Owner's Manual

ManualsBrandsFirenado ManualsFire Pit AccessoriesFN-36FLT-SQP 36" Flat Square Burner Pan, in Stainless Steel

Fire Feature Owner’s Manual

ATTENTION

INSTALLER: PLEASE LEAVE THESE INSTRUCTIONS WITH THE CONSUMER.

CONSUMER: PLEASE READ & RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE AND BEFORE INSTALLING OR

OPERATING.

WARNING

• Improper installation, adjustment, alteration, service, or maintenance can cause injury, death, or property

damage.

• Read the installation, operation, and maintenance instructions thoroughly before installing, operating, or

servicing this equipment to reduce risk of fire, burn hazard, or other injury.

• This manual should be retained for your information.

• Do not operate this fire feature without having read this manual.

• All gas installations must be performed by a qualified technician or authorized service agent.

• NOTE: This fire feature is not intended for commercial use.

WARNING

• Do not store or use gasoline or other flammable vapors and liquids in vicinity or this or any

other appliance.

• An LP gas cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

• Never operate with a LP gas cylinder inside.

WARNING

WHAT TO DO IF YOU SMELL GAS WHEN NOT IN OPERATION:

• Shut off gas to fire feature.

• Extinguish any open flame.

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any phone in your building.

• Immediately call your gas supplier. Follow your gas supplier’s instructions.

• If you cannot reach your gas supplier, call the fire department.

CARBON MONOXIDE HAZARD

• This fire feature will produce carbon monoxide which has no odor.

• As with any gas appliance, harmful carbon monoxide is produced during the combustion process that should

not be allowed to accumulate in a confined space.

• Please note since hot air rises above this fire feature while in operation, covered locations must be avoided.

• Using this fire feature in an enclosed space can cause death.

• Never use this fire feature in an enclosed space such as a camper, tent, car, or home.

• Do not locate this fire feature where an overhang or awning may cover it.

WARNING: FOR OUTDOOR USE ONLY

Summary of content (11 pages)

PAGE 1
Fire Feature Owner’s Manual WARNING: FOR OUTDOOR USE ONLY ATTENTION INSTALLER: PLEASE LEAVE THESE INSTRUCTIONS WITH THE CONSUMER. CONSUMER: PLEASE READ & RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE AND BEFORE INSTALLING OR OPERATING. • • • • • • • • • WARNING Improper installation, adjustment, alteration, service, or maintenance can cause injury, death, or property damage.
PAGE 2
GENERAL SAFETY & INSTALLATION WARNINGS • • • • Safe operation of this fire feature depends upon its proper installation. A qualified professional installer and service technician must perform adjustments and service of the burner. Proper location and proper use is essential to insure safe and continued trouble-free operation. Any non-approved alterations made to the fire feature will void the product’s warranty.
PAGE 3
• • • BEWARE OF SPIDERS CAUTION: BURNER TUBES MUST BE INSPECTED AND CLEANED BEFORE EACH USE. Spiders and small insects occasionally spin webs or make nests in the burner tubes. These webs can lead to a gas flow obstruction, which could result in a fire in and around the burner tubes. Frequent inspection and cleaning of the burner tubes is necessary. WARNING • This fire feature should be inspected before use and at least annually by a qualified service person.
PAGE 4
FIRE FEATURE INSTRUCTIONS WARNING: FOR OUTDOOR USE ONLY If designing and building your own fire feature, please read and follow the instructions below. In addition to the information below, you must check your local codes and consult the local authority having jurisdiction. • • • • Do not operate in a building, garage or any other enclosed areas. This could result in carbon monoxide buildup which could result in injury or death.
PAGE 5
• • • • • • • • • • • • • • Do not store any LP cylinder or tank not connected for use with the burner, in the area of this burner, inside or around the firepit, or any other appliance. Never store an LP cylinder or tank indoors, or within the reach of children. Never test the burner for gas leaks using a lighted match or any other open flame; see section on Leak Testing. The use of accessories, regulators, or components not recommended by the burner manufacturer may cause injuries and will void warranty.
PAGE 6
GAS SAFETY AND INSTALLATION WARNINGS • • • • • • All gas connections should be made by a professional qualified technician and in accordance with local codes and ordinances. The installation must conform with local codes. Do not twist the gas supply hose. Before each use, visually inspect the gas supply hose for cracks, cuts or excessive wear. Replace the hose if necessary. Check for gas leaks before each use.
PAGE 7
CHECKING FOR GAS LEAKS Perform a leak test before each use whether the gas supply has been disconnected or not. In addition, whenever the gas is connected to the regulator or whenever any part of the gas system is disconnected or replaced, perform a leak test. As a safety precaution, remember to always leak test your burner outdoors in a well-ventilated area. Never smoke or permit sources of ignition in the area while doing a leak test. Do not use a flame, such as a lighted match to test for leaks.
PAGE 8
FIRE FEATURE OPERATION Gas pressure and type should be checked prior to use and installation. • Natural Gas: Supply pressure: Minimum 3.5” W.C.; Maximum 5.0” W.C. • Before use, test all gas connections for leaks. Do not use fire feature if there is any evidence of leaking gas. If leaking gas is suspected, turn off main gas supply and have repaired immediately by a qualified technician. Wind and gusty conditions will affect the flame in an unpredictable manner.
PAGE 9
FIRE FEATURE START-UP • • • • • • • • • • • • • • • • • • • • • Unpacking the Unit: A final inspection of your product occurs at the factory to ensure a quality product is packaged. Please re-check for possible shipping damage immediately after unpacking your burner. If the burner is found to have some damage, contact your dealer immediately as often the shipping carrier will have a timeframe to report damage.
PAGE 10
LIMITED WARRANTY Firenado Stainless Steel burners and pans are warrantied against manufacturing defects under normal use and service for a period of 10 years. Installation, repair and maintenance work should be performed by an authorized service technician. Work by unqualified persons could be dangerous and will void the warranty. All Natural and LP Gas appliances must have a qualified installer complete the installation for the warranty to be in effect.
PAGE 11
Fire Feature Ventilation WARNING Failure to adequately vent your fire feature could result in an explosion or fire. When building or installing a fire feature, it is necessary to provide adequate ventilation. This is necessary for not only proper combustion, but also to prevent a buildup of gas. Vents must be placed on opposing sides to allow for cross ventilation. Each vent must have at least 18 square inches of ventilation per side. This allows for heat and/or residual fuel to escape.