Operation Manual

CTH
17
GB
4 Intended use
The mobile dust extractor is suitable for the
absorption and suction of dust which is haz-
ardous to health with limit values corre-
sponding to dust class 'H' in accordance with
EN 60335-2-69.
The mobile dust extractor is suitable for the
absorption and suction of dust with carcino-
genic and pathogenic particles, as well as as-
bestos dust.
The mobile dust extractor is designed to ab-
sorb water.
The mobile dust extractor is, in accordance
with EN 60335-1 and EN 60335-2-69, suit-
able for increased demands for commercial
use.
The user bears the responsibility for
damage and accidents caused by im-
proper use.
5 Safety instructions
5.1 General safety instructions
Warning! Read all safety warnings
and all instructions.
Failure to follow the
warnings and instructions may result in elec-
tric shock, fire and/or serious injury.
Save all warnings and instructions for
future reference.
– The device is not intended for use by per-
sons (including children) with limited phys-
ical, sensory or mental ability or without
sufficient experience and/or knowledge,
unless they are supervised by a person re-
sponsible for their safety or have been in-
structed on how to use the device. Children
should always be supervised to ensure that
they do not play with the device.
–
WARNING: This device contains hazard-
ous dust. Only specialists using suitable
protective equipment in accordance with
these operating instructions may perform
emptying and maintenance tasks, includ-
ing emptying the dust collection container.
Never operate the device without the com-
plete filtration system.
– When handling and extracting dusts that
are hazardous to health, the safety regula-
tions applicable in your country as well as
the specifications of the material manufac-
turer must be observed without fail.
– When extracting hazardous dust or large
quantities of oak or beech dust, only use
the machine in combination with a single
electric or pneumatic tool.
–
Risk of explosion and fire hazard: do
not extract sparks or hot dust, flammable
or explosive dust (e.g. magnesium, alu-
minium), flammable or explosive fluids
(e.g. petrol, thinner), aggressive fluids/
solids (e.g. acid, leach, solvent). The ex-
traction of wood dust is permitted. This
mobile dust extractor is suitable for ex-
tracting paint dust. Operate the machine in
a well-ventilated room (observe national
industrial safety regulations).
– Do not damage the mains power cable
(e.g. by driving over, dragging, etc.). Pro-
tect from heat, oil and sharp edges. Do not
pull the plug from the socket by the cable.
– Check the plug and the cable regularly and
have them replaced by an authorised ser-
vice workshop should either become dam-
aged cable with the type specified in the
spare parts list. Always replace the mains
power cable with the type specified in the
spare parts list.
– Do not expose the machine to rain.
– The machine should only be used by ap-
pointed persons instructed in correct ma-
chine handling.
– Before use, operators shall be provided
with information, instruction and training
for the use of the machine and the sub-
stances for which it is to be used, including
the safe method of removal and disposal of
the material collected.
– For reasons of safety, never operate the
machine from an unearthed socket.
– Always use the machine socket for the pur-
pose specified in the manual.
– Always use original Festool accessories.
– Pull the plug from the socket when the ma-
chine is not in use and prior to mainte-
nance and cleaning work.
– Do not lift or transport the machine by the
handle using a crane or lifting gear.
[1-10] Switch
[1-11] Warning sticker
[1-12] Locking clip
[1-13] Dust container
[1-15] Brake