Owner`s manual

9
Maintenance And Service
Warning: Failure to position the parts in accordance with this manual, or failure to use only parts
specicallyapprovedwiththisappliance,mayresultinpropertydamageorpersonalinjury.
Atleastonceayear,runthroughthefollowingprocedurestoensurethesystemiscleanandworking
properly.Checktheburnertoseeifalltheportsareclearandclean.Checkthepilottomakesureitisnot
blockedbyanything(seeFigure4).Thepilotameshouldbebluewithlittleornoyellowonthetips.
Theventingsystem mustbeperiodicallyexamined;itisrecommendedthe examination isdonebya
qualiedagency.
Anysafetyscreenorguardremovedforservicinganappliancemustbereplacedpriortooperatingthe
appliance.
cLeaning the gLass:
When the replace is cool,removethefaceofthereplacealongwiththeglassdoor.SeemaIntenance
anD serVIce - glass Door remoVal.Checkthegasketmaterialonthebackoftheglass,makingsurethat
itisattachedandintact.
Duringacoldstartup,condensationwillsometimesformontheglass.Thisisanormalconditionwithall
replaces.However,thiscondensationcanallowdustandlinttoclingtotheglasssurface.Initialpaint
curingoftheappliancecanleaveaslightlmbehindtheglass,atemporaryproblem.Theglasswillneed
cleaningafterthereplacehascooledofffromtherstburnandabouttwoweeksafterrstburn. Use
a mild glass cleaner and a soft cloth. Abrasive cleaners will damage the glass and plated
surfaces. Dependingontheamountofuse,theglassshouldrequirecleaningnomorethantwoorthree
times a season. Do not clean the glass when it is hot.
cLeaning the fiRebox anD buRneR:
Removethelogscarefully,astheyareveryfragile.Gentlyremovealltheembersandrockwoolandplace
onapapertowel.Vacuumthebottomofthereboxthoroughly.Carefullycleananydustoffthelogsand
removeanylintfromtheburnerandpilot.Atthistime,inspecttheburnerpanforcrackingorsevere
warping. Ifaproblemissuspected,contactthedealer.Checkthelogsfordeteriorationorlargeamounts
ofsoot;asmallamountonthebottomsideofthelogsisnormal.Replacethelogsandembersasinthe
seconDary InstallatIon - log set anD ember InstallatIon section. Ifnew/moreembersandrockwoolare
required,contactyournearestENVIROdealer.
RePLacing the gLass:
WARNING: Do not operate appliance with the glass front removed, cracked or broken.
Replacement of the glass from the door must be done by a licensed or qualied service
person. Theglassinthereplaceisahightemperatureceramic.Iftheglassisdamagedinanyway,
a factory replacement is required (see parts lIst). Weargloves when handling damaged glass door
assembly to preventpersonal injury. When the glass door assembly isbeing transported, it must be
wrappedinnewsprintandtapeand/orastrongplasticbag.The glass must be purchased from an
ENVIRO dealer. No substitute materials are allowed.
cLeaning the PLateD suRfaces:
Paintedfacesshouldbewipedwithadampclothperiodically.Ifaplatedfacehasbeenpurchased,it
shouldbeunpacked/unwrappedcarefullytoavoidgettinganythingonthesurfaceofthenish,including
cleaners,polishand ngerprints.Itisimportanttonotethatngerprintsandother markscanleave
apermanentstainonplatednishes.To avoid this, give the face a quick wipe with denatured
alcohol on a soft cloth BEFORE lighting the replace. Nevercleanthe face when it ishot.Do
notuseothercleanersastheymayleave a residue,whichcanbecomepermanentlyetchedintothe
surface.