TM-U300CD.
TM-U300CD.fm 2 ページ ２００６年３月１４日 火曜日 午前９時５７分 All rights reserved. No part of this publication may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, mechanical, photocopying, recording, or otherwise, without the prior written permission of Seiko Epson Corporation. No patent liability is assumed with respect to the use of the information contained herein.
TM-U300CD.fm 3 ページ ２００６年３月１４日 火曜日 午前９時５７分 English EMC and Safety Standards Applied Printer Product Name: TM-U300C/D, TM-U300PC/PD Model Name: M51JC/D, M51PC/PD The following standards are applied only to the printers that are so labeled. (EMC is tested using the Epson power supplies.) Europe: North America: Japan: Oceania: Taiwan: A CE marking EMI: FCC/ICES-003 Class A EMI: VCCI Class A EMC: AS/NZS CSIPR22 Class B BSMI: EMC: CNS13438 Safety: CNS14236 ng Japan: C22.2 No.
TM-U300CD.fm 4 ページ ２００６年３月１４日 火曜日 午前９時５７分 INTRODUCTION The TM-U300C-U300D and TM-U300PC/U300PD are compact, light-weight printers, designed to provide the highest possible performance to cost ratio.
TM-U300CD.fm 5 ページ ２００６年３月１４日 火曜日 午前９時５７分 CONTENTS Chapter 1 Unpacking the Printer ........................................................................... 1 1 1-3 Checking the Contents of the Printer Box ................................................... Choosing a Place for the Printer................................................................... Removingthe Transportation Damper.. ....................................................... 1-4 Part Names and Functions......................
TM-U300CD.fm 6 ページ ２００６年３月１４日 火曜日 午前９時５７分 Chapter 1 Unpacking the Printer 1-1 Checking the Contents of the Printer Box The illustration below shows the items included for the standard specification printer. TM-U300D/U300PD TM-U300C/U300PC Power cord (*1) AC adapter Roll paper Ribbon cassette Hexagonal lock screws (2 pcs) (*2) Operator’s Manual (*1) Power cord may not be provided in the package.
TM-U300CD.fm 7 ページ ２００６年３月１４日 火曜日 午前９時５７分 1-2 Choosing a Place for the Printer Avoid locations in direct sunlight or subject to excessive heat (such as near heaters). Avoid using or storing the printer in places subject to excessive moisture. Do not use or store the printer in a dusty or dirty area. Choose a stable, horizontal surface for the printer. Avoid places subject to intense vibration or shock. Make sure there is enough space around the printer so that it can be used easily.
TM-U300CD.
TM-U300CD.fm 9 ページ ２００６年３月１４日 火曜日 午前９時５７分 Functions I Switches and Buttons ➀ POWER Switch The POWER switch is used to turn the printer on and off. ➁ FEED Button The FEED button is used to feed roll paper. The line feed amount is set by the printer commands ESC 2 and ESC 3. Control Panel Lights (LEDs) ➂ POWER LED (green) The POWER LED is on when the printer is turned on and off when the printer is turned off. ➃ PAPER LED (red) Normally the PAPER LED is off.
TM-U300CD.fm 10 ページ ２００６年３月１４日 火曜日 午前９時５７分 Chapter 2 Connecting the Cables 2-1 Connecting the AC Adapter to the Printer Follow these steps to connect the AC adapter to the printer: ➀ Make sure the printer is turned off. It is off when the O side of the switch is pressed down. ➁ Check the label on the AC adapter to make sure the voltage required by the AC adapter matches that of your electrical outlet.
TM-U300CD.fm 11 ページ ２００６年３月１４日 火曜日 午前９時５７分 2-2 Connecting the Host Computer to the Printer Connect the host ECR (host computer) to the printer using an interface cable that matches the specifications of the printer and the host ECR (host computer). Be sure to use a drawer that matches the printer’s specifications. ■ Connecting the host computer to the TM-U300C/U300D Connect the interface cable as follows: ➀ Turn off the printer and the host ECR (host computer).
TM-U300C.
TM-U300CD.fm 13 ページ ２００６年３月１４日 火曜日 午前９時５７分 Chapter 3 Installing the Printer Parts 3-1 Installing the Ribbon Cassette ■ lnstalling the ribbon cassette Use Epson ribbon cassette ERC-34 (B/R). Follow these steps to install the ribbon cassette: ➀ Open the printer cover while lightly pressing the printer cover as shown below. ➁ Turn the ribbon-tightening knob in the direction of the arrow to take up any slack in the ribbon.
TM-U300C.
TM-U300CD.fm 15 ページ ２００６年３月１４日 火曜日 午前９時５７分 Replacing the ribbon cassette Use Epson ribbon cassette ERC-34 (B/R). ➀ Open the printer cover while lightly pressing the printer cover as shown below. ➁ To remove the ribbon cassette, grasp the tab on the left side and lift the left side out first. ➂ To install a new ribbon cassette, follow steps ➁ through ➄ in the previous section, Installing the ribbon cassette.
TM-U300CD.fm 16 ページ ２００６年３月１４日 火曜日 午前９時５７分 3-2 Installing the Paper Roll Installing the paper roll in the TM-U300C/U300PC Be sure to use roll paper that matches the printer’s specifications. See Appendix A, Specifications. ➀ Using scissors, cut the leading edge of the roll paper so that it is perpendicular to the paper feed direction. Correct Incorrect Incorrect ➁ Open the take-up device cover and remove the take-up spool from the printer.
TM-U300CD.fm 17 ページ ２００６年３月１４日 火曜日 午前９時５７分 ➃ Turn on the printer. The POWER LED goes on. ➄ While leaving some slack in the paper roll, insert the end of the roll paper straight into the paper inlet. The printer automatically feeds the roll paper into the printer (semi-automatic loading). ➅ Press the FEED button to continue feeding the paper until it extends about 20 cm (8 inches) beyond tear-off edge.
TM-U300CD.fm 18 ページ ２００６年３月１４日 火曜日 午前９時５７分 ➇ Install the take-up spool in the printer. Make sure that the gear on the take-up spool aligns with the gear on the printer. ➈ Close the take-up device cover. ➉ Tear off any extra paper at the tear-off edge by pulling the paper toward you. CAUTION: • The extra paper must be torn off after closing the take-up device cover so that roll paper comes out correctly from the paper exit.
TM-U300CD.fm 19 ページ ２００６年３月１４日 火曜日 午前９時５７分 Installing the paper roll in the TM-U300D/U300PD Be sure to use roll paper that matches the printer’s specifications. See Appendix A, Specifications. ➀ Using scissors, cut the leading edge of the roll paper so that it is perpendicular to the paper feed direction. Incorrect ➁ Open the roll paper cover.
TM-U300CD.fm 20 ページ ２００６年３月１４日 火曜日 午前９時５７分 ➂ Load the roll paper while lightly pressing the paper roll holder outward. Release the holder after fitting the paper core onto the holder. Make sure the paper roll turns freely and be sure to load the paper roll so it rotates in the correct direction. Correct Incorrect ➃ Turn on the printer. The POWER LED goes on. ➄ While leaving some slack in the paper roll, Insert the end of the roll paper straight into the paper inlet.
TM-U300CD.fm 21 ページ ２００６年３月１４日 火曜日 午前９時５７分 ➅ Close the roll paper cover. ➆ Tear off any extra paper at the tear-off edge by pulling the paper toward you. CAUTION: The extra paper must be torn off after closing the roll paper cover so that roll paper comes out correctly from the paper exit.
TM-U300CD.fm 22 ページ ２００６年３月１４日 火曜日 午前９時５７分 ■ Replacing the roll paper for TM-U300C/U300PC Be sure to use roll paper that matches the printer’s specifications. See Appendix A, Specifications. ➀ Open the take-up device cover. ➁ Remove the take-up spool from the printer. (If it is necessary, cut the paper going to the take-up spool, using the tear-off edge.) Then remove the roll paper core.
TM-U300CD.fm 23 ページ ２００６年３月１４日 火曜日 午前９時５７分 ■ Replacing the paper roll in the TM-U300D/U300PD Be sure to use roll paper that matches the printer's specifications. See Appendix A, Specifications. ➀ Open the roll paper cover. ➁ Remove the roll paper core. If there is roll paper remaining, cut the paper straight across using scissors at the place shown in illustration below.
TM-U300C.
TM-U300C.
TM-U300C.
TM-U300CD.fm 27 ページ ２００６年３月１４日 火曜日 午前９時５７分 Notes on printing on validation paper The printer can print only one line on validation paper. Printing is performed by the print commands, but the paper is not fed. Therefore, double-height printing cannot be performed on validation paper. Printing on the validation paper must be performed when roll paper is loaded. However, printing is affected by the total thickness of the paper.
TM-U300CD.fm 28 ページ ２００６年３月１４日 火曜日 午前９時５７分 Chapter 4 Setting the DIP Switches Finding the DIP switches As shown in the illustration below, the DIP switches are located on the bottom of the printer. The DIP switches are used to set the printer to perform various functions The TM-U300C/U300D DIP switches are numbered SW-1 to SW-10 and the TM-U300PC/U300PD DIP switches are numbered SW-1 to SW-8, from left to right as shown in figure below.
TM-U300CD.fm 29 ページ ２００６年３月１４日 火曜日 午前９時５７分 TM-U300C/U300D DIP Switch Functions Table 4-1. TM-U300C/U300D DIP Switch Functions Refer to Table 4-2. Baud rate selection ( ) Do not change the settings of DIP switches 9 and 10 on the TM-U300C/U300D * Table 4-2.
TM-U300CD.fm 30 ページ ２００６年３月１４日 火曜日 午前９時５７分 TM-U300PC/U300PD DIP Switch Functions Table 4-3. TM-U300PC/U300PD DIP Switch Functions Do not change the settings of DIP switches 3 through 6 on the TM-U300PC/U300PD.
TM-U300CD.fm 31 ページ ２００６年３月１４日 火曜日 午前９時５７分 Chapter 5 The Self Test ■ The purpose of the self test The self test checks whether the printer has any problems. If the printer does not function properly, contact your dealer.
TM-U300CD.fm 32 ページ ２００６年３月１４日 火曜日 午前９時５７分 Chapter 6 Removing Jammed Paper 6-1 Removing Jammed Paper Turn the paper-feed knob as shown below, and remove any jammed paper. It may be easier if you cut the roll paper or remove the printer cover.
TM-U300CD.fm 33 ページ ２００６年３月１４日 火曜日 午前９時５７分 Appendix Appendix A. Specifications 1. Printing Specifications Printing method: Serial impact dot matrix Head wire arrangement: Serial-type, 9-pin Printing directions: Bi-directional (logic seeking) Lines per second: Approx. 3.5 LPS (40 columns, 16 CPI, single color, continuous printing) Approx. 5.
TM-U300CD.fm 34 ページ ２００６年３月１４日 火曜日 午前９時５７分 Table A-1. Character Size, Characters Per Inch, Characters Per Line ( 1) The 7 x 9 font is the default. * Example 7 x 9 font Units: mm (inch) 3. Ribbon Ribbon cassette type: Exclusive ribbon cassette ERC-38 Color: Black and Red, Black, Red Single-color ribbon [Part No.: ERC-34 (B) (black)] and P-color ribbon [Part No.: ERC-34 (B/R) (black and red)] are also available. When using these ribbons, the print color selection command (ESC r) must not be used.
TM-U300CD.fm 35 ページ ２００６年３月１４日 火曜日 午前９時５７分 Ribbon cassette overall dimensions: Refer to Figure A-1 [Units: mm] Figure A-1. ERC-38 Overall Dimensions 4. Roll Paper Supply Device Supply method: Paper roll holding shaft Near-end detector: Provided inside the printer case The paper near-end detector location should be adjusted by the user. Refer to section 3-3, Adjusting the Paper Near-End Detector Location. Roll paper core inside diameter: ø 10.5 to 12.5 mm (0.41" to 0.
TM-U300CD.fm 36 ページ ２００６年３月１４日 火曜日 午前９時５７分 Paper size: Roll paper Paper width: 76 mm ± 0.5 mm (2.99" ± 0.02") Maximum diameter: ø 83 mm (3.27") (when 2-ply or 3-ply paper is used) ø 60 mm (2.36") (when 1 -ply paper is used) ø 10.5 to 12.5 mm (0.41" to 0.49") Paper core inside diameter: ➀ Normal paper Paper thickness: (single-ply sheet) 0.06 to 0.085 mm (0.002" to 0.003’) Weight: 52.
TM-U300CD.fm 37 ページ ２００６年３月１４日 火曜日 午前９時５７分 7. Receive Buffer Either 40 bytes or approx. 1 Kbyte, selectable using DIP switch. (TM-U300C/U300D) Either 0 bytes or approx. 1 Kbyte. selectable using DIP switch. (TM-U300PC/U300PD) (Refer to Chapter 4, Setting the DIP switch.) 8. Power Supply The supported power supply is AC adapter, C. 9.
TM-U300CD.fm 38 ページ ２００６年３月１４日 火曜日 午前９時５７分 10. Environmental Conditions Temperature: Operating: 5° to 40°C (41° to 104°F) Storage: For the TM-U300C/U300PC, when the temperature is 30°C (86°F) or more, the operating humidity is limited.
WEEE_statement_for_um.fm Page 1 Wednesday, April 26, 2006 10:57 AM WEEE (Waste Electrical and Electronic Equipment) Directive This information only applies to customers in the European Union, according to Directive 2002/96/EC OF THE EUROPEAN PARLIAMENT AND OF THE COUNCIL OF 27 January 2003 on waste electrical and electronic equipment (WEEE) and legislation transposing and implementing it into the various national legal systems.
WEEE_statement_for_um.fm Page 2 Wednesday, April 26, 2006 10:57 AM Norsk Det er krysset over merket av beholderen på hjul som vises på produktet, som angir at dette produktet ikke skal kastes sammen med vanlig husholdningsavfall. Hold dette produktet atskilt fra annet avfall slik at det kan resirkuleres på en miljømessig forsvarlig måte og dermed forhindre eventuell skade på miljø eller helse.
TM-U300CD.
TM-U300CD.
TM-U300CD.
TM-U300CD.fm 40 ページ ２００６年３月１４日 火曜日 午前９時５７分 Printed in Japan 1999.
