Installation and Operating Instructions

ManualsBrandsFire Magic ManualsBarbecue41 Inch Regal I Countertop Gas Grill with 540 sq. in. Cooking Area, 64,000 Total BTU, Stainless Steel Burners and One Infrared Burner: Liquid Propane

REV 2 - 0609190904

L-C2-00506

SAFETY WARNINGS & CODES

INSTALLER: Leave these instructions with consumer.

CONSUMER: Retain for future reference.

INSTALLATION AND OPERATING

INSTRUCTIONS

Important: READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION

REGAL I DROP-IN

SERIES 34

OUTDOOR GAS BARBECUE

Photo shows unit with optional

backburner & oven.

DANGER

IF YOU SMELL GAS:

1. Shut off the gas to the appliance.

2. Extinguish any open ﬂ ame.

3. Open lid if equipped with an oven.

4. If odor continues, keep away from the

appliance, and immediately call your gas

supplier or ﬁ re department.

WARNING

1. Do not store or use gasoline, or other

ﬂ ammable vapors and liquids, in the

vicinity of this or any other appliance.

2. A propane cylinder not connected for use

shall not be stored in the vicinity of this

or any other appliance.

Robert H. Peterson Co. • 14724 East Proctor Avenue • City of Industry, CA 91746

CODE AND SUPPLY REQUIREMENTS: This

barbecue must be installed in accordance with local

codes and ordinances or, in the absence of local

codes, with either the current National Fuel Gas

Code (ANSI Z223.1NFPA 54), Natural Gas and

Propane Installation Code (CSA B149), or Propane

Storage and Handling Code (CSA B149.2).

This appliance and its individual shutoff valves must

be disconnected from the gas supply piping system

when testing the system at pressures in excess of

½ psig (3.5 kPa).

This appliance must be isolated from the gas supply

piping system by closing its individual manual

shutoff valves during any pressure testing of the

gas supply system at pressures up to and including

½ psig (3.5 kPa).

Improper installation, adjustment, alteration,

service, or maintenance can cause injury or

property damage. Refer to this manual. For

assistance or additional information consult

a qualiﬁ ed, professional installer, service

agency, or the gas supplier.

All electrical outlets in the vicinity of the barbecue

must be properly grounded in accordance with local

codes or, in the absence of local codes, with the

National Electrical Code, ANSI/NFPA 70, or the

Canadian Electrical Code, CSA C22.1, whichever

is applicable.

CAUTION: Keep all electrical supply cords and

fuel supply hoses away from any

heated surface.

Certiﬁ ed to ANSI: Z21.58

WARNING

Summary of content (24 pages)

PAGE 1
REGAL I DROP-IN SERIES 34 OUTDOOR GAS BARBECUE INSTALLATION AND OPERATING INSTRUCTIONS INSTALLER: Leave these instructions with consumer. CONSUMER: Retain for future reference. Photo shows unit with optional backburner & oven. Important: READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION SAFETY WARNINGS & CODES DANGER IF YOU SMELL GAS: 1. 2. 3. 4. WARNING 1. Do not store or use gasoline, or other flammable vapors and liquids, in the vicinity of this or any other appliance. 2.
PAGE 2
BARBECUE EXTÉRIEUR De GAZ De la SÉRIE 34 MAJESTUEUX De I DROP-IN INSTALLATION ET CONSIGNES D’UTILISATION INSTALLATEUR : Laissez ces instructions avec le consommateur. CONSOMMATEUR : Maintenez pour la future référence. La photo montre l’unité avec le backburner et le four facultatifs. Important: LISEZ CES INSTRUCTIONS SOIGNEUSEMENT AVANT DE COMMENCER L’INSTALLATION AVERTISSEMENTS ET CODES DE SÛRETÉ DANGER AVERTISSEMENT SI VOUS SENTEZ LE GAZ : 1. Coupez le gaz à l’appareil. 2.
PAGE 3
TABLE OF CONTENTS SAFETY WARNINGS & CODES TABLE OF CONTENTS PRODUCT DATA TABLE PARTS LIST FIRE MAGIC REGAL I DROP-IN SERIES GAS BARBECUE (w/BACKBURNER) PARTS LIST FIRE MAGIC REGAL I DROP-IN BACKBURNER & OVEN PARTS LIST (WHERE FITTED) PLANNING FOR INSTALLATION OF YOUR REGAL I DROP-IN SERIES BARBECUE WHERE TO INSTALL YOUR GAS BARBECUE INSURING PROPER COMBUSTION AIR AND VENTILATION EXHAUST REMOVAL ELECTRICAL OUTLETS SAFE USE & MAINTENANCE OF PROPANE GAS CYLINDERS CYLINDER AND CONNECTOR REQUIREMENTS AND SPECIFI
PAGE 4
AVERTISSEMENTS Avertissements généraux : • Ce barbecue est pour ultilisation à l’extérieur seulement. Si l’appareil est entreposé à l’intérieur, enlever les bouteilles et les laisser à l’extérieur. • Ne pas ranger le gril immédiatement aprés l’avoir utilisé. le laisser refroidir avant de le déplacer ou de la ranger. Le non respect de cette mesure de sécurité pourrait entraîner un incendie causant des dommages à la propriété, des blessures ou la mort.
PAGE 5
PARTS LIST Item 1. or 2. or 3. 4. 5. 6. 7. 8. or 9. 10. 11. 12. 13. 14. 15. 16. 17. 18. 19. 20. Description TOP PANEL, REGAL I DRP-IN ,S.
PAGE 6
FIRE MAGIC REGAL I DROP-IN SERIES GAS BARBECUE (w/BACKBURNER) PARTS LIST 4 2 11 IMPORTANT This Fire Magic oven and backburner are fully pre-assembled and tested at the factory. 3 DO NOT attempt to remove the oven and backburner (optional) from the barbecue prior to or during installation or damage to the connecting gas line and ignitor wiring may occur. 1 18 20 5 19 The plastic straps that secure the oven (optional) to the barbecue unit must be removed and discarded prior to lighting.
PAGE 7
FIRE MAGIC REGAL I DROP-IN BACKBURNER & OVEN PARTS LIST (WHERE FITTED) Important: Your Fire Magic barbecue, oven and backburner (where fitted) are fully pre-assembled and tested at the factory. Do not attempt to remove the oven and backburner from the barbecue prior to or during installation. Damage to the connecting gas line and ignitor wiring may occur. OVEN Oven PALnut NUT Pal The plastic straps that secure the oven to the barbecue unit should be removed and discarded prior to lighting.
PAGE 8
PLANNING FOR INSTALLATION OF YOUR REGAL I DROP-IN SERIES BARBECUE EXHAUST REMOVAL WHERE TO INSTALL YOUR GAS BARBECUE Fire Magic barbecues are designed for outdoor use If installed under a patio roof, the grill area should be fully covered by a chimney and exhaust hood. An only.
PAGE 9
SAFE USE & MAINTENANCE OF PROPANE GAS CYLINDERS IMPORTANT FOR YOUR SAFETY READ AND FOLLOW ALL WARNINGS PROVIDED WITH THE PROPANE GAS CYLINDER. When operating this appliance with a propane gas cylinder these instructions and warnings MUST be observed. FAILURE TO DO SO MAY RESULT IN A SERIOUS FIRE OR EXPLOSION. CYLINDER AND CONNECTOR REQUIREMENTS AND SPECIFICATIONS The use of pliers or a wrench should not be necessary. Only cylinders marked propane must be used.
PAGE 10
UTILISATION SÛRE ET ENTRETIEN DES CYLINDRES DE GAZ DE PROPANE IMPORTANT POUR VOTRE SÛRETÉ LISEZ ET SUIVEZ TOUS LES AVERTISSEMENTS ÉQUIPÉS DE VOTRE CYLINDRE DE GAZ DE PROPANE. En actionnant cet appareil avec un cylindre de gaz de propane ON DOIT observer ces instructions et avertissements. LE MANQUE DE FAIRE AINSI PEUT AVOIR COMME CONSÉQUENCE UNE INCENDIE OU UNE EXPLOSION SÉRIEUSE.
PAGE 11
INSTALLING YOUR FIRE MAGIC REGAL I DROP-IN SERIES BARBECUE 1. POSITION THE BURNERS FOR OPERATION a. After checking orifice drill size, install the air shutter spring and the air shutter over the orifice holder fitting in the order and position shown in Fig. 11-1. b. Carefully place the burner(s) back in position, resting on the back flange of the inner liner so that the brass orifice and orifice holder fittings project well into the burners. c. Replace all the burner hold down clips.
PAGE 12
CHECKING AND CONVERTING GAS TYPE This barbecue comes from the factory configured for one type of gas as marked on the label behind the barbecue face plate. WARNING HAZARDOUS OVERHEATING WILL OCCUR IF A NATURAL GAS ORIFICE IS USED WITH PROPANE GAS. IF YOU ARE NOT SURE THE CORRECT ORIFICES ARE INSTALLED, OR IF AN ORIFICE CHANGE IS NECESSARY, REFER TO THE FOLLOWING INSTRUCTIONS. Converting this barbecue to burn a different type of gas requires a conversion kit from the factory.
PAGE 13
CHECKING/CONVERTING THE BURNER ORIFICES CHECK FUEL ORIFICES FOR PROPER SIZE a. If you removed the face plate re-install the ignition wires. Your barbecue may have either two (2) or four (4) wires depending on the exact model. Pull the drip tray out. Lean the face forward and plug the wires into the terminals on the spark generator (Fig. 13-2). The wires can be plugged into any terminal. a. Your Regal I barbecue is equipped with fuel orifices for natural gas, unless otherwise indicated.
PAGE 14
CHECKING/CONVERTING THE BURNER ORIFICES (Cont.) 6. Pull the backburner assembly to the left, clear of the orifice, and then rotate the top forward and downward and lay it face down across the main burner dividers. CAUTION: Be careful not to damage the wires connected to the backburner assembly. 7. Use the socket driver to remove the exposed orifice and replace it with the correct orifice for the gas to be burned (see Product Data Table 1 for correct orifice sizes, based on burner type and gas type). 8.
PAGE 15
AIR SHUTTER ADJUSTMENT MAIN BURNER AIR SHUTTER ADJUSTMENT Important: Tab Dimple Partially open Fig. 15-1 The air shutters must be adjusted after installation. If not, this appliance may not light, heat evenly, or cook properly. Notch Flame off ports (Turn tabs) Main burner air shutters are easily accessed by removing the frontcool) panel The air shutters (when the(face). top panel (face).
PAGE 16
BARBECUE SAFETY INFORMATION & MAINTENANCE Each time you use the barbecue, make sure that: DRIP COLLECTION SYSTEM 1. The area around the barbecue is clear of flammable The drip collector in this barbecue is part of the unit’s substances such as gasoline, yard debris, wood, main frame and is located below the burners. The drip etc. collector has one hole that will allow excess drippings to 2.
PAGE 17
LIGHTING (IGNITION) INSTRUCTIONS Read entire instructions before lighting and follow these instructions each time you light the barbecue. MANUAL LIGHTING ELECTRONIC LIGHTING 1. Open all lids and remove all covers from the burners CAUTION: Always wait 5 minutes for gas to you wish to light. clear after any unsuccessful lighting attempt. 2. Turn all gas control knobs to their OFF positions. 3. Turn on the gas at its source. 1. Follow steps 1 through 4 (left).
PAGE 18
ALLUMER DES INSTRUCTIONS (D’ALLUMAGE) Lisez l’instruction entière avant que s’allumant et suivez ces instructions chaque fois vous lumière le barbecue. Note: Les barbecues dans quelques installations réalisent ÉCLAIRAGE ÉLECTRONIQUE un meilleur mélange d’air/gas et mettront à feu plus 1. Ouvrez tous les couvercles et enlevez toutes les couvertures rapidement si le bouton de commande de brûleur des brûleurs que vous souhaitez vous allumer.
PAGE 19
ROTISSERIE INSTRUCTIONS 2. Turn the counterbalance on the spit so the counterbalance rod and weight point upward, or opposite from the heavy side of the meat. Tighten the counterbalance rod in the hub against a flat surface of the spit rod to secure (Fig. 19-1). USING YOUR BACKBURNER AND ROTISSERIE Rotisserie cooking with the backburner is accomplished without use of the main burners. Follow the steps in the appropriate sections below to set up and use these accessories (see PARTS LIST for image).
PAGE 20
REPLACING THE IGNITOR BATTERY 1. Remove the ignitor cover by turning it counter-clockwise. Note: If you have accidently removed the rubber cap, follow the instructions below to replace it. Important: Do not attempt to pull or turn the rubber cap. WRONG!! 2. Remove batter y for replacement. The battery is re-installed with the negative (-) end out. 3. After properly inserting the battery, replace the ignitor cover by turning the cap clockwise. 1. Pull the rubber cap and the inner plastic sleeve apart.
PAGE 21
ACCESSORIES USING THE GRILL SCRAPER WARMING RACK The triangular stainless steel piece with serrated edges is designed to be used as a tool to quickly and easily scrape food particles and drippings off the grill after barbecuing. To use it, simply align one of the edges of the scraper so that the cooking grid bars fit into the grooves in the serrated edge, and then scrape it along the length of the cooking grid. Repeat as needed. The warming rack (Fig. 21-2) is packed separately with the barbecue.
PAGE 22
This page intentionally left blank.
PAGE 23
BARBECUE CARE & CLEANING CARE AND CLEANING The new Fire Magic barbecue represents the latest and most advanced technology available. In order to continue to enjoy the benefits of this technology and to protect your investment, we recommend the following: Check the burner ports annually for blockage. The inside of the barbecue may be cleaned periodically with oven cleaner if desired. Follow the oven cleaner instructions for proper use.
PAGE 24
FIRE MAGIC OUTDOOR GAS BARBECUES LIMITED WARRANTY PLEASE COMPLETE AND RETURN YOUR REGISTRATION CARD WHICH IS INCLUDED WITH YOUR BARBECUE LIFETIME WARRANTY - Fire Magic cast stainless steel burners, stainless steel rod cooking grids, and stainless steel housings (including liners, frames, ovens, and barbecues faces) are warranted for as long as you own your Fire Magic barbecue.