fdg_safety_2016_2.
TABLE OF CONTENTS Product Record Information....................................1 For Your Safety.....................................................2 Safety Symbols.....................................................2 Installation Safety Precautions.................................3 Use and Care.......................................................5 Food Safety..........................................................9 Limited Warranty..................................................
DANGER 1. Never operate this appliance unattended. 2. Never operate this appliance within 10ft (3m) of any structure, combustible material or other gas cylinder. 3. Never operate this appliance within 25 ft (7.5 m) of any flammable liquid. 4. If a fire should occur, keep away from the appliance and immediately call your fire department. Do not attempt to extinguish an oil or grease fire with water.
Call Cooker Service Center for Help and Parts • If you need assistance with your product or warranty parts call 1-281-206-2678. Hours of Service Center Operation are 8:00 A.M. To 5:00 P.M. CST Monday - Friday. • To order non-warranty replacement parts or accessories please visit us on the web at www. FireDiscCookers.com or call 1-281-206-2678 and one of our friendly and knowledgeable agents will be glad to assist you.
For Safe Use of Your Cooker and to Avoid Serious injury: Regulator/Valve Installation/Removal 1. Regulator should never be fully removed unless damaged. Refer to regulator to burner assembly instructions. 2. With knob pointing to back of cooker, insert Regulator/Valve with pipe into end of burner and screw until hand tight. Do not over tighten. 3.Control knob should face upward with threaded end facing down. 4. To remove reverse steps. Leak Testing (1lb.
Safety Tips: Safety Tips • The use of alcohol, prescription or nonprescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance. • When cooker is not in use, disconnect 1 lb. cylinder or hoses. • Never move cooker while in operation or still hot. Allow the appliance to cool before moving or storing. • Cooker stand is designed to support the bowl that came with the cooker. Do not use any other pots, pans, griddles or other utensils.
DANGER CARBON MONOXIDE HAZARD • For outdoor use only. • Never use inside house, or other unventilated or enclosed areas. This outdoor stove consumes air (oxygen). Do not use in unventilated or enclosed areas to avoid endangering your life NATURALHAZARD – SPIDERS • Never store propane near high heat, open flames, pilot lights, direct sunlight, other ignition sources or where temperatures exceed 120°F (49°C). • Propane is heavier than air and can accumulate in low places.
General Cooker Cleaning: Do not mistake brown or black accumulation of grease and smoke for paint. Interiors of gas cookers are not painted at the factory (and should never be painted). Apply a strong solution of detergent and water or use a cooker cleaner with scrub brush on insides of cooker lid and bottom. Rinse and allow to completely air dry. Do not apply a caustic grill/oven cleaner to painted surfaces. General Cooker Cleaning: • Clean cooking surface.
USDA Recommended Internal Cooking Temperatures: Ground Meat Beef, Pork, Veal, Lamb................................... 160°F Turkey, Chicken............................................ 165°F Fresh Beef, Veal, Lamb Medium Rare................................................ 145°F (let stand 3 minutes before cutting) Medium....................................................... 160°F Well Done.................................................... 170°F Poultry Chicken & Turkey, whole.............................
This warranty applies only to the ORIGINAL PURCHASER and is not transferable. Therefore, we require reasonable proof of your date of purchase. Therefore, you should retain your sales slip or invoice. This limited warranty is limited to the repair or replacement of parts that prove defective under normal use and service and which on examination, to TEXAS CUSTOM GRILLS, LLC’ satisfaction, they are defective.
