Owner`s manual

EXHAUST PASSAGES (semi-annually)
Topreventbuildupoffly-ashalltheexhaustpassagesmustbecleanedandvacuumed.
Routine Cleaning and Maintenance
Iftheglasshasbuildupthatcannotberemovedwithonlythecloth,cleantheglassusingpapertowel
andagasapplianceglasscleaner,thismaybepurchasedthroughmostdealers.Ifagasapplianceglass
cleanerisnotavailable,useadamppapertoweldippedinyashtocleantheglass.Aftertheglasshas
beencleanedusethedrysoftclothtowipingdowntheoutsideandinsideoftheglass.
Vacuum inside ash
box compartment.
Heat exchanger tubes
cleaner handle.
Empty ash box.
Vacuum the
air wash.
ROO
M
AIR
F
A
N ON/OF
F
ON/OFF
F
EED RAT
E
TRIM
COMBUSTION
BLOWER TRIM
HEAT LEVEL
AUTO/OFF
HIGH/LOW
MANUA
L
AUGER
MODE
11
Figure 9: Mini Open
ASH PAN (weekly)
Thispartislocatedunderthedoor.Toremove
theashpan,openthecoverfromtherighthand
side,andlifttheashpanupandout.Dumpthe
ashesintoametalcontainerstoredawayfrom
combustibles.Monitortheashleveleveryweek.
Remember that different pellet fuels will have
different ash contents. Ash content is a good
indication of fuel efficiency and quality.  Refer
to “
saFety Warnings and recOmmendatiOns” for
disposalofashes.Vacuumtheinsideoftheash
pancompartmentinsidethepedestalincluding
the hole at the top back of the compartment.
Replace the ash pan and close pedestal door.
DO NOT PLACE UNBURNED OR RAW
PELLET FUEL IN ASH PAN.
AIR INTAKE (semi-annually)
Inspect periodically to be sure that it is not
cloggedwithanyforeignmaterials.
Loosen the four (4) screws, rotate
counter-clockwise & remove.
Loosen the screw &
rotate the cover
(left & right sides)
Cleanbehindclean-outcovers:
• Openashboxcover.
• Removeashbox.
• Using a
5
/16” socket, loosen
the six (6) screws in the ash
boxcompartment;four(4)on
thebackandone(1)oneach
side(seeFigure10).
• Rotatethebackcovercounter-
clockwisetoremoveandrotate
thesidecoverstoopenthem.
• Vacuum out all three (3)
chambers.
• Close all the clean-out covers
andtightenthescrews.
Figure 10: Mini Clean-Out Covers.