Owner`s manual

2-3 Days / Weekly Semi-annually or 2 Tons of Fuel

Burn Pot and Liner Exhaust Vent

Heat Exchanger Tubes Air Intake

Ash Pan Blower Mechanisms

Door Glass Heat Exchanger Tubes

Inside Firebox Behind Firebox Liners & Covers

Ash Pan and Door Gaskets All Hinges

Door Latch Post Season Clean-up

Routine Cleaning and Maintenance

The following list of components should be inspected and maintained routinely to ensure that the

applianceisoperatingatits’optimumandgivingyouexcellentheatvalue:

Burn Pot Liner

Ignitor Tube

Air Intake Tube

Burn Pot

Ignitor Hole

BURNER POT AND LINER(2-3days)

Everytwo to threedays(when the unit is cold), removethe burn-potlinerfromthe stove.Using a

metalscraper,removematerialthathasaccumulatedoriscloggingtheliner’sholes.Thendisposeof

thescrapedashesfromthelinerandfrominsidetheburn-pot.Placetheburn-potbackintothestove,

makingsurethatthepipesareproperlyinsertedintotheburnpot.Placethelinerbackintotheburn-pot,

makingsurethattheignitorholeinthelinerisalignedwiththeignitortube(showninFigure8).Push

thelinerupagainsttheignitortube.

If,afterlongperiodsofburning,thefirecontinuallybuildsupandoverflowstheburnpotorthereisa

buildupofclinkers,thisisanindicationthatthepelletfuelqualityispoor,thestovemayneedcleaning,

ortheairadjusted.Checkthestoveforashbuildup(cleanifrequired)andadjusttheslider/damper

toproducethepropercleancombustion.

Heat eXcHangeR tubeS (2-3days)

Ahandleislocatedinthecenterofthestovejustabovethedoor(showninFigure6).Thishandleistobe

pulledupanddownafewtimes(ONLYWHENTHEUNITISCOLD)inordertocleanawayanyflyashthat

mayhavecollectedontheheatexchangertubes.Asdifferenttypesofpelletsproducedifferentamounts

ofash,cleaningofthetubesshouldbedoneonaregularbasistoenabletheunittorunefficiently.

ASH PAN AND DOOR GASKETS (weekly)

After extended use the gasketing may come loose. To repair this,glue the gasketingon using high-

temperature fiberglassgasketglueavailablefromyourlocal dealer.Thisisimportant tomaintainan

airtightassembly.

DOOR GLASS CLEANING (2-3days)

Cleaningoftheglassmustonlybedonewhenstoveiscold.Openthedoorbyliftingthehandle.Theglass

canbecleanedbywipingdowntheoutsideandinsideoftheglasswithadrysoftcloth.

Figure 8: Mini Burn pot and Liner

TOOLS REQUIRED TO CLEAN UNIT:

Torx T-20 Screwdriver,

/16” wrench or socket, Brush, Soft

Cloth,Vacuumwithfinefilterbag