Owner`s manual

Routine Cleaning and Maintenance

Removalofthefireboxbacking.

• Openthedoorbyliftingthehandle,removetheburnpotandburnpotliner.

• Lubricateallscrewswithpenetratingoil.

• Removethefour(4)screwsthatholdthesidepanelsinplace.

• Withthetipofaflatscrewdriver,gentlyliftupthesidepanelsandremovethesidepanels.

• Pullthecenterpanelout.

• Vacuumthoroughly.

Installationoffireboxbacking:

• Insertcenterpanel.

• Placethesidepanelsbackintothefireboxlockingthemintoplaceandre-installthetwo(2)screwson

eachside.

• Cleanthoroughly.

AIR WASH (annually)

Vacuumouttheairwashpassagesatthetopoftheglass(seeFigure9).Werecommendthatasoftbrush

nozzleheadisusedonthevacuum.

EXHAUST VENT (annually)

Thisventshould be cleanedevery year or after two tonsof pellets.We recommendcontacting your

dealerforprofessionalcleaning.Tocleantheventpipe,taplightlyonthepipetodislodgeanylooseash.

Openthebottomofthe“T”todumptheash,thenvacuumasmuchoftheashoutoftheventpipeas

possible.

BLOWER MECHANISMS(season)

Unplugthestovethenopentherightandleftsidepanelstoaccessthetwoblowers.Vacuumalldust

frommotors.DONOTlubricatethemotors.Checkgasketsandreplaceifneeded.

PoSt SeaSon cLean-uP

Onceyouarefinishedusingthepelletappliancefortheseason,unplugthestoveforaddedelectrical

protection.Itisveryimportantthatthestovebecleanedandservicedasstatedabove.

FIREBOX PANEL

Thepaintonthesteelfireboxpanelsmaypeel.Thisisduetoextremeconditionsappliedtothepaintand

isinnowaycoveredbywarranty.

DOOR GLASS REPLACEMENT

Itisrecommendedthatyourdealerreplacetheglassifbroken.Thedoorglassismadeofhightemperature

PYROCERAMIC.Toreplacetheglass,unscrewandremovethefourglassretainers.Removetheglass

andanybrokenpieces.Hightemperaturefiberglasstapeshouldbeusedaroundtheglass.Replacethe

glassbysecuringtheglassretainersbacktotheframemakesuretheglassisseatedagainstthebottom

glassretainerscrews.Theuseofsubstitutematerialsisprohibiteduseonlypart50-1155.