Installation and Operating Instructions

ManualsBrandsFire Magic ManualsBarbecue50 Inch Patio Post Mount Deluxe Gas Grill with Infrared Burners, Warming Rack, 368 sq. in. Cooking Area, 42,000 Total BTU and Stainless Steel Burners: Natural Gas

SAFETY WARNINGS & CODES

INSTALLER: Leave these instructions with consumer.

CONSUMER: Retain for future reference.

INSTALLATION AND OPERATING

INSTRUCTIONS

IMPORTANT: READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION OR USE.

CODE AND SUPPLY REQUIREMENTS: This

barbecue must be installed in accordance with

local codes and ordinances, or, in the absence of

local codes, with either the latest National Fuel Gas

Code (ANSI Z223.1/NFPA 54), and Natural Gas and

Propane Storage and Handling Installation Code

(CSA-B149.1).

This appliance and its individual shutoff valves must

be disconnected from the gas supply piping system

when testing the system at pressures in excess of

½ psig (3.5 kPa).

This appliance must be isolated from the gas supply

piping system by closing its individual manual

shutoff valves during any pressure testing of the

gas supply system at pressures up to and including

½ psig (3.5 kPa).

DELUXE

POST BARBECUE

PATIO MOUNT

All electrical outlets in the vicinity of the barbecue

must be properly grounded in accordance with local

codes or, in the absence of local codes, with the

National Electrical Code, ANSI/NFPA 70, or the

Canadian Electrical Code, CSA C22.1, whichever

is applicable.

Keep all electrical supply cords and fuel supply

hoses away from any heated surface.

DANGER:

IF YOU SMELL GAS:

1. Shut off the gas to the appliance.

2. Extinguish any open ﬂ ame.

3. Open lid if equipped with an oven.

4. If odor continues, keep away from the

appliance and immediately call your gas

supplier or ﬁ re department.

WARNING:

1. Do not store or use gasoline or other

ﬂ ammable vapors and liquids in the

vicinity of this or any other appliance.

2. A propane cylinder, not connected for

use, shall not be stored in the vicinity of

this or any other appliance.

WARNING

mproper installation, adjustment, alteration,

service or maintenance can cause injury

or property damage. Refer to this manual.

For assistance or additional information,

consult a qualiﬁ ed professional installer,

service agency, or the gas supplier.

Robert H. Peterson Co. • 14724 East Proctor Avenue, • City of Industry, CA 91746

Certiﬁ ed to ANSI: Z21.58-2005 /

CSA 1.6-2005

REV 4 - 0907061309

L-C2-21209

Summary of content (20 pages)

PAGE 1
DELUXE POST BARBECUE PATIO MOUNT INSTALLATION AND OPERATING INSTRUCTIONS INSTALLER: Leave these instructions with consumer. CONSUMER: Retain for future reference. IMPORTANT: READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION OR USE. SAFETY WARNINGS & CODES DANGER: IF YOU SMELL GAS: 1. 2. 3. 4. WARNING: 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2.
PAGE 2
BÂTI DE LUXE DE PATIO DE BARBECUE DE POTEAU INSTALLATION ET CONSIGNES D’UTILISATION INSTALLATEUR : Laissez ces instructions avec le consommateur. CONSOMMATEUR : Maintenez pour la future référence. IMPORTANT: LISEZ CES INSTRUCTIONS SOIGNEUSEMENT AVANT DE COMMENCER L’INSTALLATION AVERTISSEMENTS ET CODES DE SÛRETÉ DANGER: AVERTISSEMENT: S’il y a une odeur de gaz: 1. Coupez l’admission de gaz de l’appareil. 2. Éteindre toute flamme nue. 3. Ouvrir le couvercle. 4.
PAGE 3
TABLE OF CONTENTS SAFETY WARNINGS & CODES PRODUCT DATA TABLE PARTS LIST PLANNING THE LOCATION OF THE POST BARBECUE ENSURING PROPER COMBUSTION AIR AND COOLING AIR FLOW ELECTRICAL OUTLETS EXHAUST REMOVAL INSTALLATION GAS SUPPLY PLUMBING REQUIREMENTS CONNECTING TO THE GAS SUPPLY SECURING THE POST BARBECUE SAFE USE & MAINTENANCE OF PROPANE-GAS CYLINDERS RIGID SHELF INSTALLATION CHECKING AND CONVERTING GAS TYPE CHECKING AND CONVERTING THE REGULATOR CHECKING/CONVERTING THE BURNER ORIFICES MAIN BURNER ORIFICE SIZE
PAGE 4
AVERTISSEMENTS Avertissements généraux : • Ce barbecue est pour ultilisation à l’extérieur seulement. Si l’appareil est entreposé à l’intérieur, enlever les bouteilles et les laisser à l’extérieur. • Ne pas ranger le gril immédiatement aprés l’avoir utilisé. le laisser refroidir avant de le déplacer ou de la ranger. Le non respect de cette mesure de sécurité pourrait entraîner un incendie causant des dommages à la propriété, des blessures ou la mort.
PAGE 5
PARTS LIST Item 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. Description Deluxe oven gourmet assembly Grill, 16" x 11 1/2" stainless steel rod (2) Shelf, Deluxe w/out cutout (2) Deluxe inner liner, assembly Deluxe post assembly Lag screw (1/4" x 1.5) and shield (1/4" x 1.
PAGE 6
PLANNING THE LOCATION OF THE POST BARBECUE This barbecue is designed FOR OUTDOOR USE ONLY. DO NOT use this unit under overhead combustible construction. DO NOT use this appliance inside a building, garage, or any unprotected, enclosed area (see EXHAUST REMOVAL). It must not be used in or on recreational vehicles or boats.
PAGE 7
INSTALLATION (Cont.) Back of timer valve Important: An external valve (with a removable key) in the gas line is necessary for safety when the barbecue is not in use. It also provides for convenient maintenance. Location of regulator if equipped (for natural gas only) CONNECTING TO THE GAS SUPPLY This post barbecue is capable of connecting to the gas supply in a few different ways. The connection can be made inside the post, under the post base, or out the back of the post.
PAGE 8
UTILISATION SÛRE ET ENTRETIEN DES CYLINDRES DE GAZ DE PROPANE IMPORTANT POUR VOTRE SÛRETÉ LISEZ ET SUIVEZ TOUS LES AVERTISSEMENTS ÉQUIPÉS DE VOTRE CYLINDRE DE GAZ DE PROPANE. En actionnant cet appareil avec un cylindre de gaz de propane ON DOIT observer ces instructions et avertissements. LE MANQUE DE FAIRE AINSI PEUT AVOIR COMME CONSÉQUENCE UNE INCENDIE OU UNE EXPLOSION SÉRIEUSE.
PAGE 9
SAFE USE & MAINTENANCE OF PROPANE-GAS CYLINDERS IMPORTANT FOR YOUR SAFETY READ AND FOLLOW ALL WARNINGS PROVIDED WITH THE PROPANE-GAS CYLINDER. When operating this appliance with a propane-gas cylinder, these instructions and warnings MUST be observed. FAILURE TO DO SO MAY RESULT IN A SERIOUS FIRE OR EXPLOSION. The use of pliers or a wrench should not be necessary. Only cylinders marked “propane” may be used. CYLINDER/CONNECTOR REQUIREMENTS a.
PAGE 10
RIGID SHELF INSTALLATION This barbecue comes with two (2) rigid shelves that must be attached. These can be attached using the four support screws provided and a Phillips-head screw driver. 1. Hold the shelf inverted so that one of the corner Shelf support screws holes in the shelf lines up with the appropriate upper screw hole in the barbecue. 2. Insert the screw, but do not tighten all the way so that the shelf can be easily rotated around the first screw. 3.
PAGE 11
CHECKING AND CONVERTING GAS TYPE This unit comes from the factory configured for WARNING one type of gas, as marked on the label behind the HAZARDOUS OVERHEATING WILL OCCUR faceplate. IF A NATURAL-GAS ORIFICE IS USED WITH PROPANE GAS. IF YOU ARE NOT SURE IF THE Converting this unit to burn a different type of CORRECT ORIFICES ARE INSTALLED, OR IF AN gas requires a conversion kit from the factory. ORIFICE CHANGE IS NECESSARY, REFER TO The professional installer who converts this THE FOLLOWING INSTRUCTIONS.
PAGE 12
CHECKING/CONVERTING THE BURNER ORIFICES MAIN BURNER ORIFICE SIZE CHECKING/ CONVERSION Note: The drill size is stamped on the face of each orifice. Before beginning, make sure you have the proper tools for the task. 7. Replace the orifice with an orifice of the proper drill size as listed in the Product Data Table. This task requires: • • 8. Replace the burner by first sliding the open end over the new orifice and then lowering the back end into position.
PAGE 13
AIR SHUTTER ADJUSTMENT MAIN BURNER AIR SHUTTER ADJUSTMENT Important: Tab Dimple Partially open Fig. 13-1 The air shutters must be adjusted after installation. If not, this appliance may not light, heat evenly, or cook properly. Notch Flame off ports (Turn tabs) Main burner shutters are accessed easily accessed by Main burner airair shutters are easily by removing removing front panelunder (face). shutters are the accessthe panel located theThe rightair hand shelf.
PAGE 14
BARBECUE SAFETY INFORMATION & MAINTENANCE Each time you use the barbecue, make sure that: DRIP COLLECTION SYSTEM 1. The area around the barbecue is clear of flammable vapors, liquids, and substances such as gasoline, yard debris, wood, etc. 2. There is no blockage of the airflow through the vent space located below the face of the unit. 3. When using propane gas: a. The special ventilation openings in the enclosure should be kept free and clear of debris (see PLANNING THE LOCATION OF THE BARBECUE). b.
PAGE 15
LIGHTING (IGNITION) INSTRUCTIONS Read entire instructions before lighting and follow these instructions each time you light the barbecue. ELECTRONIC LIGHTING FOR PROPANE ONLY OFF ONN RRNN O TUTU TOT O 1. Open all lids and remove all covers from the burners Propane tanks are equipped with a safety shut-down you wish to light. device that may cause low or no gas pressure/flame at the burners if operating and lighting instructions 2. Turn all gas control knobs to their OFF positions.
PAGE 16
ALLUMER DES INSTRUCTIONS (D’ALLUMAGE) Lisez les instructions entières avant que s’allumant et suivez ces instructions chaque fois vous lumière le barbecue. ÉCLAIRAGE ÉLECTRONIQUE POUR LE PROPANE SEULEMENT OFF OONN RNRN TUTU TOT O 1. Ouvrez tous les couvercles et enlevez toutes les couvertures Les réservoirs de propane sont équipés d’un dispositif d’arrêt de sûreté qui peut ne pas causer le bas ou aucun gaz pressure/flame des brûleurs que vous souhaitez vous allumer.
PAGE 17
CARE & CLEANING CARE AND CLEANING Your new Fire Magic® unit represents the latest and most advanced technology available. In order to continue to enjoy the benefits of your unit and to protect your investment, we recommend the following: Check and clean the burner ports and carry-over slits for blockage at least annually by removing the burner (see orifice changing instructions) and visually inspecting the burner inlet for insects and nests. A clogged burner can lead to a fire beneath the unit.
PAGE 18
ACCESSORIES THE GRILL BRUSH (OPTIONAL) THE WARMING RACK Purchase a Fire Magic® stainless-steel grill brush (sold separately) to keep your grill cleaner. It comes with scraper for large particles and a replaceable head with brass bristles for overall cleaning. The warming rack (Fig. 18-2) is packed separately. To install the warming rack, lift the front of the rack up slightly and insert the rack hangers into the two holes in the back of the inner oven hood just above the backburner.
PAGE 19
REPLACING THE IGNITOR BATTERY 1. Remove the ignitor cover by turning it counterclockwise. Note: If you have accidentally removed the rubber cap, follow the instructions below to replace it. Important: Do not attempt to pull or turn the rubber cap. WRONG!! 2. Remove batter y for replacement. The battery is reinstalled with the negative (-) end out. 3. After properly inserting the battery, replace the ignitor cover by turning the cap clockwise. 1. Pull the rubber cap and the inner plastic sleeve apart.
PAGE 20
FIRE MAGIC® OUTDOOR GAS GRILL LIMITED WARRANTY PLEASE COMPLETE AND RETURN YOUR REGISTRATION CARD, WHICH IS INCLUDED WITH YOUR FIRE MAGIC® GRILL LIFETIME WARRANTY - Fire Magic® cast stainless-steel burners, stainless-steel rod cooking grids, and stainless-steel housings are warranted for as long as you own your Fire Magic® grill.