airmovementthatincreaseanddecreaseswiththespeedoftheblower.The
blowerispushingtheheatfromthereplaceintotheroom.
GasControlValve Dullclickwhenturningonoroff,thisisthevalveopeningandclosing.
HI
OFF
LO
Figure 6: Fan control.
aDjusting VentuRi aiR settings:
Thereisoneventuriadjustment.
Usethisventuriadjustmentlever,showninFigure7,to
achieveaproperandefcientame.
AdjustleveruntiltheamepatternissimilartoFigure
37. Suggested pull out distances are ½” (13 mm)
minimumforNaturalGasand⅞”(22mm)minimum
forPropane.
Pull out the venturi adjustment to increase primary air at the venturi tube.
Push in the venturi adjustment to decrease primary air at the venturi tube.
Figure 7: Adjusting the venturi air setting.