Installation Guide
18
OK
Mount Drain Saddle
at either location
Drain Saddle
The Drain Saddle is used to connect the Black Drain Line to the drain pipe under the sink. The Drain Saddle
is designed to t around a andard 1.5 inch OD (outer diameter) drain pipe.
NOTE! Adjuable drain saddles are available upon reque if the saddle does not t your pipe.
The Drain Saddle should always be inalled above (before) the P-Trap and on a raight vertical or horizon-
tal section of pipe. To avoid clogging the drain line with debris do not inall the Drain Saddle after the drain
pipe meets a garbage disposal or dishwasher drain. The image below shows ideal Drain Saddle locations.
1. Once you have found where your Drain Saddle will go on the Drain Pipe make a mark for the opening
there with a marker or pencil.
2. Use your drill and an appropriate 1/4 inch (6.35mm) drill bit to drill a hole at your mark. Be careful to drill
through only one side of the pipe. Stabilize your pipes while drilling to avoid damaging them.
3. Find the half of the Drain Clamp with a hole in its center. Then remove the backing from the Foam Gasket
(the foam circle at the center of the Gasket is disposable). Make sure to align the Foam Gasket hole with the
Drain Clamp hole and ick the adhesive side of the Gasket to the inner wall of the Drain Clamp half.
4. Take the half of the Drain Clamp without the Foam Gasket and insert a nut into the recess on each side.
5. Position both halves of the Drain Clamp on the drain pipe with the clamp’s opening aligned over the
drilled hole. The Foam Gasket will be between the drain clamp and the drilled hole. Push your 1/4 inch drill
bit through both holes (the Drain Clamp hole and the hole in the Drain Pipe) and remove to verify that the
clamp is properly aligned with the hole you drilled.
6. Secure the Drain Clamp halves together in place on the Drain Pipe. Screw the bolts through the Drain
Clamp half with the Foam Gasket and into the half you inalled the nuts. Do not over tighten. When
tightening bolts make sure there is equal space on both sides between the Drain Clamp halves.
X
WARNING!
Nut
Black Tube/Drain Line
Foam Gasket
Drain
Clamp
Drain Pipe
1/4” Hole
Bolt
OK
OK
X
X
P-Trap
Garbage
Disposal
*Adjuable drain saddles are available if the saddle does not t your pipe
Never mount here