BRAVO UM GB 15-05-2007 8:36 Pagina 1 F I A T B R A V O ENGLISH The data contained in this publication is intended merely as a guide. FIAT reserves the right to modify the models and versions described in this booklet at any time for technical and commercial reasons. If you have any further questions please consult your FIAT dealer. Printed in recycled paper without chlorine.
001-022 BRAVO GB:001-022 BRAVO GB 15-03-2011 12:04 Pagina 1 Dear Customer, Thank you for selecting Fiat and congratulations on your choice of a Fiat Bravo. We have written this handbook to help you get to know all your new Fiat Bravo features and use it in the best possible way. You should read it right through before taking the road for the first time.
001-022 BRAVO GB:001-022 BRAVO GB 15-03-2011 12:04 Pagina 2 MUST BE READ! REFUELLING K Petrol engines: only refuel with unleaded petrol with octane rating (RON) not less than 95 conforming to the European specification EN 228. Diesel engines: only refuel with diesel fuel conforming to the European specification EN590. Using other products or mixtures may damage the engine beyond repair and cause the forfeiture of the warranty cover for caused damages as a consequence.
001-022 BRAVO GB:001-022 BRAVO GB 15-03-2011 12:04 Pagina 3 ELECTRICAL ACCESSORIES If, after buying the car, you decide to add electrical accessories (that will gradually drain the battery), visit a Fiat Dealership. They can calculate the overall electrical requirement and check that the car’s electric system can support the required load. CODE card (for versions/markets, where provided) Keep the code card in a safe place, not in the car. The code card shall be used for requesting additional keys.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 001-022 BRAVO GB:001-022 BRAVO GB 4 15-03-2011 12:04 Pagina 4 DASHBOARD AND CONTROLS DASHBOARD ...................................................................... INSTRUMENT PANEL ........................................................ SYMBOLS ...............................................................................
001-022 BRAVO GB:001-022 BRAVO GB 15-03-2011 12:04 Pagina 5 DASHBOARD AND CONTROLS DASHBOARD 1. Side window air vent - 2. Adjustable and swivel air vent - 3. External light stalk - 4. Instrument panel - 5. Windscreen/rear window wiper/trip computer stalk - 6. Adjustable and swivel air vents - 7. Hazard light switch - 8. Front passenger air bag - 9. Glovebox - 10. Set of switches for front/rear fog lights and menu opening/setting - 11. Sound system controls - 12.
15-03-2011 12:04 Pagina 6 INSTRUMENT PANEL Versions with multifunction display A Speedometer (speed indicator) B Fuel level gauge with reserve warning light SAFETY DEVICES DASHBOARD AND CONTROLS 001-022 BRAVO GB:001-022 BRAVO GB C Engine coolant temperature gauge and excessive temperature warning light CORRECT USE OF THE CAR D Rev counter E Multifunction display.
12:04 Pagina 7 DASHBOARD AND CONTROLS 15-03-2011 Versions with reconfigurable multifunction display A Speedometer (speed indicator) SAFETY DEVICES B Fuel level gauge with reserve warning light C Engine coolant temperature gauge and excessive temperature warning light E Reconfigurable multifunction display. m c Warning lights fitted on diesel versions only fig. 4 IN AN EMERGENCY On diesel versions the rev counter end scale value is 6000 rpm.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 001-022 BRAVO GB:001-022 BRAVO GB 8 15-03-2011 12:04 Pagina 8 SYMBOLS THE FIAT CODE SYSTEM Special coloured labels have been attached near or actually on some of the components of your car. These labels bear symbols that remind you of the precautions to be taken as regards that particular component.
Each time the ignition key is turned to STOP, the Fiat CODE system deactivates the functions of the engine electronic control unit. If the code has not been recognised correctly, the instrument panel warning light Y (or symbol on display) will turn on. In this case, the key should be moved to the STOP position and then back to MAR; if the lock continues, possibly try again with the other key provided with the car. If it is still not possible to start the car contact a Fiat Dealership.
THE KEYS Together with the keys you will receive the CODE card fig. 7 to be presented to Fiat Dealership when requesting additional keys.
fig. 9 Press button Ë for more than 2 seconds to open the windows. F0Q0255m KEY WITH REMOTE CONTROL The key is fitted with a metal insert A-fig.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 001-022 BRAVO GB:001-022 BRAVO GB 12 15-03-2011 Closing the doors and the tailgate Briefly press button Á for remote locking of doors and tailgate and simultaneous alarm (for versions/markets, where provided) activation, switching off of the internal ceiling lights and single flashing of direction indicators.
DASHBOARD AND CONTROLS Pagina 13 REQUEST FOR ADDITIONAL REMOTE CONTROLS REPLACING THE BATTERY OF THE KEY WITH REMOTE CONTROL fig. 11 Battery replacement: ❒ press button A and open the metal insert B; Used batteries are harmful to the environment. They should be disposed of as specified by law in the special containers provided, or take them to a Fiat Dealership, which will deal with their disposal.
15-03-2011 DASHBOARD AND CONTROLS 001-022 BRAVO GB:001-022 BRAVO GB INDEX Pagina 14 WARNING Once the safe lock device has been actuated, doors cannot be opened from inside the car in any way whatsoever. For this reason, make sure there are no persons left inside the car. SAFETY DEVICES CORRECT USE OF THE CAR WARNING LIGHTS AND MESSAGES IN AN EMERGENCY TECHNICAL CAR SPECIFICATIONS MAINTENANCE 14 12:04 fig.
The main functions that can be activated with the keys (with or without remote control) are the following: Key with remote control Direction indicators flashing (only with key with remote control) Led on central dashboard Window opening Window closing – – – – – – – – Key turning counterclockwise (driver side) or clockwise (passenger side) (where provided) Key turning clockwise (driver side) or counterclockwise (passenger side) (where provided) Key turning counterclockwise (driver side) or clo
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 001-022 BRAVO GB:001-022 BRAVO GB 16 15-03-2011 ALARM (for versions/markets, where provided) The alarm function is provided in addition to all remote control functions previously described and it is controlled by the receiver located under the dashboard, next to the fuse box.
Engagement of the alarm is preceded by a self-diagnostic test. If a fault is detected the system sounds a further warning “beep” and the display shows the relevant message (see section “Warning lights and messages”). In this case, switch the alarm system off by pressing button Ë, check that the doors, bonnet and tailgate are properly shut, then switch the alarm on again by pressing button Á. Otherwise, the door, bonnet or tailgate that is not shut properly will be excluded from the alarm system control.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 001-022 BRAVO GB:001-022 BRAVO GB 18 15-03-2011 12:04 Pagina 18 VOLUME-SENSING/ ANTI-LIFT PROTECTION HOW TO CUT OFF THE ALARM SYSTEM To ensure correct operation of the protection, it is advisable to fully close the side windows and sun-roof (for versions/ markets, where provided).
WARNING In certain parking conditions (e.g. wheels steered) the force required to move the steering wheel to switch the function off may be high. ❒ STOP: engine off, key can be removed, steering column locked. Certain electrical devices (e.g.: sound system, central door locking, electronic alarm, etc.) can work. ❒ MAR: driving position. All electrical devices are powered. ❒ AVV: engine starting.
DASHBOARD AND CONTROLS SPEEDOMETER fig. 17 DASHBOARD LIGHTING ADJUSTMENT (Brightness sensor) (versions Sport with reconfigurable multifunction display) INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES INSTRUMENTS SAFETY DEVICES 15-03-2011 CORRECT USE OF THE CAR 001-022 BRAVO GB:001-022 BRAVO GB 20 12:04 Pagina 20 Instrument background color and type may vary according to the version. It shows the car speed.
The reserve warning light A-fig. 19 turns on to indicate that approx. 8-10 litres of fuel are left in the tank. E - tank empty. F - tank full (see contents of “At the filling station” paragraph in this chapter). fig. 19 Do not travel with the tank almost empty because the catalytic converter could become damaged. ENGINE COOLANT TEMPERATURE GAUGE IMPORTANT The needle sets to E with warning light A flashing to indicate that the system is failing.
MULTIFUNCTION DISPLAY Your car is fitted with the multifunction display that shows all the useful information necessary when driving. INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR DASHBOARD AND CONTROLS 15-03-2011 SAFETY DEVICES 001-022 BRAVO GB:001-022 BRAVO GB 22 12:04 Pagina 22 (for versions/markets, where provided) "STANDARD" SCREEN fig.
Note When opening one of the front doors the display will show for a few seconds the clock and covered km or miles. The setup menu can be activated by pressing briefly button MODE. Single presses on buttons ▲ or ▼ will scroll the setup menu options. Handling modes differ with each other according to the characteristic of the option selected.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 023-037 BRAVO GB:023-036 BRAVO GB 28-04-2010 12:08 Pagina 24 Example: Day English Deutsch Italiano Nederlands Español Français Briefly press button MODE to start surfing from the standard screen. To surf the menu use buttons ▲ or ▼.
28-04-2010 12:08 Pagina 25 DASHBOARD AND CONTROLS RECONFIGURABLE MULTIFUNCTION DISPLAY fig. 24 F0Q0041m fig. 25 F0Q0643m WARNING LIGHTS AND MESSAGES Rotating the starter’s key into MAR position, the main page will be displayed also showing the date fig. 23 or the boosting pressure of the turbocharger fig. 24 depending on the set-up selected from the menu, caption “Homepage” (“Date” of “Engine Info”). CONTROL BUTTONS fig.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 023-037 BRAVO GB:023-036 BRAVO GB 26 28-04-2010 Note Buttons ▲ and ▼ activate different functions according to the following situations: – to scroll the menu options upwards and downwards; – to increase or to decrease values during settings.
Single presses on buttons ▲ or ▼ will scroll the setup menu options. Handling modes differ with each other according to the characteristic of the option selected. If the car is equipped with Radionavigator, the only functions that can be adjusted/set through the instrument panel display are the following: “Dimmer”, “Speed Beep”, “Headl. sensor” (for versions/markets, where provided), “Belt buzzer” and “Passenger bag”.
TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 023-037 BRAVO GB:023-036 BRAVO GB 28-04-2010 12:08 Pagina 28 Example: Day English Deutsch Italiano Nederlands Español Français Briefly press button MODE to start surfing from the standard screen. To surf the menu use buttons ▲ or ▼.
With this function it is possible to adjust brightness of the instrument panel and of buttons and controls of sound system and automatic climate control system (where provided) according to 8 levels (for versions/markets, where provided).
12:08 Pagina 30 Headl. sensor (Automatic/dusk sensor headlights sensitivity adjustment) (for versions/markets, where provided) Trip B data (Trip On/Off) Set time (Setting the clock) Through this option it is possible to activate (On) or deactivate (Off) the Trip B (partial trip). This function enables the headlights to come on or go off depending on external lighting conditions. For further information see “Trip computer”.
– press again button MODE for long to go back to the standard screen or to the main menu according to the current menu level. – briefly press button MODE: “year” will flash on the display; This function enables to select the type of information displayed in the main screen. It is possible to display the date or the pressure of the turbo-compressor.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 023-037 BRAVO GB:023-036 BRAVO GB 32 28-04-2010 See radio (Audio repetition) 12:08 Pagina 32 Autoclose (Automatic central door locking when travelling) Units (Setting units) When activated (On), this function locks automatically the doors when the car speed exceeds 20 km/h.
– press button ▲ or ▼ to select the required level; To set the required language proceed as follows: – if selecting “Temperature”: pressing button MODE briefly, the display will show “°C” or “°F” according to previous setting; – briefly press button MODE: the previously set “language” will flash on the display; – briefly press button MODE: the previously set volume “level” will flash on the display; – press button ▲ or ▼ to select the required level; – press button ▲ or ▼ for setting; – press button
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 023-037 BRAVO GB:023-036 BRAVO GB 34 28-04-2010 Button vol. (Adjusting the button volume) With this function the volume of the roger-beep accompanying the activation of buttons MODE, ▲ and ▼ can be adjusted according to 8 levels.
– briefly press button MODE, to display the confirmation message and to go back to the menu screen or press the button for long to go back to the standard screen without storing settings.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 023-037 BRAVO GB:023-036 BRAVO GB 36 28-04-2010 Cornerning light (activation/deactivation of “Cornering lights”) (for versions/markets, where provided) This function makes it possible to activate/deactivate the “Cornering lights” (see the description in the “Exterior lights” paragraph).
fig. 26b F0Q0647m Trip distance This value shows the distance covered from the start of the new mission. Average consumption This value shows the average consumption from the start of the new mission. Instant consumption Represents the indicative average of consumptions from the beginning of the new mission. Average speed This value shows the car average speed as a function of the overall time elapsed since the start of the new mission.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 038-057 BRAVO GB:037-056 BRAVO GB 38 15-04-2010 16:47 Pagina 38 SEATS Fabric upholstery of your car is purpose-made to withstand common wear resulting from normal use of the car.
DASHBOARD AND CONTROLS Pagina 39 Seat adjustment controls are the following: Multifunction control A: ❒ to adjust height; fig. 28 F0Q0601m ELECTRICALLY ADJUSTABLE FRONT SEATS fig. 28 (for versions/markets, where provided) Adjustment is possible when the ignition key is at MAR or within 1 minute with ignition key at STOP or removed. When opening one of the front doors, it is possible to adjust the seat on the side of the door opened for about 3 minutes or until closing the door.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 038-057 BRAVO GB:037-056 BRAVO GB 40 15-04-2010 16:47 Pagina 40 HEAD RESTRAINTS FRONT Head restraints are adjustable in height and they lock automatically in the required position. ❒ to raise: raise the head restraint until hearing the locking click. ❒ to lower: press button A-fig. 30 and lower the head restraint.
STEERING WHEEL REARVIEW MIRRORS The steering wheel can be adjusted both axially and in height. DRIVING MIRROR Release the lever A-fig. 32 pulling it towards the steering wheel, then adjust it in the most suitable position and lock it pushing the lever A fully forwards. WARNING Any adjustment of the steering wheel position must be carried out only with the car stationary and the engine turned off. fig.
15-04-2010 16:47 Pagina 42 INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 038-057 BRAVO GB:037-056 BRAVO GB 42 F0Q00658m fig. 34 fig. 35 F0Q0623m DOOR MIRRORS Electrical adjustment Manual folding This operation is only possible with ignition key at MAR.
038-057 BRAVO GB:037-056 BRAVO GB 15-04-2010 16:47 Pagina 43 1. Upper fixed vent for defrosting or demisting windscreen - 2. Centre adjustable vent -3. Fixed vents for defrosting or demisting side windows - 4. Side adjustable and swivel vents - 5. Lower vents - 6. Rear adjustable and swivel outlet - 7. Rear feet area fixed vents. INDEX F0Q0668m fig.
15-04-2010 16:47 Pagina 44 F0Q0626m fig. 38 IN AN EMERGENCY INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE 44 F0Q0627m fig. 40 CENTRAL VENTS fig. 40 A - Controls for directing air flow (up/down, right/left). WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 038-057 BRAVO GB:037-056 BRAVO GB B - Air flow adjusting controls: ç = completely closed O = completely open. F0Q0750m fig. 41 REAR VENT fig.
038-057 BRAVO GB:037-056 BRAVO GB 15-04-2010 16:47 Pagina 45 DASHBOARD AND CONTROLS HEATING AND VENTILATION SAFETY DEVICES CONTROLS fig.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 038-057 BRAVO GB:037-056 BRAVO GB 46 15-04-2010 16:47 Pagina 46 Preventive demisting procedure FAN SPEED ADJUSTMENT In the event of considerable outside moisture and/or rain and/or considerable differences in temperature inside and outside the passenger compartment, perform the following preventive demisting procedure: To ventilate the passeng
15-04-2010 16:47 Pagina 47 DASHBOARD AND CONTROLS MANUAL CLIMATE CONTROL SYSTEM SAFETY DEVICES (for versions/markets, where provided) CONTROLS fig. 43 CORRECT USE OF THE CAR A: Air temperature knob (mixing hot and cold air) B: Heated rear window on/off button C: Fan knob F: Air distribution knob. WARMING THE PASSENGER COMPARTMENT fig.
FRONT WINDOW FAST DEMISTING/DEFROSTING ❒ rotate completely knob A to the right; INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR DASHBOARD AND CONTROLS 15-04-2010 SAFETY DEVICES 038-057 BRAVO GB:037-056 BRAVO GB 48 Proceed as follows: ❒ press button ❄; 16:47 Pagina 48 Climate control system is very useful to speed up demisting since it dehumidifies the air.
Proceed as follows: This function is particularly useful when the outside air is heavily polluted (in a traffic jam, tunnel, etc.) However, it is better not to use it for long periods, especially if there are several people in the car. IMPORTANT The inside air recirculation system makes it possible to reach the required “heating” or “cooling” conditions faster. Do not use the air recirculation function on rainy/cold days as it would considerably increase the possibility of the windows misting inside.
DASHBOARD AND CONTROLS 038-057 BRAVO GB:037-056 BRAVO GB 15-04-2010 16:47 Pagina 50 AUTOMATIC TWO-ZONE CLIMATE CONTROL SYSTEM INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES (for versions/markets, where provided) 50 DESCRIPTION The car is fitted with a two-zone climate control system which makes it possible to separately adjust the air temperature on the driver’s side and on the passenger’s side.
The climate control system compressor works only with the engine running and outside temperature over 4°C. ❒ fan speed adjustment knob; ❒ air inlet in the passenger’s compartment; ❒ inside air recirculation and AQS function on/off button; ❒ air distribution in the passenger’s compartment; thus cancelling all the previous manual adjustments. When the climate control system is working automatically, FULL AUTO is displayed. ❒ air distribution selection button; ❒ climate control compressor button.
SAFETY DEVICES DASHBOARD AND CONTROLS 038-057 BRAVO GB:037-056 BRAVO GB 15-04-2010 FAN SPEED ADJUSTMENT To adjust the fan speed, press button p. The 12 selectable speeds are shown by the lighting up of the bars on the climate control system display: ❒ max fan speed = all bars lit INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR ❒ min fan speed = one bar lit.
❒ forced switching off (inside air recirculation always off with air inlet from outside), button led T off; IMPORTANT The inside air recirculation system makes it possible to reach the required “heating” or “cooling” conditions faster. It is however inadvisable to use it on rainy/cold days as it would considerably increase the possibility of the windows misting inside, especially if the climate control system is off.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 038-057 BRAVO GB:037-056 BRAVO GB 54 15-04-2010 ALIGNMENT OF SET TEMPERATURES (MONO function) Pressing button MONO automatically aligns the temperature on the passenger’s side with that on the driver’s side. 16:47 Pagina 54 CLIMATE CONTROL COMPRESSOR ON/OFF Press button ❄ to switch on the climate control compressor.
Q Splitting of the air flow between E centre and side dashboard outlets, rear outlet and windscreen and side window demisting/defrosting vents. This type of air distribution allows satisfactory ventilation of the passenger compartment while preventing possible misting of the windows. ❒ writing OFF; To restore automatic air distribution control after a manual selection, press button AUTO.
SAFETY DEVICES DASHBOARD AND CONTROLS 038-057 BRAVO GB:037-056 BRAVO GB 15-04-2010 16:47 Pagina 56 EXTERNAL LIGHTS The left-hand stalk fig. 45 controls the external lights. The external lights can only be switched on when the ignition key is at MAR. INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR LIGHTS SWITCHED OFF 56 Knurled ring turned to O. fig. 45 SIDELIGHTS PARKING LIGHTS DIRECTION INDICATORS fig.
F0Q0651m fig. 48 F0Q0652m “Cornering lights” Activation With low beams on at a speed of less than 40 km/h, when the steering wheel is turned through a large angle or upon activation of the direction indicator, a light (incorporated in the fog lamp) will come on to expand the angle of night-time visibility on the side to which the vehicle is turned. With the ignition key at STOP or removed, pull the stalk towards the steering wheel and operate it within 2 minutes from when the engine is turned off.
10:17 Pagina 58 WINDOW WASHING The device can only work when the ignition key is at MAR. INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR DASHBOARD AND CONTROLS 8-04-2010 SAFETY DEVICES 058-082 BRAVO GB.qxd 58 IMPORTANT When the wiper is on, engaging reverse gear automatically turns on the rear window wiper. WINDSCREEN WASHER/ WIPER fig. 49 Never use the window wiper to remove ice or snow from the windscreen.
IMPORTANT Keep clean the glass in the sensor area. fig. 50 F0Q0646m “Smart washing” function fig. 50 Pulling the lever towards the steering wheel (unstable position) operates the windscreen washer. Keeping the stalk pulled, with just one movement it is possible to operate the washer jet and the wiper at the same time; indeed, the latter comes into action automatically if the stalk is pulled for more than half a second.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 058-082 BRAVO GB.qxd 60 8-04-2010 10:17 Pagina 60 Deactivation Turn the ignition key to STOP. At next engine starting (key at MAR), the sensor will not be reactivated even is the stalk is on B-fig. 49. In this event, to activate the rain sensor, you have to move the stalk to A or C and then again to B.
❒ turn the knurled ring A-fig. 54 to ON and press the accelerator pedal to the required speed; (for versions/markets, where provided) It is a device able to support the driver, with electronic control, which allows driving at speed over 30 km/h on long and straight dry roads (e.g.: motorways), at a desired speed, without pressing the accelerator pedal. Therefore it is not suggested to use this device on extra-urban roads with traffic. Do not use it in town. fig.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 058-082 BRAVO GB.
Ceiling light timing FRONT CEILING LIGHT WITH SPOT LIGHTS fig. 55 To facilitate getting in/out of the car at night or with poor lighting, 2 different timed switching on modes have been provided. Switch A turns on/off the ceiling lights. Light turning on/off is gradual. Switch B performs the spot function; with ceiling light off, it will turn on: ❒ light C if pressed on the left side; ❒ light D if pressed on the right side. Lights will turn on as follows: fig.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 058-082 BRAVO GB.qxd 64 8-04-2010 10:17 Pagina 64 Light timing when getting out of the car After removing the key from the ignition switch, the ceiling lights will turn on as follows: ❒ within 2 minutes from turning the engine off for about 10 seconds; ❒ when opening one of the side doors for about 3 minutes; F0Q0670m fig.
Pagina 65 DASHBOARD AND CONTROLS CONTROLS Emergency braking In the event of emergency braking the emergency lights automatically turn on and at the same time the lights Î and ¥ turn on on the dashboard. The function automatically turns off when the emergency braking stops. This function complies with the current applicable laws. FRONT FOG LIGHTS (for versions/markets, where provided) To turn front fog lights on, press button B-fig.
8-04-2010 10:17 Pagina 66 FUEL CUT-OFF SYSTEM (as an alternative to the fuel cut off switch, for versions/markets where provided) This system intervenes in the event of a collision, activating: Carefully inspect the car to find fuel leaks, e.g. in the engine compartment, under the car or near the tank. If no fuel leaks are found and the car can be started again, press button A to reset the fuel system and the lights.
058-082 BRAVO GB.qxd 8-04-2010 10:17 Pagina 67 DASHBOARD AND CONTROLS INTERIOR FITTINGS F0Q0631m fig. 63 F0Q0634m fig. 62 F0Q0632m fig. 64 F0Q0633m CORRECT USE OF THE CAR fig. 61 The armrest can be adjusted longitudinally by operating the cover A-fig. 61. Pay attention not to spill the drinks: the food box bottom however is provided with a hole to drain spilled liquids, if any. Conditioned food box Press button A-fig. 63 and raise the armrest B to reach the conditioned food box fig. 64.
8-04-2010 10:17 Pagina 68 CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 058-082 BRAVO GB.qxd fig. 66 ODDMENT COMPARTMENTS Oddment compartment on passenger’s side WARNING LIGHTS AND MESSAGES IN AN EMERGENCY INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE 68 F0Q0635m Open the oddment compartment moving the handle A-fig. 66 as shown by the arrow. fig. 65 F0Q0010m REAR ARMREST (for versions/markets, where provided) To use the rear armrest A-fig. 65, lower it as shown in the figure.
8-04-2010 10:17 Pagina 69 Some versions may also be fitted with a power point A-fig. 68 located in the luggage compartment. fig. 69 F0Q0630m CIGAR LIGHTER (for versions/markets, where provided) ASHTRAY (for versions/markets, where provided) It is located on the central console, near the handbrake lever. It consists of a spring-release removable plastic container fig. 69, that can be located in the glass/can holder recesses on the central console. Press button A-fig.
8-04-2010 10:17 Pagina 70 INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 058-082 BRAVO GB.qxd 70 fig. 70 F0Q0671m fig. 71 F0Q0672m fig. 73 F0Q0674m fig. 72 F0Q0673m fig. 74 F0Q0676m GLASS HOLDERS fig. 70 The central console houses two recesses for glasses, cups or cans. ODDMENT COMPARTMENTS They are set near the cigar lighter fig. 71, near the handbrake fig.
On certain versions, the driver’s sun visor is fitted with a courtesy mirror and a light. Passenger’s side The passenger’s sun visor is fitted with a courtesy mirror (on certain versions the mirror is fitted with a light). fig. 75 Driver and passenger’s sun visors can be adjusted forwards and sidewards. Lift the lid A to use the mirror. On certain versions, the passenger’s sun visor is fitted, on the back, with a courtesy mirror with a light that enables to use the mirror also with poor sunlight.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 058-082 BRAVO GB.qxd 72 8-04-2010 10:17 Pagina 72 SUNROOF (for versions/markets, where provided) The sunroof consists of two wide panes (a fixed one and a moving one), fitted with two manually-operated sun curtains (front and rear). Sun curtains can be used in “wide close” and “wide open” positions (no fix intermediate positions).
Sunroof is fitted with anti-crushing safety system that detects the presence of an obstacle during sunroof closing stroke and that cuts in by stopping and reversing the sunroof stroke. SAFETY DEVICES ANTI-CRUSHING SAFETY SYSTEM CORRECT USE OF THE CAR Do not open the sunroof if there is snow or ice on it: it could be damaged. WARNING When leaving the car, the ignition key should be removed to prevent the sunroof from being operated inadvertently and harming anyone remaining in the car.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 058-082 BRAVO GB.qxd 74 8-04-2010 10:17 Pagina 74 INITIALISATION PROCEDURE EMERGENCY OPERATION Sunroof shall be re-initialised after disconnecting the battery or if the relevant protection fuse is blown. If the switch does not work, the sunroof can be operated manually as follows: Proceed as follows: ❒ Press button A-fig.
Pagina 75 DASHBOARD AND CONTROLS DOORS With the doors closed, fit and turn the key in one of the front door locks. From inside From inside the car (with doors closed) press the door lock/unlock button fig. 79 set on the dashboard. Doors can however be closed manually if the electric system is failing. IMPORTANT The rear doors cannot be opened from inside when the child lock is engaged. fig. 79 F0Q0641m CHILD LOCK fig. 80 To prevent opening the rear doors from the inside. fig.
8-04-2010 10:17 Pagina 76 DASHBOARD AND CONTROLS 058-082 BRAVO GB.qxd To realign the lock knobs (only if battery charge is restored) proceed as follows: ❒ press the key button Ë; INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES ❒ press door lock/unlock button ≈ on the instrument panel; 76 ❒ opening with the key in front door revolving plug; fig. 81 F0Q0679m REAR DOORS EMERGENCY LOCK DEVICE fig.
Front driver side door fig. 82 IMPORTANT In the event that the anticrushing function is activated 5 times in only 1 minute, the system will automatically enter the “recovery” mode (self-protection). This conditions is pointed out by the fact that, in the closing phase, the window goes up in jerks.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 058-082 BRAVO GB.qxd 78 8-04-2010 10:17 Pagina 78 Press buttons A or B to open/close the required window. MANUAL REAR WINDOWS (for versions/markets, where provided) Pressing briefly one of the buttons the window “jerks” whereas a prolonged pressing makes the window opening or closing in “automatic continuous” mode.
To close, lower the tailgate until the lock clicks. When release, the luggage compartment may be opened from outside the car by operating the electric logo fig. 84. To open the tailgate use the key with remote control. If the boot is not shut properly the instrument panel warning light ´ or symbol R will turn on together with the message on the display (see section “Warning lights and messages”).
8-04-2010 10:17 Pagina 80 INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 058-082 BRAVO GB.qxd 80 fig. 86 F0Q0681m WARNING When using the boot, make sure the loads you are carrying do not exceed the permitted weight (see section “Technical specifications”).
8-04-2010 10:18 Pagina 81 Proceed as follows: ❒ lower completely the rear seat head restraints; ❒ move the seat belt sideways and check that the belt is not twisted; ❒ fold cushions forward as described previously; ❒ remove the rear parcel shelf fig. 90 and release the upper ends A-fig. 91 of the two tie rods by removing eyelets from the pins and pushing them in arrow direction; ❒ after tilting the cushion, fold completely rear seat backs (as described previously) to have one single surface.
8-04-2010 10:18 Pagina 82 fig. 93 F0Q0685m Two attachments fig. 93 located inside the luggage compartment are used to anchor cables that insure transported loads are firmly secured and two attachments on the rear crossmember fig. 94. IMPORTANT Never anchor to single hooks a load exceeding 100 kg. INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE WARNING LIGHTS AND MESSAGES ANCHORING THE LOAD IN AN EMERGENCY CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 058-082 BRAVO GB.
1-04-2011 15:44 Pagina 83 BONNET DASHBOARD AND CONTROLS 083-110 BRAVO GB:083-104 BRAVO GB B TO OPEN THE BONNET ❒ pull lever A-fig. 96 in the direction of the arrow; fig. 97 F0Q0690m fig. 98 F0Q0748m TO CLOSE THE BONNET WARNING LIGHTS AND MESSAGES Proceed as follows: ❒ hold the bonnet up with one hand and with the other remove rod C-fig. 98 from recess D and fit it back into its catch; ❒ lower the bonnet at approx.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 083-110 BRAVO GB:083-104 BRAVO GB 84 1-04-2011 WARNING For safety reasons the bonnet must be closed properly to avoid its opening while the car is travelling. Therefore, always check it is properly closed and the catch engaged. Should you notice that the catch is not perfectly engaged when travelling, stop the car immediately and close the bonnet.
Position 0 - one or two passengers on front seats. Proper adjustment of the headlight beams is of vital importance for your safety and comfort and also for the other road users. To ensure you and other drivers have the best visibility conditions when travelling with the headlights on, the headlights must be set properly. Contact Fiat Dealership to have the headlights properly adjusted. Position 1 - five passengers.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 083-110 BRAVO GB:083-104 BRAVO GB 86 1-04-2011 ABS SYSTEM The car is fitted with ABS braking system, which prevents the wheels from locking when braking, makes the most of road grip and gives the best control when emergency braking under difficult road conditions.
WARNING If the instrument panel warning light x turns on (together with the message on the display), stop the car immediately and contact the nearest Fiat Dealership. Fluid leaks from the hydraulic system, in fact, can compromise the braking system, both traditional systems and systems with ABS. In this case with sharp braking the rear wheels might lock too early, with the possibility of skidding. Drive extremely carefully to the nearest Fiat Dealership to have the system checked.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 083-110 BRAVO GB:083-104 BRAVO GB 88 1-04-2011 ESP SYSTEM (Electronic Stability Program) 15:44 Pagina 88 ESP SYSTEM ACTIVATION HILL HOLDER SYSTEM The ESP system is automatically activated when the car is started and cannot be de-activated. This system is an integral part of the ESP system and it is provided to facilitate starting on slopes.
WARNING For correct operation of the ESP and ASR systems, the tyres must absolutely be of the same brand and type on all wheels, in perfect conditions and, above all, of type, brand and size specified. WARNING During the use of the spacesaver spare wheel, the ESP system carries on working. However, you must remind that the space-saver spare wheel has dimensions smaller than the standard tyre and therefore its grip is reduced as to the other car tyres.
1-04-2011 DASHBOARD AND CONTROLS 083-110 BRAVO GB:083-104 BRAVO GB INDEX Pagina 90 FAILURE INDICATIONS In the event of malfunctioning, the ASR system is automatically disconnected and the warning light á will turn on with fixed light on the instrument panel (together with the message on the display) (see section “Warning lights and messages”). In this case contact Fiat Dealership as soon as possible.
1-04-2011 15:44 Pagina 91 DASHBOARD AND CONTROLS START&STOP SYSTEM (for versions/markets, where provided) F0Q0771m The system is active every time the engine is started. TURNING THE SYSTEM ON/OFF MANUALLY OPERATING MODES To activate/deactivate the system manually, press the button T fig. 103 on the dashboard, next to the steering wheel. Versions with reconfigurable multifunction display: symbol T and a message will appear on the display when the Start&Stop system is off.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 083-110 BRAVO GB:083-104 BRAVO GB 92 1-04-2011 15:44 Pagina 92 FAILED ENGINE CUT-OUT CONDITIONS ❒ reverse gear engaged (for example, for parking manoeuvres); When the system is operating, due to comfort, emission control and safety reasons, the engine does not stop in some conditions, among which: ❒ for versions equipped with dual zone automat
For reasons of comfort, limiting harmful emissions and safety purposes, the power unit can restart automatically without any action on behalf of the driver if certain conditions are met, including: If the clutch is not pressed, after 3 minutes from the engine stopping, the engine can be restarted only using the ignition key.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 083-110 BRAVO GB:083-104 BRAVO GB 94 1-04-2011 15:44 Pagina 94 ENERGY SAVING FUNCTION (for versions/markets, where provided) WARNING When replacing the battery, always go to a Fiat Dealership. Replace the battery using a new one of the same type (HEAVY DUTY) and having the same specifications.
15:44 Pagina 95 DASHBOARD AND CONTROLS 1-04-2011 EMERGENCY STARTING F0Q0761m WARNING LIGHTS AND MESSAGES WARNING Before opening the engine hood, make sure that the engine is off and that the ignition key is in STOP position. Follow the instructions on the plate affixed on the front crossmember (fig. 106). You are advised to extract the key when other people are inside the car. Remove the ignition key or turn it to the STOP position before leaving the car.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 083-110 BRAVO GB:083-104 BRAVO GB 96 1-04-2011 EOBD SYSTEM The European On Board Diagnostic system (EOBD), fitted to engine electronic control units, allows monitoring and warning of any malfunction to the electronic systems that could increase exhaust emissions.
15:44 Pagina 97 SOUND SYSTEM WARNING For connection to existing car presetting system, contact Fiat Dealership to prevent any trouble that could impair car safety. (for versions/markets, where provided) The sound system shall be installed in the proper space occupied by the central oddment compartment A-fig. 107, here you will find the preset cables. To remove the oddment compartment press the retaining devices in the points shown in the figure.
INSTALLATION OF ELECTRIC/ELECTRONIC DEVICES Electric/electronic devices installed after buying the car and in after-market shall bear the following marking: INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR DASHBOARD AND CONTROLS 1-04-2011 SAFETY DEVICES 083-110 BRAVO GB:083-104 BRAVO GB 98 Fiat Group Automobiles S.p.A.
1-04-2011 15:44 Pagina 99 To connect/disconnect the CITY function, press button A-fig. 108 set on the dashboard next to the steering wheel. Activation of this function is indicated by the word CITY on the instrument panel display (on certain versions it is also indicated by the turning on of the CITY warning light). When the CITY function is on the steering wheel effort is lighter and thus parking operations are easier: therefore this function is particularly useful for driving in city centres.
1-04-2011 This function enables the engine control unit to reach maximum pressure levels inside the turbocharger, depending on the position of the accelerator pedal and for a limited time. This enables to achieve an increased engine torque. This function is quite useful if maximum performance is required for a short time (e.g. overcoming other vehicles). IMPORTANT when the SPORT button is pressed, the function activates after about 5 seconds.
WARNING The T.P.M.S. system does not exempt the driver to check tyre and spare wheel pressure at regular intervals (see paragraph “Wheels” in section “Car maintenance”). IMPORTANT NOTES Failure indications will not be stored and therefore will not be displayed when turning the engine off and on again. If failure persists, the control unit will send warning indications to the instrument panel only after a few seconds when the car is moving. Tyre pressure should be checked with tyres cold.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 083-110 BRAVO GB:083-104 BRAVO GB 102 1-04-2011 The T.P.M.S. system requires special equipment. Contact Fiat Dealership to know what type of accessories are compatible with the system (wheels, wheel caps, etc.). Using other accessories could cause system malfunctioning.
Failure indication Fiat Dealership service operation – – YES Contact Fiat Dealership Wheel change with spare wheel NO YES Repair damaged wheel Wheel change with snow tyres NO YES Contact Fiat Dealership Wheel change with snow tyres YES NO – Wheel change with others of different size (*) YES NO Contact Fiat Dealership Wheel cross switching (front/rear) (**) YES NO – (*) Given as an alternative on the Owner Handbook and available at Lineaccessori Fiat.
TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 083-110 BRAVO GB:083-104 BRAVO GB 1-04-2011 15:44 Pagina 104 PARKING SENSORS (for versions/markets, where provided) Parking sensors inform the driver about the presence of obstacles behind the car (versions fitted with 4 rear sensors) or behind and in front of the car (versions fitted with 4 rear sensors and 4 front sensors). fig.
WARNING Parking manoeuvres however are always under the driver’s responsibility that shall always check the absence of people (specially children) or animals in the manoeuvre space. This system is just a help for the driver but she/he shall never reduce attention during dangerous manoeuvres even if performed at low speed. When the reverse gear is engaged an intermittent acoustic signal is automatically activated.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 083-110 BRAVO GB:083-104 BRAVO GB 106 1-04-2011 The acoustic signal: ❒ becomes louder as the reduction of distance between the car and the obstacle decreases; ❒ becomes continuous when the distance between the car and the obstacle is less that 30 cm and stops immediately if the distance raises; ❒ is constant if the distance is unvaried.
When parking, take the utmost care to obstacles set above or under the sensors. Sensors are reactivated when removing the trailer cable plug. IMPORTANT If you wish to leave the tow-hook fitted without a trailer attached, contact your Fiat Dealership to update the system because the tow-hook will be detected as an obstacle by the central sensors.
DASHBOARD AND CONTROLS 083-110 BRAVO GB:083-104 BRAVO GB 1-04-2011 AT THE FILLING STATION INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES PETROL ENGINES 108 Use only unleaded petrol. To prevent errors, the diameter of the fuel tank filler is too small to introduce a lead petrol pump filler. Use petrol with a rated octane number (R.O.N.) not lower than 95.
1) Open the flap A pulling it outwards, keep the cap B still, insert the ignition key in the lock and turn it anti-clockwise. 2) Turn the cap anti-clockwise and extract it. The cap has a device C retaining it to the flap so it cannot be lost. When refilling, attach the cap to the flap, as illustrated. Closing 1) Fit the cap (complete with key) and turn it clockwise until it clicks once or more. 2) Turn the key clockwise and extract it, then close the flap. fig.
15:44 Pagina 110 PROTECTING THE ENVIRONMENT DIESEL PARTICULATE FILTER (DPF) (for versions/markets, where provided) The devices for curtailing petrol engine emissions are the following: ❒ three-way catalytic converter; The Diesel Particulate Filter is a mechanical filter, integral with the exhaust system, that physically traps particulate present in the exhaust gases of Diesel engines. ❒ Lambda sensor; ❒ fuel evaporation system.
S.B.R. SYSTEM ....................................................................... 113 PRETENSIONERS.................................................................. 114 CARRYING CHILDREN SAFELY...................................... 117 PRESETTING FOR MOUNTING THE ISOFIX CHILD RESTRAINT SYSTEM .............................. 122 FRONT AIR BAGS................................................................ 124 SIDE AIR BAGS (Side bag - Window bag) ......................
23-04-2010 The belt should be worn keeping the chest straight and rested against the seat back. To fasten seat belts, take the tongue A-fig. 1 and insert it into the buckle B, until hearing the locking click. WARNING LIGHTS AND MESSAGES At removal, if it jams, let it rewind for a short stretch, then pull it out again without jerking. Through the reel, the belt automatically adapts to the body of the passenger wearing it, allowing freedom of movement.
Always adjust the height of the seat belt to fit the person wearing it. This precaution could greatly reduce the risk of injury in case of collision. Correct adjustment is obtained when the belt passes half way between the end of the shoulder and the neck. fig. 4 F0Q0697m WARNING Make the height adjustment when the car is stationary. WARNING After adjustment, always check that the slider is anchored in one of the positions provided. To do this, with the button Afig.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 111-130 BRAVO GB.qxd:105-128 BRAVO GB 114 23-04-2010 PRETENSIONERS To increase the efficiency of the front and rear (for versions/markets, where provided) seat belts, the car is fitted with pretensioners. These devices, in the event of violent front and side crash, rewind the seat belts a few centimetres.
23-04-2010 11:46 Pagina 115 Seat belts are also to be worn by expectant mothers: the risk of injury in the case of accident is greatly reduced for them and the unborn child if they are wearing a seat belt. Of course they must position the lower part of the belt very low down so that it passes under the abdomen (as illustrated in fig. 5). IMPORTANT The belt should not be twisted. The upper part should pass over the shoulder and cross the chest diagonally.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 111-130 BRAVO GB.qxd:105-128 BRAVO GB 116 23-04-2010 WARNING Under no circumstances should the components of the seat belts and pretensioners be tampered with or removed. Any operation should be carried out by qualified and authorised personnel. Always contact a Fiat Dealership.
0-10 kg in weight This is even more important for children. Group 0+ 0-13 kg in weight This prescription is compulsory in all EC countries according to EC Directive 2003/20/EC. Group 1 9-18 kg in weight Group 2 15-25 kg in weight Group 3 22-36 kg in weight Compared with adults, their head is proportionally larger and heavier than the rest of the body, while the muscles and bone structure are not completely developed. Therefore, correct restraint systems are necessary, other than adult seat belts.
23-04-2010 11:46 Pagina 118 DASHBOARD AND CONTROLS 111-130 BRAVO GB.qxd:105-128 BRAVO GB F0Q0429m fig. 9 F0Q0772m GROUP 1 Babies up to 13 kg must be carried facing backwards on a cradle seat, which, supporting the head, does not induce stress on the neck in the event of sharp deceleration. Starting from 9 kg to 18 kg in weight, children may be carried facing forwards fig. 9. The cradle is restrained by the car seat belts, as shown in fig.
23-04-2010 11:46 Pagina 119 GROUP 2 GROUP 3 Starting from 15 kg to 25 kg in weight, children may be restrained directly by the car belts fig. 10. The only function of the seat is to position the child correctly in relation to the belts, so that the diagonal part adheres to the chest and not to the neck and that the horizontal part clings to the child’s pelvis and not the abdomen. For children between 22 kg and 36 kg, there are boosters allowing the seatbelt to fit correctly. Fig.
CORRECT USE OF THE CAR INDEX 11:46 Pagina 120 Your car complies with the new European Directive 2000/3/EC regulating child’s seat assembling on the different car seats according to the following table: WARNING LIGHTS AND MESSAGES IN AN EMERGENCY TECHNICAL CAR SPECIFICATIONS MAINTENANCE 120 23-04-2010 SUITABILITY OF PASSENGER SEATS FOR CHILD SEAT USE SAFETY DEVICES DASHBOARD AND CONTROLS 111-130 BRAVO GB.
3) Attain to the instructions for fastening the specific child restraint system which you are using. These instructions must be provided by the manufacturer. Keep the child restraint system installation instructions with the car documents and this Handbook. Never use a child restraint system without installation instructions. 6) Always check the seat belts do not fit around the child’s throat. 7) While travelling, do not let the child sit incorrectly or release the belts.
23-04-2010 fig. 13 F0Q0698m fig. 14 F0Q0699m WARNING LIGHTS AND MESSAGES IN AN EMERGENCY It is possible to mount at the same time both the traditional restraint system and the Isofix one. Other weight groups are covered by a specific Isofix child seat that can be used only if specifically designed, tested and approved for his vehicle (see the list of vehicles accompanying the child seat).
Child’s seat orientation Group 0 to 10 kg Facing backwards E IL Facing backwards E IL Facing backwards D IL Facing backwards C IL (*) Facing backwards D IL Facing backwards C IL (*) Facing forwards B IUF Facing forwards B1 IUF Facing forwards A IUF Group 0+ to 13 kg Group I - 9 to 18 kg Isofix class Isofix position side rear IUF: suitable for Isofix child restraint systems to be set facing forwards, universal class (fitted with third upper fastener), approved for the weight
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 111-130 BRAVO GB.qxd:105-128 BRAVO GB 124 23-04-2010 FRONT AIR BAGS The car is fitted with front air bags for the driver, for the passenger and with driver’s knees air bag (for versions/markets, where provided).
It consists of an instant-inflating cushion contained into a special recess in the dashboard, this cushion has a volume bigger than that of the driver. The driver’s and passenger’s front Air bags have been designed and calibrated to improve the protection of a person wearing seat belts. At their maximum inflation, their volume fills most of the space between the dashboard and the passenger. DASHBOARD AND CONTROLS SAFETY DEVICES AUTO fig. 17 F0Q0702m DRIVER’S KNEES AIR BAG fig.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 111-130 BRAVO GB.qxd:105-128 BRAVO GB 126 23-04-2010 MANUAL DEACTIVATION OF PASSENGER’S FRONT AIR BAG AND SIDE BAG Should it be absolutely necessary to carry a child on the front seat, the passenger’s front air bag and the side bag (where provided) can be deactivated.
WINDOW BAGS fig. 19 (for versions/markets, where provided) It is formed by two "curtain" window bags are located behind the side roof upholstery and are covered by special trimming. They were designed to protect the head of front and rear passengers in case of side collisions, thanks to the wide cushion inflation surface. In minor side crashes (for which the restraining action of the seat belts is sufficient), the air bags are not deployed.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 111-130 BRAVO GB.
WARNING When the ignition key is turned to MAR, the warning light “ (with passenger’s front Air bag on) turns on and flashes for few seconds to remind that the passenger’s air bag will be deployed in a crash, after which it should go off. WARNING The air bag does not substitute the seat belts, but only increases their effectiveness.
111-130 BRAVO GB.
CORRECT USE OF THE CAR ENGINE STARTING ........................................................... 132 DASHBOARD AND CONTROLS Pagina 131 TOWING TRAILERS............................................................ 139 SNOW TYRES ....................................................................... 141 SNOW CHAINS ................................................................... 141 CAR INACTIVITY ...............................................................
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 131-142 BRAVO GB:129-140 BRAVO GB 132 8-04-2010 10:22 Pagina 132 ENGINE STARTING STARTING PROCEDURE FOR PETROL VERSIONS The car is fitted with an electronic engine lock device: if the engine fails to start, see the paragraph “The Fiat CODE system” in section “Dashboard and controls”.
❒ turn the ignition key to MAR. The warning lights m and Y (or the symbol on display) on the instrument panel will turn on; ❒ wait for the warning lights Y (or the symbol on display) and m to turn off. The hotter the engine is, the quicker this will happen; ❒ press the clutch pedal down to the floor without touching the accelerator; ❒ turn the ignition key to AVV as soon as warning light m turns off. If you wait too long you will lose the benefit of the work done by the glow plugs.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 131-142 BRAVO GB:129-140 BRAVO GB 134 8-04-2010 HOW TO WARM UP THE ENGINE AFTER IT HAS JUST STARTED (petrol and diesel engines) Proceed as follows: ❒ Drive off slowly, letting the engine turn at medium revs. Do not accelerate abruptly; 10:22 Pagina 134 STOPPING THE ENGINE Turn the ignition to STOP while the engine is idling.
The handbrake lever is located between the two front seats. ❒ Stop the engine and engage the handbrake; Pull the handbrake lever upwards until the car cannot be moved. ❒ Engage a gear (1st if the car is faced uphill or reverse if it is faced downhill) and leave the wheels steered. Block the wheels with a wedge or a stone if the car is parked on a steep slope. Do not leave the ignition key at MAR to prevent draining the battery. Always remove the key when you leave the car.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 131-142 BRAVO GB:129-140 BRAVO GB 136 8-04-2010 10:22 Pagina 136 USING THE GEARBOX To engage the gears, press the clutch pedal fully and shift the gear lever into the required position (the diagram of gear position is shown on the knob fig. 2, fig. 3 and fig. 4. To engage 6th gear (1.416V, 1.4 T-JET, 1.4 Turbo Multi Air, 1.6 Multijet, 1.
The air conditioner is an additional load which greatly affects the engine leading to higher consumption (on average up to +20%). When the temperature outside the car permits it, use the air vents where possible. Roof rack/ski rack GENERAL CONSIDERATIONS Car maintenance Have checks and adjustments carried out in accordance with the “Service schedule”.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 131-142 BRAVO GB:129-140 BRAVO GB 138 8-04-2010 DRIVING STYLE Starting Do not warm the engine with the car at a standstill or at idle or high speed: under these conditions the engine warms up much more slowly, increasing electrical consumption and emissions. It is therefore advisable to move off immediately, slowly, avoiding high speeds.
The towing device should be fastened to the body by specialised personnel according to any additional and/or integrative information supplied by the Manufacturer of the device. The towing device must meet current regulations with reference to 94/20/EC Directive and subsequent amendments. For any version the towing device used must match the towable weight of the car on which it is to be installed. IMPORTANT Supplementary electric loads other than external lights (e.g. electric brake, electric winch, etc.
8-04-2010 10:22 Pagina 140 Assembly diagram fig. 5 REAR AXLE The hook should be fastened to the body avoiding any type of drilling and trimming of the rear bumpers that remains visible when the hook is removed. Existing hole Existing holes Full load The tow-hook structure must be secured at the points indicated with Ø with a total of 2 M8 bolts, 4 M10 bolts and 2 M12 bolts. After fitting, screw holes shall be sealed to prevent exhaust gas inlet.
For the type of tyre to be used, inflation pressures and the specifications of snow tyres, follow the instructions given in paragraph “Wheels” in section “Technical specifications”. The winter features of these tyres are reduced considerably when the tread depth is below 4 mm. In this case, they should be replaced. All four tyres should be the same (brand and track) to ensure greater safety when driving and braking and better driveability.
8-04-2010 IMPORTANT Snow chains may not be used on tyres type 225/40 R18 92V since interference can be generated with the surrounding components.
FRONT PASSENGER AIR BAG/ SIDE BAGS DEACTIVATED ....................................................... SEAT BELTS NOT FASTENED.......................................... LOW BATTERY CHARGE ................................................. LOW ENGINE OIL PRESSURE.......................................... EXHAUSTED OIL ................................................................ 145 146 146 146 146 “DUALDRIVE” ELECTRIC POWER STEERING FAILURE..............................................................
DASHBOARD AND CONTROLS 143-156 BRAVO GB:141-154 BRAVO GB 4-04-2011 WARNING LIGHTS AND MESSAGES SAFETY DEVICES CORRECT USE OF THE CAR WARNING LIGHTS AND MESSAGES IN AN EMERGENCY INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE Pagina 144 x LOW BRAKE FLUID LEVEL (red) HANDBRAKE ON (red) GENERAL WARNINGS 144 14:00 Turning on of warning light and/or symbol is accompanied by specific message and/or by buzzer sound where provided by instrument panel.
The display will show the dedicated message. WARNING If when turning the ignition key to MAR, the warning light ¬ does not turn on or stays on when travelling there could be a failure in safety systems; in this event air bags or pretensioners could not trigger in case of impact or, in a minor number of cases, they could trigger accidentally. Contact Fiat Dealership immediately to have the system checked.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 143-156 BRAVO GB:141-154 BRAVO GB 146 < 4-04-2011 SEAT BELTS NOT FASTENED (red) 14:01 Pagina 146 v Light stays on: LOW ENGINE OIL PRESSURE (red) The warning light comes on constantly with the vehicle stationary if the driver’s seat belt is not properly fastened.
– repeated interruption of the regeneration process, signalled by the DPF warning light coming on. WARNING Exhausted engine oil should be replaced as soon as possible after the warning light comes on, never more than 500 km after the warning light first comes on. Failure to change the oil within the first 500 km may result in severe damage to the engine and will result in forfeiture of the warranty.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 143-156 BRAVO GB:141-154 BRAVO GB 148 ç 4-04-2011 ENGINE COOLANT HIGH TEMPERATURE (red) Turning the ignition key to MAR the warning light turns on, but it should go off after few seconds. The warning light turns on when the engine is overheated.
Start&Stop fault (for versions/markets where provided) (versions with multifunction display) The warning light comes on when a Start&Stop failure is detected. A specific message is displayed on certain versions. Twilight sensor failure The warning light (or the symbol on display) turns on when a fault is detected to the twilight sensor. The display will show the dedicated message.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 143-156 BRAVO GB:141-154 BRAVO GB 150 4-04-2011 WARNING Always drive at a speed appropriate to the traffic conditions, the weather and speed limits. The engine may be turned off while the DPF light is on; however, repeated interruption of the regeneration process may result in premature exhaustion of engine oil.
On certain versions the dedicated message is displayed. Warning light flashing when driving indicates that the ESP system is active. á * HILL HOLDER FAILURE (amber) The symbol * will turn on when the Hill Holder system is faulty. Contact Fiat Dealership as soon as possible. On certain versions warning light á turns on as an alternative. The display will show the dedicated message.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 143-156 BRAVO GB:141-154 BRAVO GB 152 > 4-04-2011 ABS SYSTEM FAILURE (amber) Turning the ignition key to MAR the warning light turns on, but it should go off after few seconds. The warning light turns on when the system is inefficient or unavailable.
TYRE PRESSURE UNSUITABLE FOR SPEED (amber) (for versions/markets, where provided) Turning the ignition key to MAR the warning light (for versions/markets, where provided) will turn on, but it should go off after a few seconds. In this way, the TPMS system notifies the driver by indicating that the tyre/s is dangerously deflated and is therefore probably punctured. IMPORTANT Stop immediately with one or more tyres flat, avoid braking sharply and abrupt turns.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 143-156 BRAVO GB:141-154 BRAVO GB 154 4-04-2011 14:01 Pagina 154 Check tyre pressure Tyre pressure unsuitable for speed The warning light (or the symbol on the display) turns on to indicate that the tyre pressure is below the recommended value which ensures the long life of the tyre and optimum fuel consumption, and/or to indicate a slow pressu
❒ side/taillights The failure could be due to: blown bulb, blown protection fuse or electric connection cut-off. ❒ brake lights or relevant fuse (see what described for symbol T). ❒ rear fog lights On certain versions warning light W turns on as an alternative. ❒ direction indicators ❒ number plate lights. The failure referring to these lights could be: one or more blown bulbs, a blown protection fuse or an electric connection cut-off. The display will show the dedicated message.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 143-156 BRAVO GB:141-154 BRAVO GB 156 3 4-04-2011 SIDE/TAILLIGHTS AND LOW BEAMS (green) FOLLOW ME HOME Side/taillights and low beams The warning light turns on when side/taillights, parking lights or low beams are turned on.
Pagina 157 DASHBOARD AND CONTROLS IN AN EMERGENCY 158 IF A TYRE IS PUNCTURED ............................................... 159 QUICK TYRE REPAIR KIT FIX & GO automatic ......... 165 WHEN NEEDING TO CHANGE A BULB ................... 169 IF AN EXTERIOR LIGHT BURNS OUT.......................... 172 IF AN INTERIOR LIGHT BURNS OUT .......................... 177 IF A FUSE BLOWS................................................................ 180 IF THE BATTERY IS FLAT ............................
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 157-192 BRAVO GB.qxd 158 4-04-2011 11:55 Pagina 158 ENGINE STARTING EMERGENCY START-UP If the instrument panel warning light Y turns on glowing steadily, contact immediately Fiat Dealership.
GENERAL INSTRUCTIONS As an alternative to the Fix&Go kit, the car can be provided (upon request) with space-saver spare wheel or standard size spare wheel; wheel changing and correct use of the jack and space-saver spare wheel call for some precautions as listed below. SAFETY DEVICES WARNING The space-saver spare wheel (for versions/markets, where provided) is specific to your car, do not use it on other models, or use the spare wheel of other models on your car.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 157-192 BRAVO GB.qxd 160 4-04-2011 11:55 Pagina 160 WARNING When driving with a spacesaver spare wheel fitted, the driving performance of the car changes. Avoid accelerating or braking sharply, abrupt turns or fast cornerings. The life of the spare wheel is approx. 3000 Km, after this distance it should be replaced with another of the same type.
Pagina 161 DASHBOARD AND CONTROLS 11:55 B ❒ use the handle A-fig. 2 to remove the piece of stiff cover B; loosen the clamping device E-fig. 3; Please note: ❒ the jack weight is 1,76 kg; ❒ the jack requires no adjustment; ❒ for versions with Fix&Go automatic or take the tool kid from the luggage compartment; ❒ the jack cannot be repaired: if it breaks it must be replaced with a new genuine jack; ❒ no tool other than its cranking device may be fitted on the jack. F0Q0393m fig.
4-04-2011 11:55 Pagina 162 INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 157-192 BRAVO GB.qxd 162 fig. 5 F0Q0394m ❒ using the wrench provided L-fig. 5 loosen the fastening bolts by about one turn; if the car is fitted with alloy rims, shake the car to facilitate removing this rim from the wheel hub; ❒ work the jack crank M-fig.
fig. 7 F0Q0396m ❒ install the space-saver spare wheel matching the holes S-fig. 7 with the corresponding pins T; fig. 8 F0Q0397m REFITTING THE STANDARD WHEEL ❒ using the wrench provided, fully tighten the four fastening bolts; Following the procedure described previously, raise the car and remove the spare wheel. ❒ work the jack handle R-fig.
157-192 BRAVO GB.qxd 4-04-2011 11:55 Pagina 164 DASHBOARD AND CONTROLS When you have finished ❒ Stow the space-saver spare wheel G-fig. 10 in the space provided in the boot; INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES ❒ Insert the partially open jack into the container F and force it slightly into its seat so that it does not vibrate when the car is moving; 164 fig.
Pagina 165 DASHBOARD AND CONTROLS QUICK TYRE REPAIR KIT FIX & GO automatic The quick tyre repair kit includes fig. 11: – filler hose B – sticker C with caution “max. 80 km/h”, to be affixed in a visible position for the driver (instrument panel) after repairing the tyre ❒ instruction brochure (see fig.
4-04-2011 11:55 Pagina 166 IT SHOULD BE NOTICED THAT: The sealing fluid of the quick tyre repair kit is effective with external temperatures between –20 °C and +50 °C. WARNING The compressor shall not be operated for more than 20 minutes. Risk of overheating! Tyres repaired with the quick tyre repair kit shall be used temporarily only.
4-04-2011 11:55 Pagina 167 ❒ If after 5 minutes it is still impossible to reach at least 1.5 bar, disengage compressor from valve and current outlet, then move the car forth for approx. ten metres in order to distribute the sealing fluid inside the tyre evenly, then repeat the inflation operation; ❒ If after this operation it is still impossible after 5 minutes to reach at least 1.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 157-192 BRAVO GB.qxd 168 4-04-2011 11:55 Pagina 168 WARNING If the pressure falls below 1.8 bars, do not drive any further: the quick tyre repair kit Fix & Go automatic cannot guarantee proper hold because the tyre is too much damaged. Contact Fiat Dealership. fig. 16 ❒ if at least 1.
❒ Before changing a bulb check the contacts for oxidation; ❒ Burnt bulbs must be replaced by others of the same type and power; ❒ Always check the height of the headlight beam after changing a bulb. WARNING Modifications or repairs to the electrical system (electronic control units) carried out incorrectly and without bearing the features of the system in mind can cause malfunctions with the risk of fire.
4-04-2011 11:55 Pagina 170 TYPES OF BULBS fig. 18 Various types of bulbs are fitted to your car: A All glass bulbs: these are pressed on. Pull to remove. B Bayonet type bulbs: press the bulb, turn counterclockwise to remove this type of bulb from its holder. C Tubular bulbs: free them from their contacts to remove. D-E Halogen bulbs: to remove the bulb, release the clip holding the bulb in place. F Gas-discharge bulbs (Bi-Xenon).
Power Main beam headlights E H1 55W Longlife dipped beam headlights D H1 55W Gas-discharge low beam headlights (for versions/markets, where provided) F D2R 35W Front sidelights longlife A W5W 5W Front fog lights (for versions/markets, where provided) E H11 55W Front direction indicators B PY24W 24W Side direction indicators A WY5W 5W Rear direction indicators B R10W 10W Taillights/rear fog lights B P5/21W 5W/21W Rear/stop positions B P5/21W 5W/21W Third brake light (
4-04-2011 11:55 Pagina 172 IF AN EXTERIOR LIGHT BURNS OUT For the type of bulb and power rating, see “When needing to change a bulb”. FRONT LIGHT UNITS fig. 19 The front light units contain the side/ taillights, dipped beam, main beam and direction indicator bulbs. fig.
4-04-2011 11:55 Pagina 173 fig. 23 F0Q0708m SIDELIGHTS MAIN BEAM HEADLIGHTS DIRECTION INDICATORS To change the bulb, proceed as follows: To change the bulb, proceed as follows: Front ❒ remove the protective cover A-fig. 19; ❒ remove the protective cover A-fig. 19; To change the bulb, proceed as follows: ❒ turn the bulb holder A-fig. 21 counterclockwise and then withdraw it; ❒ release the bulb holder catch A-fig. 22; ❒ turn the protective cover C-fig.
4-04-2011 11:55 Pagina 174 INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 157-192 BRAVO GB.qxd 174 fig. 24 F0Q0709m Side To change the bulb, proceed as follows: ❒ push the transparent cover A-fig.
4-04-2011 11:55 Pagina 175 F0Q0713m fig. 30 F0Q0711m fig. 31 F0Q0712m REVERSING LIGHTS fig. 30 fig. 28 F0Q0739m WARNING LIGHTS AND MESSAGES Contact Fiat Dealership to have reversing light bulbs replaced. To change the bulb proceed as follows: REAR FOG LIGHTS fig. 31 ❒ open the tailgate then, slacken the two fastening screws A-fig. 27; Contact Fiat Dealership to have rear fog light bulbs replaced. ❒ remove the light unit with both hands as shown by the arrows in fig.
4-04-2011 11:55 Pagina 176 CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 157-192 BRAVO GB.qxd fig. 33 fig. 34 F0Q0718m fig. 35 F0Q0719m ❒ press the tabs C-fig. 33 and remove the bulb holder; WARNING LIGHTS AND MESSAGES IN AN EMERGENCY TECHNICAL CAR SPECIFICATIONS MAINTENANCE F0Q0751m ❒ remove the snap-fitted bulb and replace it. ❒ refit cover A-fig. 32 and then close the tailgate. fig.
Pagina 177 DASHBOARD AND CONTROLS IF AN INTERIOR LIGHT BURNS OUT FRONT CEILING LIGHT To replace the bulbs proceed as follows: ❒ work in the points shown by the arrows and remove light A-fig. 36; fig. 36 F0Q0720m fig. 38 F0Q0723m fig. 37 F0Q0721m fig. 39 F0Q0722m WARNING LIGHTS AND MESSAGES ❒ open the protection lid B-fig. 37; ❒ replace bulbs C releasing them from the side contacts; make sure that new bulbs are correctly clamped between contacts; ❒ re-close the lid B-fig.
4-04-2011 11:56 Pagina 178 fig. 40 F0Q0741m IN AN EMERGENCY INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE 178 fig. 42 F0Q0724m BOOT LIGHT To change the bulb, proceed as follows: WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 157-192 BRAVO GB.qxd ❒ open the tailgate; ❒ remove the light unit A-fig. 42 levering in the point shown by the arrow; ❒ open the protection cover B-fig. 43 and replace the snap-fitted bulb; fig.
4-04-2011 11:56 Pagina 179 COURTESY MIRROR LIGHT (for versions/markets, where provided) ❒ open the glovebox, then remove the light unit A-fig. 44; To change the bulb, proceed as follows: ❒ replace the bulb B releasing it from the side contacts making sure that the new bulb is correctly clamped between the contacts. ❒ remove the bulb B levering in the points shown by the arrows; ❒ open the mirror cover A-fig. 45; fig. 46 F0Q0424m ❒ replace the bulb C-fig.
4-04-2011 11:56 Pagina 180 IF A FUSE BLOWS SAFETY DEVICES When a device does not work, check the efficiency of its fuse: the conductor element A-fig. 47 must be intact. If not, replace the fuse with one of the same amp rating (same colour). INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES The fuse is a protective device for the electric system: it comes into action (i.e. it cuts off) mainly due to a fault or improper action on the system.
DASHBOARD AND CONTROLS Pagina 181 FUSE LOCATION The vehicle fuses are grouped in three control units: SAFETY DEVICES ❒ instrument dashboard fuse control unit; fig. 48 F0Q0727m Fuse box on the dashboard fig. 48 (left hand drive versions) To gain access to the fuses in the fuse box on the dashboard fig. 49, loosen the three fastening screw A-fig. 48 and remove the cover B. fig. 48 F0Q0098m Fuse box on the dashboard fig.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 157-192 BRAVO GB.qxd fig. 48a 182 4-04-2011 11:56 Pagina 182 F0Q0061m fig.
11:56 Pagina 183 Fuse box next to the battery fig. 51a (for versions/markets, where provided) fig. 50 F0Q0816m fig. 50a CORRECT USE OF THE CAR To gain access to the fuse box next to the battery, press the retainers A-fig. 50a and remove the protection cover B. DASHBOARD AND CONTROLS 4-04-2011 SAFETY DEVICES 157-192 BRAVO GB.qxd F0Q0498m WARNING LIGHTS AND MESSAGES Fuse box next to the battery fig.
4-04-2011 11:56 Pagina 184 Fuse box in the boot fig. 52 (for versions/markets, where provided) To gain access to the fuses in the fuse box on the left side of the boot, open lid A-fig. 53. fig. 52 F0Q0747m fig. 53 F0Q0776m INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 157-192 BRAVO GB.qxd 184 fig.
AMPERE FIGURE Right dipped beam (quartz-iodine headlights) F12 7.5 49 Right dipped beam (Bi-Xenon headlights) F12 15 49 Left dipped beam (quartz-iodine headlights) F13 7.5 49 Left dipped beam (Bi-Xenon headlights) F13 15 49 Reversing light F35 7.5 49 Third stop light F37 7.5 49 Rear fog light (driver’s side) F53 7.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 157-192 BRAVO GB.qxd 186 4-04-2011 11:56 Pagina 186 COMPONENTS FUSE AMPERE FIGURE Climate control fan F08 40 51 Headlight washer pump F09 30 51 Horn F10 10 51/51a Headlight alignment correction system (versions with halogen headlights) F13 7.5 49 (PTC1) additional heater F15 30 51 Conditioner compressor F19 7.
AMPERE FIGURE F36 20 49 Brake pedal control (normally closed contact NA)/ Instrument panel (NQS)/gas-discharge lamp control units on front headlights F37 7.5 49 Car radio and Radio navigator (excluding 1.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 157-192 BRAVO GB.
Charge the battery as follows: ❒ proceed as follows: detach the connector A (by pressing button B) from sensor C for monitoring the status of the battery installed on the battery negative pole D; Charging should be slow at a low amp rating for 24 hours. Charging for a longer time may damage the battery.
4-04-2011 11:56 Pagina 190 WARNING The liquid contained in the battery is poisonous and corrosive. Avoid contact with the skin or eyes. The battery should be charged in a well ventilated place, away from naked flames or possible sources of sparks: danger of explosion and fire. INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 157-192 BRAVO GB.
Proceed as follows: ❒ release the cap operating the tab A-fig. 56-57; B fig. 56 F0Q0730m ❒ take the tow hook B from its support; ❒ tighten the ring on the rear or front threaded pin. fig. 57 F0Q0731m SAFETY DEVICES TOW RING HOOKING CORRECT USE OF THE CAR The tow ring provided with the car is housed in the tool box under the boot mat. WARNING Before starting to tow, turn the ignition key to MAR and then to STOP. Do not remove the key.
4-04-2011 11:56 Pagina 192 WARNING Do not start the engine when towing the car. INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 157-192 BRAVO GB.qxd 192 WARNING Before fitting the hook, clean accurately its threaded seat. Before starting to tow, make sure to have tighten the hook. The front and rear tow hooks must only be used for emergency situations on the road.
SERVICE SCHEDULE ........................................................... 195 ROUTINE MAINTENANCE ............................................. 199 HEAVY-DUTY ...................................................................... 199 CHECKING FLUID LEVELS................................................ 200 AIR CLEANER/POLLEN FILTER ...................................... 207 BATTERY ................................................................................ 207 WHEELS AND TYRES ..........
INDEX CAR TECHNICAL SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 193-216 BRAVO GB:191-212 BRAVO GB 194 16-03-2011 SCHEDULED SERVICING Correct maintenance is essential for ensuring long car life under the best conditions. This is why Fiat has programmed a series of checks and maintenance operations every 30,000 km or 35,000 km (1.6 Multijet and 2.0 Multijet versions).
18 36 54 72 90 108 Thousands of km 30 24 60 48 90 72 120 96 150 120 180 144 ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● Months Check tyre conditions/wear and adjust pressure if necessary Check lighting system operation (headlights, direction indicators, hazard lights, luggage compartment lights, passenger compartment lights, glove compartment lights, instrument panel warning lig
INDEX CAR TECHNICAL SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 193-216 BRAVO GB:191-212 BRAVO GB 196 16-03-2011 14:45 Pagina 196 Thousands of miles 18 36 54 72 90 108 Thousands of km 30 24 60 48 90 72 120 96 150 120 180 144 ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● Months Check exhaust emissions (pet
42 63 84 105 Thousands of km 35 70 105 140 175 Months 24 48 72 96 120 Check tyre conditions/wear and adjust pressure if necessary Check lighting system operation (headlights, direction indicators, hazard lights, luggage compartment lights, passenger compartment lights, glove compartment lights, instrument panel warning lights, etc.
INDEX CAR TECHNICAL SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 193-216 BRAVO GB:191-212 BRAVO GB 198 16-03-2011 14:45 Pagina 198 Thousands of miles 21 42 63 84 105 Thousands of km 35 70 105 140 175 Months 24 48 72 96 120 ● ● ● ● ● ● ● ● ● ● Check emissions/fumes Check operation of engine control systems (by means of test interface) Replace accessory drive belt/s Replace toothed ti
❒ windscreen washer fluid level; ❒ tyre pressure and conditions; ❒ light system operation (headlights, direction indicators, hazard lights, etc.); ❒ windscreen wiper/washer operation and windscreen/rear window blade position/wear; Every 3,000 km check and top up if required: engine oil level.
16-03-2011 14:45 Pagina 200 CHECKING FLUID LEVELS When topping up take care not to confuse the various types of fluids: they are all incompatible with one another and could seriously damage the car. WARNING Never smoke while working in the engine compartment; gas and inflammable vapours may be present, with the risk of fire. fig. 1 - 1.
16-03-2011 14:45 Pagina 201 1 Engine oil - 2 Battery - 3 Brake fluid 4 Windscreen/rear window/headlight washer fluid - 5 Engine coolant F0Q0763m CAR TECHNICAL SPECIFICATIONS MAINTENANCE IN AN EMERGENCY fig. 2a - 1.4 Turbo Multi Air version WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 193-216 BRAVO GB:191-212 BRAVO GB INDEX 1 Engine oil - 2 Battery - 3 Brake fluid 4 Windscreen/rear window/headlight washer fluid - 5 Engine coolant fig. 3 - 1.
16-03-2011 14:46 Pagina 202 1 5 2 INDEX CAR TECHNICAL SPECIFICATIONS MAINTENANCE 1 Engine oil - 2 Battery - 3 Brake fluid 4 Windscreen/rear window/headlight washer fluid - 5 Engine coolant 3 4 fig. 5 - 1.9 Multijet 16V version (for versions/markets where provided) 202 F0Q0615m fig. 4 - 1.
16-03-2011 14:46 Pagina 203 IN AN EMERGENCY F0Q0768m CAR TECHNICAL SPECIFICATIONS MAINTENANCE fig. 5a - 2.
16-03-2011 14:46 Pagina 204 DASHBOARD AND CONTROLS 193-216 BRAVO GB:191-212 BRAVO GB B fig. 6 - 1.4 16V version F0Q0665m fig. 7a - 1.4 Turbo Multi Air version F0Q0764m Oil level shall never exceed the MAX mark. IN AN EMERGENCY INDEX CAR TECHNICAL SPECIFICATIONS MAINTENANCE F0Q0621m If the oil level is near or even below the MIN mark, add oil through the filler neck B, until reaching the MAX mark. fig. 7 - 1.4 T-JET version 204 fig. 10 - 1.
14:46 Pagina 205 DASHBOARD AND CONTROLS 16-03-2011 Engine oil consumption Max engine oil consumption is usually 400 grams every 1000 km. WARNING When the engine is hot, take care when working inside the engine compartment to avoid burns. Remember that when the engine is hot, the fan may cut in: danger of injury. Scarves, ties and other loose clothing might be pulled by moving parts. Used engine oil and filter contain harmful substances for the environment.
193-216 BRAVO GB:191-212 BRAVO GB 16-03-2011 14:46 Pagina 206 DASHBOARD AND CONTROLS Check level through the reservoir. INDEX CAR TECHNICAL SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES For versions fitted with headlight washer, remove the filter and the relevant dipstick. Use the dipstick to check the fluid level inside the reservoir. 206 fig. 13 F0Q0666m WINDSCREEN/REAR WINDOW/HEADLIGHT WASHER FLUID fig.
WARNING Symbol π, on the container indicates synthetic brake fluid, distinguishing it from the mineral kind. Using mineral fluids irreversibly damages the special braking system rubber seals. BATTERY The battery is of the “Limited maintenance” type: under normal conditions of use the electrolyte does not need topping up with distilled water. However, to make sure that it is in efficient conditions at routine intervals have it checked at Fiat Dealership only.
INDEX CAR TECHNICAL SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 193-216 BRAVO GB:191-212 BRAVO GB 208 16-03-2011 Batteries contain substances that are very harmful for the environment. You are advised to have the battery changed at a Fiat Dealership, which is properly equipped for disposing of used batteries respecting nature and the law.
Incorrect pressure causes abnormal tyre wear fig. 15: A: normal pressure: tread evenly worn. B: low pressure: tread particularly worn at the edges. C: high pressure: tread particularly worn in the centre. Tyres must be replaced when the tread wears down to 1.6 mm. In any case, comply with the laws in the country where the car is being driven. fig. 15 F0Q0101m IMPORTANT NOTES ❒ As far as possible, avoid sharp braking and screech starts, etc.
16-03-2011 WARNING Remember that road holding depends also on the correct tyre inflating pressure. INDEX CAR TECHNICAL SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 193-216 BRAVO GB:191-212 BRAVO GB 210 WARNING If the pressure is too low the tyre overheats and this can cause it serious damage.
16-03-2011 14:46 Pagina 211 Changing the rear window blade Proceed as follows: ❒ raise the cover A-fig. 17 and remove the arm from the car, slackening the nut B that fastens it to the pivot pin; ❒ fit the new arm, positioning it correctly, and fully tighten the nut; fig. 17 F0Q0663m ❒ lower the cover. fig. 19 F0Q0660m SPRAY NOZZLES Windscreen wiper fig. 18 If the jet of fluid is inadequate, firstly check that there is fluid in the reservoir: see “Checking fluid levels” in this section).
DASHBOARD AND CONTROLS BODYWORK SAFETY DEVICES 16-03-2011 The main causes of corrosion are the following: CORRECT USE OF THE CAR 193-216 BRAVO GB:191-212 BRAVO GB ❒ salty air and humidity (coastal areas, or hot humid climates); PROTECTION FROM ATMOSPHERIC AGENTS ❒ Painting products and systems which give the car particular resistance to corrosion and abrasion; ❒ atmospheric pollution; WARNING LIGHTS AND MESSAGES IN AN EMERGENCY ❒ seasonal environment conditions.
– remove the antenna from the roof to avoid damages; ❒ pass on the body a sponge with a light cleansing solution, frequently rinsing the sponge; – water with a cleansing solution must be used for washing; – rinse accurately to avoid cleansing solution residues which may remain on the body or hidden parts. Do not wash the car after it has been left in the sun or with the bonnet hot: this may alter the shine of the paintwork. ❒ rinse accurately with water and dry with air jet or suede.
INDEX CAR TECHNICAL SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 193-216 BRAVO GB:191-212 BRAVO GB 214 16-03-2011 14:46 Pagina 214 Front headlights Windows Engine compartment IMPORTANT Never use aromatic substances (e.g.: petrol) or ketones (e.g.: acetone) for cleaning front headlight plastic lens. Use specific window cleaner product.
For routine cleaning of interior plastic parts use a soft cloth moistened with water and neutral soap. Remove grease or persisting stains using appropriate solventfree products designed to preserve appearance and colour of plastic components. Remove liquid or grease stains with a dry absorbent cloth without rubbing. Then wipe with a soft cloth or chamois leather with water and neutral soap. If the stain persists, use specific products, carefully following the instructions for use.
INDEX CAR TECHNICAL SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 193-216 BRAVO GB:191-212 BRAVO GB 216 16-03-2011 REAL LEATHER TRIMMED STEERING WHEEL/ GEAR LEVER/HAND BRAKE These components shall only be cleaned with water and neutral soap. Never use spirit or alcohol-based products.
ENGINE CODES - BODYWORK VERSIONS .............. 220 ENGINE .................................................................................. 222 FUEL FEED/IGNITION ....................................................... 225 TRANSMISSION .................................................................. 225 BRAKES ................................................................................... 226 SUSPENSIONS....................................................................... 226 STEERING.
SAFETY DEVICES DASHBOARD AND CONTROLS 217-248 BRAVO GB.qxd:213-236 BRAVO GB 11-04-2011 12:03 Pagina 218 IDENTIFICATION DATA You are advised to note the identification codes. The identification data stamped and given on the plates and their position are the following fig. 1: ❒ Model plate ❒ Bodywork paint identification plate F0Q0736m fig. 2 F0Q0029m G Maximum vehicle weight on front axle.
11-04-2011 12:03 Pagina 219 ENGINE MARKING It can be reached by sliding forth the lid A-fig. 3. BODYWORK PAINT IDENTIFICATION PLATE fig. 4 The plate is applied inside the bonnet and it bears the following data: A - Paint manufacturer. It bears the following data: B - Colour name. ❒ car model (ZFA 198000); C - Fiat colour code. ❒ chassis number. D - Respray and touch up code. WARNING LIGHTS AND MESSAGES It is printed on the passenger compartment floor, near the right-hand front seat.
12:03 Pagina 220 ENGINE CODES - BODYWORK VERSIONS Engine code Bodywork version 1.4 16V 192B2000 198AXA1B 00E ( ) 1.4 T-JET 120HP 198A4000 198AXGIB 06G ( ) 198AXGIB 06H (▲) ( ) 1.4 T-JET 150HP 198A1000 198AXF1B 05E 198AXF1B 05F (▲) 1.4 Turbo Multi Air 198A7000 198AXSIB 15 ( ) 198AXSIB 15B (▲) ( ) 1.6 Multijet 90HP ( ) 198A6000 198AXM1B 09 (*) 198AXM1B 09B (*) (▲) 1.
192A8000 198AXB1A 01 ( ) 198AXB1A 01C ( ) 198AXB1A 01B ( ) (▲) 198AXB1A 01D ( ) (▲) 1.9 Multijet 16V ( ) 937A5000 198AXC1B 02 ( ) 198AXC1B 02C ( ) 198AXC1B 02B ( ) (▲) 198AXC1B 02D ( ) (▲) 1.9 Multijet 8V ( ) 192B4000 198AXD1A 03 ( ) 198AXD1A 03C ( ) 198AXD1A 03B ( ) (▲) 198AXD1A 03D ( ) (▲) 1.9 Multijet 8V ( ) 192B5000 198AXE1A 04 ( ) 198AXE1A 04C ( ) 198AXE1A 04B ( ) (▲) 198AXE1A 04D ( ) (▲) 2.
Pagina 222 ENGINE GENERAL 1.4 16V 1.4 T-JET 120 HP 1.4 T-JET 150 HP 1.4 Turbo Multi Air Engine code 192B2000 198A4000 198A1000 198A7000 Otto Otto Otto Otto Number and layout of cylinders 4 in line 4 in line 4 in line 4 in line INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES DASHBOARD AND CONTROLS 12:03 SAFETY DEVICES 11-04-2011 CORRECT USE OF THE CAR 217-248 BRAVO GB.qxd:213-236 BRAVO GB 222 Cycle Piston bore and stroke mm 72.
1.6 Multijet 120 HP 1.9 Multijet 8V (*) Engine code 198A6000 198A3000 198A2000 192A8000 Diesel Diesel Diesel Diesel 4 in line 4 in line 4 in line 4 in line Cycle Number and layout of cylinders Piston bore and stroke mm 79.5 x 80.5 79.5 x 80.5 79.5 x 80.5 82.0 x 90.4 Total displacement cm3 1598 1598 1598 1910 16.5 16.5 16.5 18 kW HP rpm 66 90 4000 77 105 4000 88 120 4000 88 120 4000 Nm kgm rpm 290 29.5 1500 290 29.5 1500 300 30.
SAFETY DEVICES Number and layout of cylinders INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES Engine code 224 11-04-2011 GENERAL CORRECT USE OF THE CAR DASHBOARD AND CONTROLS 217-248 BRAVO GB.qxd:213-236 BRAVO GB Cycle 12:03 Pagina 224 1.9 Multijet 16V (*) 1.9 Multijet 8V (●)(*) 1.9 Multijet 8V (●)(*) 2.0 Multijet 2.
Pagina 225 FUEL FEED/IGNITION 1.6 Multijet - 1.9 Multijet 8V 1.9 Multijet 16V - 2.0 Multijet Multipoint sequential phased electronic injection returnless system Multipoint sequential phased electronic injection with turbosupercharger and intercooler Direct injection with electronically controlled Multijet “Common Rail” turbosupercharger and intercooler 1.4 16V - 1.4 T-JET - 1.4 Turbo Multi Air - 1.6 Multijet 1.9 Multijet 16V - 2.0 Multijet 1.
DASHBOARD AND CONTROLS Service brakes: INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR BRAKES SAFETY DEVICES 217-248 BRAVO GB.qxd:213-236 BRAVO GB 12:03 Pagina 226 1.4 16V - 1.4 T-JET - 1.4 Turbo Multi Air - 1.6 Multijet 1.9 Multijet 8V - 1.9 Multijet 16V - 2.
Pressed steel or alloy rims. Tubeless tyres with radial carcass. The homologated tyres are listed in the Log book. IMPORTANT In the event of discrepancies between the information provided on this “Owner handbook” and the “Log book”, consider the specifications shown in the log book only. Attaining to the prescribed size, to ensure safety of the car in movement, it must be fitted with tyres of the same make and type on all wheels. IMPORTANT Do not use inner tubes with Tubeless tyres.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 217-248 BRAVO GB.qxd:213-236 BRAVO GB 228 11-04-2011 12:03 Pagina 228 Q = up to 160 km/h. UNDERSTANDING RIM MARKING fig. 5 R = up to 170 km/h. Example: 6J x 15 H2 ET 31.5 S = up to 180 km/h. 6 = rim width in inches (1). T = up to 190 km/h. J U = up to 200 km/h.
6J x 15 ET 31.5 195/65 R15 91H 195/65 R15 91T (M+S) 7J x 16 ET 31 205/55 R16 91H 205/55 R16 91T (M+S) 7J x 17 ET 31 225/45 R17 91W 225/45 R17 91T (M+S) 6J x 15 ET 31.
Size INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR 1.4 16V 230 11-04-2011 12:03 Pagina 230 COLD TYRE INFLATION PRESSURE (bar) SAFETY DEVICES DASHBOARD AND CONTROLS 217-248 BRAVO GB.qxd:213-236 BRAVO GB 1.4 T-JET 120 HP 1.4 Turbo Multi Air 1.6 Multijet 1.9 Multijet 8V 1.4 T-JET 150HP 1.9 Multijet 16V 2.0 Multijet STANDARD TYRES Medium load Full load Front Rear Front Rear 195/65 R15 91H 2.3 2.3 2.6 2.
217-248 BRAVO GB.qxd:213-236 BRAVO GB 11-04-2011 12:03 Pagina 231 DASHBOARD AND CONTROLS DIMENSIONS Dimensions are expressed in mm and refer to the car fitted with standard tyres. SAFETY DEVICES The height refers to the car unladen. WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR BOOT VOLUME Unladen boot volume (V.D.A. standards) ...................... 400 dm3 with Cargo Box (for versions/markets, where provided) located in the luggage compartment.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 217-248 BRAVO GB.qxd:213-236 BRAVO GB 232 11-04-2011 12:03 Pagina 232 PERFORMANCE Top admitted speed after initial car use in km/h. 1.4 16V 1.4 T-JET 120 HP 1.4 T-JET 150 HP 1.4 Turbo Multi Air 1.6 Multijet 90 HP (*) 1.6 Multijet 105 HP 1.6 Multijet 120 HP 179 197 212 204 173 187 195 (*) Versions for specific markets 1.
WEIGHTS SAFETY DEVICES 2.
TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 217-248 BRAVO GB.qxd:213-236 BRAVO GB 11-04-2011 12:03 Pagina 234 CAPACITIES 1.4 16V 1.4 T-JET 1.4 Turbo Multi Air Recommended fuels and genuine lubricants litres kg litres kg litres kg Fuel tank: including a reserve of: 57 8-10 – – 57 8-10 – – 57 8-10 – – Engine cooling system – with climate control: 5.2 4.6 6.0 5.3 6.0 5.
litres kg litres kg litres kg Fuel tank: including a reserve of: 57 8-10 – – 57 8-10 – – 57 8-10 – – Engine cooling system – with climate control: 7.1 6.3 7.1 6.3 7.1 6.3 Engine sump: Engine sump and filter: 4.3 4.6 3.6 3.9 4.3 4.6 3.6 3.9 4.3 4.9 3.6 4.1 SELENIA WR P.E. Gearbox/differential casing: 1.87 1.6 3.1 2.7 TUTELA CAR TECHNYX TUTELA CAR MATRYX (●) Hydraulic brake circuit with ABS: 0.56 0.525 0.56 0.
DASHBOARD AND CONTROLS SAFETY DEVICES Use Oils for petrol engines Oils for diesel engines INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY FLUIDS AND LUBRICANTS CORRECT USE OF THE CAR 11-04-2011 WARNING LIGHTS AND MESSAGES 217-248 BRAVO GB.
Synthetic-based oil, grade SAE 75W-85 that passes API GL-4 PLUS specifications. Qualification FIAT 9.55550-MX3. TUTELA CAR TECHNYX Contractual Technical Reference N° F010.B05 Mechanic gearboxes and differentials Synthetic-based oil, grade SAE 75W Qualification FIAT 9.55550-MZ6 TUTELA TRANMISSION GEARFORCE Synthetic-based oil, grade SAE 75W-85 that passes API GL-4 specifications. Qualification FIAT 9.55550-MZ1 Contractual Technical Reference N° F002.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 217-248 BRAVO GB.qxd:213-236 BRAVO GB 11-04-2011 FUEL CONSUMPTION The fuel consumption figures given in the table below are determined on the basis of the homologation tests set down by specific European Directives.
12:03 Pagina 239 DASHBOARD AND CONTROLS CO2 EMISSIONS The CO2 emission levels at the exhaust given in the following tables refer to combined consumption. CO2 EMISSIONS ACCORDING TO EUROPEAN DIRECTIVE IN FORCE (g/km) 1.4 16V 1.4 T-JET 120 HP 1.4 T-JET 150 HP 1.4 Turbo Multi Air 1.6 Multijet 90 HP ( ) 1.6 Multijet 105 HP 146 146 155 132 115 125 (**) / 119 (*) 1.9 Multijet 8V 90 HP ( ) 1.9 Multijet 8V 115 HP ( ) 1.9 Multijet 16V 2.
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 217-248 BRAVO GB.
IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 12:04 TECHNICAL CAR SPECIFICATIONS MAINTENANCE 11-04-2011 INDEX 217-248 BRAVO GB.
217-248 BRAVO GB.qxd:213-236 BRAVO GB 11-04-2011 12:04 Pagina 242 PROVISIONS FOR THE PROCESSING OF A VEHICLE AT THE END OF ITS LIFE-CYCLE For years now Fiat has been developing its global commitment towards the safeguarding and protection of the Environment through the continuous improvement of its production processes and the making of increasingly more “eco friendly” products.
217-248 BRAVO GB.qxd:213-236 BRAVO GB 11-04-2011 12:04 Pagina 243 ® In the heart of your engine. ® Always ask your mechanic for Pagine_ITA.
217-248 BRAVO GB.qxd:213-236 BRAVO GB 11-04-2011 12:04 Pagina 244 Oil change? The experts recommend Selenia The engine of your car is factory filled with Selenia. This is an engine oil range which satisfies the most advanced international specifications. Its superior technical characteristics allow Selenia to guarantee the highest performance and protection of your engine.
11:54:19 217-248 BRAVO GB.qxd:213-236 BRAVO GB 11-04-2011 12:04 Pagina 245 DASHBOARD RIGHT HAND DRIVE VERSIONS The presence and the position of the instruments and warning lights may vary according to the versions. F0Q0005m fig. 1 1. Adjustable and swivel air vent - 2. Side window air vent - 3. Front passenger air bag - 4. Adjustable and swivel air vents - 5. Hazard light switch - 6. External light stalk - 7. Instrument panel - 8. Windscreen/rear window wiper/trip computer stalk - 9.
217-248 BRAVO GB.qxd:213-236 BRAVO GB 11-04-2011 12:04 Pagina 246 INSTRUMENT PANEL Versions with multifunction display A Speedometer (speed indicator) B Fuel level gauge with reserve warning light C Engine coolant temperature gauge and excessive temperature warning light D Rev counter E Multifunction display. RIGHT HAND DRIVE VERSIONS m c Warning lights fitted on diesel versions only On diesel versions the rev counter end scale value is 6000 rpm. F0Q0006m fig.
217-248 BRAVO GB.qxd:213-236 BRAVO GB 11-04-2011 12:04 Pagina 247 Versions with reconfigurable multifunction display A Speedometer (speed indicator) B Fuel level gauge with reserve warning light C Engine coolant temperature gauge and excessive temperature warning light D Rev counter m c Warning lights fitted on diesel versions only On diesel versions the rev counter end scale value is 6000 rpm. F0Q0008m fig.
217-248 BRAVO GB.
– Cargo Box....................................... 82 46-49 – replacement.................................... 207 – extending the boot........................ 80 Air filter/Pollen filter ........................... 207 – tips for extending battery life .... 208 – luggage transport warnings.......... 82 Air recirculation ........................ 46-49-53 Body paintwork identification plate 219 – lighting.............................................. 178 Air vents ...................................
INDEX TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 249-260 BRAVO GB.qxd 4-04-2011 12:00 Pagina 250 Car performance ................................. 232 – suitability for using child seats ... 120 – brake fluid (type) ........................... 237 Car radio wiring system..................... 97 Cigarette lighter .................................. 69 – checking levels and topping up ..
windows ................................ 45-48-52 the inside ......................................... 12 Courtesy lights ..................................... 71 Diesel Particulate Filter (DPF) .......... 110 – rear door locking device ............ 76 Dipped beam headlights – remote control ............................. 11 – bulb replacement........................... 179 Cruise Control..................................... 61 – alignment .........................................
4-04-2011 12:00 Pagina 252 Engine compartment Engine oil Fiat CODE system ............................ 8 – checking fluid levels ...................... 200 – checking levels and topping up .. 200 – opening/closing the bonnet ......... 83 – consumption .................................. 205 quick tyre repair kit.......................... 165 – specifications................................... 236 Flashings (main beam headlights) .... 56 Engine starting .....................................
– bulb replacement........................... 174 – switch............................................... 65 – switching on.................................... 65 – system .............................................. 66 Front seats ............................................ 38 – adjusments ...................................... 38 (control units)............... 181-182-183 – general information Fuel reserve warning light ................. 21 Fuel reserve.................................
SAFETY DEVICES DASHBOARD AND CONTROLS 249-260 BRAVO GB.qxd 4-04-2011 12:00 Pagina 254 Hazard warning lights Ignition switch – switching on.................................... 65 Headlight alignment corrector.......... 85 Headlight washers ............................... 61 CORRECT USE OF THE CAR WARNING LIGHTS AND MESSAGES IN AN EMERGENCY TECHNICAL CAR SPECIFICATIONS MAINTENANCE .................................................... 10 In an emergency ............................
– switching on.................................... 56 – body colour plate ......................... 219 – general information ...................... 159 Manual climate control system ........ 47 Parking (sensors) ................................ 104 Mileometer.......................... Parking lights Mirror adjustment...................... 6-7-22-25 Radio transmitters and mobile phones .................................. 98 40-42 – switching on.................................... 56 Rain sensor..
SAFETY DEVICES DASHBOARD AND CONTROLS 249-260 BRAVO GB.qxd 4-04-2011 12:00 Pagina 256 Rear window washer – checking levels and topping up .. 200 – remote door opening/ closing..................................... Saving fuel ............................................. 137 11-12 – tailgate opening ............................. 12 – fluid specifications..........................
Side air bags Starting and driving ............................ 131 Tools ...................................................... 161 – ignition switch ............................... 19 Top speeds ........................................... 232 Steering ................................................. 226 Topping up the engine oil ................. 205 Steering lock and ignition switch ..... 19 Towing the car .................................... 191 Steering wheel .................................
TECHNICAL CAR SPECIFICATIONS MAINTENANCE IN AN EMERGENCY WARNING LIGHTS AND MESSAGES CORRECT USE OF THE CAR SAFETY DEVICES DASHBOARD AND CONTROLS 249-260 BRAVO GB.qxd 4-04-2011 12:00 Pagina 258 – inflation pressure........................... 230 – reading the symbols correctly .... 227 INDEX Washing the car – tyre and wheel types .................... 229 – tyre inflation pressure .................. 230 – Rim Protector ............................... 228 – engine compartment ..................
4-04-2011 12:00 Pagina 259 Windscreen wiper blades – replacement.................................... 211 DASHBOARD AND CONTROLS 249-260 BRAVO GB.qxd Winter – snow chains ................................... 141 – snow tyres............................. 141-229 CORRECT USE OF THE CAR WARNING LIGHTS AND MESSAGES – rain (sensor) ................................... 59 IN AN EMERGENCY – nozzles ............................................
249-260 BRAVO GB.qxd 4-04-2011 12:00 Pagina 260 Fiat Group Automobiles S.p.A. - Parts & Services - Technical Services - Service Engineering Largo Senatore G. Agnelli, 5 - 10040 Volvera - Torino (Italia) Print N. 603.81.
BRAVO UM GB 15-05-2007 8:36 Pagina 1 F I A T B R A V O ENGLISH The data contained in this publication is intended merely as a guide. FIAT reserves the right to modify the models and versions described in this booklet at any time for technical and commercial reasons. If you have any further questions please consult your FIAT dealer. Printed in recycled paper without chlorine.