Full Product Manual

ManualsBrandsFIMCO ManualsBattery Sprayers15 Gal. Economy Lever Handgun Tank Sprayer

Page 1

Model: LG-15-EC (5301302)

(15 Gallon Lawn & Garden Spot Sprayer)

Technical Specifications

 15 Gallon Corrosion-Resistant Polyethylene Tank

 12 Volt Diaphragm Pump, 1.2 GPM - 60 PSI

 Lever Handgun with 15 Ft. Handgun Hose (3/8” I.D.)

 15 Ft. max. vertical throw, 25 Ft. horizontal throw

Assembly Instructions

Your sprayer has been mostly assembled at the factory. The

only requirement will be for you to attach the wand clips and

hook up your battery leads to a fully charged 12 Volt battery.

 After assembly is complete and before testing your

sprayer, make sure you connect the electrical hook-up to

the end of your pump and clip the clips to a fully charged

battery.

 The drain plug assembly should already be attached to

the tank

www.fimcoindustries.com

1000 FIMCO Lane, P.O. Box 1700, North Sioux City, SD 57049

Toll Free Phone: 800-831-0027 : Toll Free Fax: 800-494-0440

[5194785 (03/20)]

OWNER’S MANUAL

BEFORE RETURNING THIS PRODUCT

FOR ANY REASON, PLEASE CALL

1-800-831-0027

MONDAY-FRIDAY, 8:00 AM TO 5:00 PM CST

If you should have a question or experience a problem with

your Fimco Industries Product: Visit our website @

www.fimcoindustries.com or call the Toll free number above. Our

technical support representatives will be happy to help you.

In most cases a customer service rep. can resolve

the problem over the phone.

To obtain prompt, efficient service, always remember to give the

following information....

• Correct Part Description and/or part number

• Model number and Serial Number

Part descriptions and numbers can be obtained from the

illustrated parts list section(s) of this manual.

General Information

Thank you for purchasing this product. The purpose of this

manual is to assist you in operating and maintaining your lawn

& garden Spot sprayer.

Retain a copy of your receipt for your

unit, as it will be required to validate

any warranty service.

Warranted against manufacturer or

workmanship defects from date of

purchase with copy of receipt:

Homeowner Usage: Sprayer-One Year and Pump-Two Years.

Commercial Usage: Sprayer and Pump-90 Days.

Summary of content (6 pages)

PAGE 1
OWNER’S MANUAL Model: LG-15-EC (5301302) (15 Gallon Lawn & Garden Spot Sprayer) General Information Thank you for purchasing this product. The purpose of this manual is to assist you in operating and maintaining your lawn & garden Spot sprayer. Technical Specifications     BEFORE RETURNING THIS PRODUCT FOR ANY REASON, PLEASE CALL 1-800-831-0027 15 Gallon Corrosion-Resistant Polyethylene Tank 12 Volt Diaphragm Pump, 1.2 GPM - 60 PSI Lever Handgun with 15 Ft. Handgun Hose (3/8” I.D.) 15 Ft. max.
PAGE 2
IMPORTANT: Remove tank lid and be sure the tank is clean and free of any foreign material. Rinse tank out of any tank residue before filling with water to test. Testing the Sprayer NOTE: It is important that you test your sprayer for leakage and proper spray patters with plain water before chemical application is attempted. This will also give you the opportunity to familiarize yourself with the operation of the sprayer. Conditions of weather and terrain must be considered when setting the sprayer.
PAGE 3
Pump Model: 5281370 1.2 GPM - 60 PSI Available Replacement Parts Replacement Pump: 5151086 DO  Clean and rinse your pump after each use with Fimco Tank Neutralizer  Winterize your pump or sprayer by rinsing, draining and running RV Antifreeze through it before storing for the winter.  Use clean water for your spray mixture  Store inside a building when not in use. DON’T  Use to pump bleach.
PAGE 4
Checking the Pressure Switch: If your motor is not running and you’ve checked the following: for loose wiring connections, fuse, the switch on the lead wire was “ON” and made sure you were connected to a fully charged battery and everything is fine, but the motor won’t run, then it’s time to check to see if the pressure switch is bad.  Remove the cover off the 1” square box (pressure switch) on the head of the pump, the cover is held on by one phillips-head screw. This will expose the two red wires.
PAGE 5
Exploded View/Parts List: LG-15-EC (5301302) Intake Detail Page 5
PAGE 6
Warranty LIMITED WARRANTY FOR NEW FIMCO, IND. EQUIPMENT WHO MAY USE THIS LIMITED WARRANTY. This limited warranty (the “Limited Warranty”) is provided by Fimco, Ind. to the original purchaser (“you”) of the Equipment (as defined below) from Fimco, Ind. or one of Fimco, Ind.’s authorized dealers. This Limited Warranty does not apply to any subsequent owner or other transferee of the Equipment.