Troubleshooting Guide

ManualsBrandsFire Sense ManualsOutdoor Heating46,000 BTU Aged Chestnut Gas Patio Heater

½¼Ç\¿½¼ÃÙ\¿½¼Ãu\¿61736, 61737, 61738, 61739, 61740, 61741, 61742, 61743\¿

½Çuuu\¿½Ç¼lw\¿½Ç¼lu\¿½Çl¼\¿½ÃÙÙl\¿½ÃÙÙ\¿½ÃÙÙ

DANGER

FOR YOUR SAFETY: ¿If you smell gas:

1. Shut off gas to the appliance.

Ç¦¿ÒÁyÉ¸¿>Ó¿¡g¿t>g¦

Ã¦¿If odor continues, keep away from the

appliance and immediately call your gas

¸É¡¡gµ¿µ¿tµg¿_g¡>µÁgÁ¦

DANGER

DANGER indicates an imminently hazardous

situation which, if not avoided, will result in

death or serious injury.

DANGER

Failure to comply with the precautions and

instructions provided with this heater can

result in death, serious bodily injury and

property loss or damage from hazards t¿tµg\¿

gÒ¡¸\¿LÉµ\¿>¸¡ÓÒ>Á\¿and/or carbon

monoxide poisoning. Only persons who can

understand and follow the instructions should

use or service this heater.

WARNING

Do not store or use gasoline or other t>>Lg¿

Ð>¡µ¸¿>_¿ªÉ_¸¿¿Ág¿vicinity of this or any

other appliance.¿An LP¿Uylinder not connected for

use shall not be stored in the vicinity of this or

any other appliance.

WARNING

Improper installation, adjustment, alteration,

service or maintenance can cause property

damage, injury or death. Read the installation,

operation and maintenance instructions

thoroughly before installing or servicing this

equipment.

WARNING

",½"1/"",½1-½" 9r

Comfort, Quality & Style Since 1998

Outdoor &RPPHUFLDOPatio Heater

Item#:

60368, 60485, ½ÃÙ\¿61185, 61444, 61726, 61727, 61728,

ATTACH YOUR RECEIPT

Keep a copy of your proof of

¡ÉµU>¸g¿µ¿µ_gµ¿Utµ>Á¿

which will be µgªÉµg_ if you need

to contact us about warranty

coverage.

Serial No.

Purchase Date

WARNING

/¸¿¡µ_ÉUÁ¿U>¿gÒ¡¸g¿ÓÉ¿Á¿UgU>¸¿

UÉ_y¿>µL¿Ò_g\¿g>_\¿µÉ¿

£gÒ>Ð>gÁ¿U¡É_¸¤\¿£ÇgÁÓgÒÓ¤¿

¡Á>>Ág¿£*¤¿>_¿¸Ó¿¡Á>>Ág¿

£ *¤\¿ÑU¿>µg¿Ñ¿Á¿Ág¿-Á>Ág¿t¿

>tµ>¿Á¿U>É¸g¿U>Ugµ¿>_¿LµÁ¿_gtgUÁ¸¿µ¿

Ágµ¿µg¡µ_ÉUÁÐg¿>µ¦¿µ¿µg¿tµ>Á\¿

y¿Á¿ÑÑÑ¦*½u7>µy¸¦U>¦yÐ¦

// /"

t¿ÓÉµ¿¡>Á¿g>Ágµ¿_g¿¸¿gªÉ¡¡g_¿ÑÁ¿>¿

L>¸g¿

ÑgyÁ¾¸>_¿LÒ\¿Á¿¸¿¸ÁµyÓ¿µgUg_g_

¿Á>Á¿

ÓÉ¿t¿Á¿ÑÁ¿¸>_¿µ¿tg¿yµ>Ðg¿>_¿>ÁÁ>U¿Á¿

¸gUÉµgÓ¿Á¿Ág¿LÁÁ¿t¿Ág¿g>Ágµ¦¿¿Ñ_Ó¿

U_Á¸\¿¸Áµg¿Ág¿g>Ágµ¿¿>¿¡µÁgUÁg_¿>µg>¿µ¿

ÁgµÑ¸g¿¸gUÉµg¿Á¦¿1¸gUÉµg_¿g>Ágµ¸¿U>¿Lg¿

LÑ¿Ðgµ¿¿_gµ>Ág¿Á¿y¿Ñ_¦¿>>yg¿

_Ég¿Á¿Ñg>Ágµ¿µ¿>UÁ¸¿t¿_¿¸¿Á¿UÐgµg_¿

É_gµ¿Ñ>µµ>ÁÓ¦

4XHVWLRQVSUREOHPVPLVVLQJSDUWV"

%HIRUHUHWXUQLQJWR\RXUUHWDLOHURXUH[FHSWLRQDOFXVWRPHUVHUYLFHLVDYDLODEOH

&DOOWROOIUHH



DPȂSP(67

(PDLO¿

/LYHFKDW

FVHUYLFH#ZHOOWUDYHOHGQHW

ZZZEDONHQHKRPHFRP DPȂSP(670RQȂ)UL

0813

Summary of content (16 pages)

PAGE 1
Comfort, Quality & Style Since 1998 Outdoor &RPPHUFLDO Patio Heater Item#: 60368, 60485, ½ÃÙ\¿61185, 61444, 61726, 61727, 61728, ½¼Ç\¿½¼ÃÙ\¿½¼Ãu\¿61736, 61737, 61738, 61739, 61740, 61741, 61742, 61743\¿ ½Çuuu\¿½Ç¼lw\¿½Ç¼lu\¿½Çl¼\¿½ÃÙÙl\¿½ÃÙÙ\¿½ÃÙÙ DANGER FOR YOUR SAFETY: ¿If you smell gas: 1. Shut off gas to the appliance.
PAGE 2
BEFORE YOU BEGIN TABLE OF CONTENTS Before You Begin Page 2 Safety Information Page 3 Package Contents Page 4 Hardware Contents Page 4 Assembly Page 5-8 Operating Instructions Page 9-12 Care and Maintenance Page 13 Troubleshooting Page 14 Replacement Parts List Page 15 Warranty Information Page 16 %()25( <28 %(*Ζ1 3OHDVH UHDG DQG XQGHUVWDQG WKLV HQWLUH PDQXDO EHIRUH DWWHPSWLQJ WR DVVHPEOH RSHUDWH RU LQVWDOO WKLV DSSOLDQFH ΖI \RX KDYH DQ\ TXHVWLRQV UHJDUGLQJ WKH SURGXFW SOHDVH FRQWDFW
PAGE 3
SAFETY INFORMATION , , indicates an imminently hazardous situation which, if not avoided, will U>É¸g death or serious injury. DANGER EXPLOSION—FIRE HAZARD T Keep solid combustibles, such as building materials, paper, or cardboard a safe distance away from the heater as¿ recommended by the instructions. T *µÐ_g¿>_gªÉ>Ág¿Ug>µ>Ug¸¿>µÉ_¿>µ¿ openings into the combustion chamber.
PAGE 4
PACKAGE CONTENTS B PART A C D E DESCRIPTION QUANTITY A 4 packed in inner carton B 1 packed under Base C Head Assembly 1 packed in 1 inner carton D Tank Housing 1 E Gas Hose 1 attached to Head Assembly F Upper Post 1 G Lower Post 1 H Regulator 1 packed in inner carton I Post Supports 3 packed in 1 inner carton J Base¿£ÑÁ¿¡µg¸Á>g_¿¸>_LÒ¤ 1 K Wheel Assembly 1 packed in inner carton L Chain (secures LPG cylinder) 1 packed with post supports F HARDWARE CONTENTS
PAGE 5
ASSEMBLY PREPARATION Before beginning assembly of this appliance, make sure all parts are present. Compare all parts with package contents list and hardware contents as listed on page 4 of this manual. If any part is missing or damaged, do not attempt to assemble this product. Contact ustomer -ervice for replacement parts.
PAGE 6
ASSEMBLY 3 Attach the Lower Post G to the Post Supports I. Once you have tightened the bolts holding the Post Supports I to the Base J, align the holes in the Lower Post G with the holes on the tops of the Post Supports and insert a Large Bolt through the hole in the Post Support. Secure with a Small Flange Nut. Repeat this in the 5 remaining holes (6 holes total—¿ 2 for each Post Support piece). Handtighten initially then tighten with the Wrench when all ¿¶ have been inserted.
PAGE 7
ASSEMBLY 7 Attach Head Assembly C to Upper Post F[¿ ¸g¿µ¿ µgÐg¿Ág¿w¿->½ ¿¶½Í¿½ U½7>¶g³¶¿¡µg¸Á>g_¿ 1 g³¼ Íg³½*¶¿¶¿ ¾ ¿>_¿>y¿w¿¸>¿g¸¿¿Ág¿ g>_½ Ág¿gU¿t¿Ág¿ g>_½ ¶¶gLÏ¦¿,ÉÁg¿ >¶½ ¶g¿ ¿_Ñ¿Á¿ ¶¶gLÏ¿ ¿ÑÁ¿w¿¸>¿g¸¿¿Ág¿1 g³½*¶¿¿ ¦¿ ¸gµÁ¿Ág¿w¿ ->½ ¿¶½Í¿½ U½7>¶g³¶¿ÁµÉy¿Ág¿>yg_¿w¿g¸¿>_¿ ÁyÁg¿¸gUÉµgÓ¿ÑÁ¿Ág¿ÑµgU¦ Hardware Used: 4x Small Bolt w/Lock Washer 8 NOTE: MAKE SURE TO REMOVE PROTECTIVE PLASTIC COVER ON REFL
PAGE 8
ASSEMBLY 9 While supporting heater, tilt the Head Assembly C and slide 3 Large Flat Washers over the ,g×gU¿³½-¿Å_¶. Place the ,g×gU¿³½ ¶¶gLÏ onto the ,g×gU¿³½-¿Å_¶ and slide 3 Large Flat Washers over the ,g×gU¿³½-¿Å_¶ and onto the ,g×gU¿³½ ¶¶gLÏ. Secure with 3 Wing Nuts. Once you have tightened the Wing Nuts, return the heater to an upright position. Hardware Used: 6x Large Flat Washer | 3x Wing Nut 10ñ½ Connect the hose and regulator to the LPG tank. The LPG tank is sold separately.
PAGE 9
OPERATING INSTRUCTIONS ¿É¿¸É¡¡Ó¿¡µg¸¸Éµg¿t¿¦u¿¡¸¿¸¿µgªÉµg_¿tµ¿Ág¿¡Éµ¡¸g¿t¿¡ÉÁ¿ adjustment of propane gas. Storage of an appliance indoors is permissible T ¿Á¿¸Áµg¿>¿¸¡>µg¿ *y>¸ only if the cylinder is disconnected and removed from the appliance. A cylinder cylinder under or near this must be stored outdoors in a well-ventilated area out of the reach of children. appliance.
PAGE 10
OPERATING INSTRUCTIONS BEFORE TURNING GAS SUPPLY ON: LEAK TEST WARNING 1. Make 2-3 oz. of leak test solution £g¿¡>µÁ¿ªÉ_¿_¸¿Ñ>¸y detergent and three parts water). 2. Apply several drops of solution where hose attaches to regulator. T Perform all leak tests outdoors. T¿ ÒÁyÉ¸¿>¿¡g¿Û>g¸¦ T NEVER leak test when smoking T Do not use heater until all connections have been leak tested and show no signs of leakage. 1. Your heater was designed and approved for OUTDOOR use only.
PAGE 11
OPERATING INSTRUCTIONS LIGHTING WARNING NOTE: For initial start or after any cylinder change, hold the control knob in for 2 minutes to purge air from all gas lines RN TU before proceeding. 1. Turn the control knob to the “OFF” position. 2. Fully open the LPG tank valve. 3. Push in and turn the control knob to HI symbols. 4. Keep the control knob depressed and then push the RED igniter button simultaneously, push several times to ignite the main burner. Repeat until the burner ignites.
PAGE 12
OPERATING INSTRUCTIONS OPERATION CHECKLIST: For a safe and ¡g>¸>Á heating experience, perform this check before each use: WARNING FOR YOUR SAFETY Heater will be hot after use. Handle with extreme care. BEFORE OPERATING: I am familiar with entire owner’s manual and understand all precautions noted. All components are properly assembled, intact and operable. No alterations have been made. All gas connections are secure and do not leak. Wind velocity is below 10 mph.
PAGE 13
CARE AND MAINTENANCE To enjoy years of outstanding performance from your heater, make sure you WARNING perform the following maintenance activities on a regular basis: KEEP EXTERIOR SURFACES CLEAN. ¦ 1¸g¿¸>¡Ó¿Ñ>Ágµ¿tµ¿Ug>y¦¿ gÐgµ¿É¸g¿Û>>Lg¿µ¿Uµµ¸Ðg FOR YOUR SAFETY T Do NOT touch or move heater for at least 45 minutes after use. T¿,gÛgUÁµ¿¸¿Á¿Á¿Ág¿ÁÉU¦ T¿ Ñ¿µgÛgUÁµ¿Á¿U¿Lgtµg¿ÁÉUy¦ cleaning agents. 2.
PAGE 14
TROUBLESHOOTING PROBLEM POSSIBLE CAUSE CORRECTIVE ACTION Gas valve may be off Turn gas valve ON Fuel tank may be empty ,gÚ¿ * ¿Á> "µÚUg¿LUg_ Air in supply system Loose connection Main burner will not light Burner unit Purge air from lines[ pen gas lines and depress control knob for 2-3 minutes.
PAGE 15
PACKAGE CONTENTS B A C D PART DESCRIPTION QUANTITY A ,gÛgUÁµ¿*>g 4 packed in inner carton B ,gÛgUÁµ¿ gÁgµ¿ >¡ 1 packed under Base C Head Assembly 1 packed in 1 inner carton D Tank Housing 1 E Gas Hose 1 attached to Head Assembly F Upper Post 1 G Lower Post 1 H Regulator 1 packed in inner carton I Post Supports 3 packed in 1 inner carton J* Base* 1 K Wheel Assembly 1 packed in inner carton L Chain (secures LPG cylinder) 1 packed with post supports *Some models c
PAGE 16
LÓ / ½7 ,, /9 Å¶¿g³¶½½¿g½ ¿yÅÅ¶½17¿½ ³t½t½ Å³U>¶g½t³½>½>Å¿³Óg_½³g¿>g³\¿Á¸¿¡µ_ÉUÁ¿¸¿Ñ>µµ>Ág_¿ tµ¿>¿¡gµ_¿t¿¿Óg>µ¿tµ¿µy>¿¡ÉµU>¸g¿_>Ág¿>y>¸Á¿_gtgUÁ¸¿¿>Ágµ>¸¿ >_¿Ñµ>¸¡¿É_gµ¿µ>¿É¸g¦¿/¸¿Ñ>µµ>ÁÓ¿_g¸¿ "/¿UÐgµ¿µ>¿ Ñg>µ¾Ñg>Ágµy\¿gÒ¡¸Éµg¿Á¿Ñ>Ágµ\¿tµgg×y¿Ág¡gµ>ÁÉµg¸\¿¸\¿tÉ_¸\¿µ¿ UgU>¸¿",¿É¸g¿¿>¿UgµU>¿UÁgÒÁ¿t¿Ág¿ÉÁ¿¸¿Á¿_g¸y>Ág_¿>¸¿>¿ UgµU>¿_g¦¿ Á¿7g¿/µ>Ðgg_¿ Ðy²¸¿¸g¿_¸UµgÁ\¿¡µ_ÉUÁ¸¿É_gµ¿