Product features may vary from the picture above. JEEP and the Jeep grille design are registered trademarks of DaimlerChrysler Corporation and are used under license. ©DaimlerChrysler Corporation. Fisher-Price, Power Wheels by Fisher-Price, BARBIE Splash and Power Lock are U.S. trademarks of Mattel, Inc. Owner’s Manual with Assembly Instructions Please read this manual and save it with your original sale’s receipt.
Parts A B C D E F G H I J K L M N O Important Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 Warnings and Cautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
B Warnings and Cautions ELECTRICAL HAZARD WARNING • Battery can fall out and injure a child if vehicle tips over. Always use battery clamp. • PREVENT FIRE - Do not bypass a Power Wheels® fuse. It is a safety device. - Use only a Power Wheels® 25 Amp fuse. - Never modify the electrical system. Alterations could cause a fire resulting in serious injury and could also ruin the electrical system. - Use of the wrong type battery, fuse or charger could cause a fire or explosion resulting in serious injury.
C Parts • If you experience a problem with this product, or are missing a part, please call us at 1-800-348-0751, rather than return this product to the store. • Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded. • Metal parts have been coated with a lubricant to protect them during shipment. Wipe all metal parts with a paper towel to remove any excess lubricant.
Parts 6-VOLT CHARGER Key Assembly Microphone 6 Volt Charger ® 25 amp Fuse - 1* Radio Dial Shifter 6 Volt Battery Gas Cap Assembly Steering Wheel Cap Traction Band - 4 Radio Knob - 2 Not Shown: Label Sheet *For your convenience, an extra 25 amp fuse has been included. #8 x 1" Screw – 12 #6 x 1/2" Screw – 11 Cap Nut – 2* #8 x 18 x 1" Screw – 2 #6 x 1 1/2" Screw – 2 All Shown Actual Size *For your convenience, an extra cap nut has been included.
D Parts Diagram 34 31 15 16 9 30 32 5 18 34 25 4 19 24 27 31 26 5 31 23 21 20 10 33 33 34 14 22 1 28 34 13 ® 3 29 34 17 6 7 8 11 12-VOLT CHARGER 2 11 12 Note: Some parts shown are assembled on both sides of the vehicle. 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14.
E Battery Charging ELECTRICAL HAZARD WARNING CAUTION • Battery can fall out and injure a child if vehicle tips over. Always use battery clamp. • PREVENT FIRE - Do not bypass a Power Wheels® fuse. It is a safety device. - Use only a Power Wheels® 25 Amp fuse. - Never modify the electrical system. Alterations could cause a fire resulting in serious injury and could also ruin the electrical system.
Battery Charging 1 3 25 Amp Fuse ANT IMPORT E MUST FUSD IN TOP AMP RE A 25INSTALLE BEFO GE HAR BE BATTERY OF WILL REC E TOY OPERAT OR ® ® GOOD FUSE "BLOWN" FUSE • Plug the charger into a standard 120 volt wall outlet. Note: If power flow to the wall outlet is controlled by a switch, make sure the switch is “ON”. • Before first-time use, charge the battery for at least 18 hours. Never charge the battery longer than 30 hours.
F Assembly Steering Column 3 WARNING Children can be harmed by small parts, sharp edges and sharp points in the vehicle’s unassembled state, or by electrical items. Care should be taken in unpacking and assembly of the vehicle. Children should not handle parts, including the battery, or help in assembly of the vehicle. Guides Steering Linkage Inset 1 Square Opening Vehicle Body Steering Column Bottom View Dash • Position the vehicle body on its side.
Assembly Steering Wheel Cap 5 8 Steering Wheel Radio Knobs Shifter Activity Panel • Fit the steering wheel cap into the center of the steering wheel with the screw holes aligned. • Insert two #8 x 1" screws through the holes in the steering wheel cap and into the steering wheel. • Tighten the screws with a Phillips screwdriver. Do not over-tighten. • From the front of the activity panel, insert and snap the radio knobs.
Assembly 11 Slot Microphone 13 Hole Plastic Tip • Fit the windshield into the windshield frame. • Insert five #6 x 1/2" screws through the holes in the windshield and into the windshield frame. • Tighten the screws with a Phillips screwdriver. Do not over-tighten. 14 • Bend the plastic tip at the end of the microphone cord to form a “T”. • Insert the plastic tip into the small hole in the left side of the vehicle body. Pull gently on the cord to make sure it is secure.
Assembly 16 Hood 18 Grille Sport Bar Sport Bar Cover (BAC) Holes • Lift the hood. • Fit the tabs at the bottom of the grille into the slots in the vehicle body. • Press near the top of the grille to snap it into the vehicle body. • Lower the hood. 17 Grille • With the ends of the sport bar angled toward you, fit the sport bar cover marked “BAC” to the sport bar. • Align the holes in the sport bar with the holes in the sport bar cover.
Assembly 20 22 Sport Bar Seat VRear ehi of cle Taillight Lens Taillight Housing Hole • Using safety scissors, separate the taillight lenses and taillight housings from the plastic connectors. Dispose of the plastic connectors properly. • Fit a taillight lens in a taillight housing. Hole 23 • With the sport bar positioned to angle towards the rear of the vehicle, fit the ends of the sport bar into the holes in the vehicle body on either side of the seat.
Assembly 24 25 Traction Band Battery Clamp (Engine Cover) Spark Plug Wire Set Spark Plug Wire End Ridge Wheel Hole Bottom View • Turn the vehicle on its side. • Fit a traction band around a wheel. • Slide a slotted screwdriver under the traction band to push the traction band onto the ridge in the center of the wheel. Hint: If the traction band is difficult to fit around the wheel, you may want to soak it in warm water to soften it slightly.
G Label Decoration Proper label application will help to keep the labels looking their best! Keep the following guidelines in mind when applying labels: • Wash your hands before applying the labels. • Before applying the labels, wipe the surface of the vehicle with a clean, dry cloth to remove any dust or oils. • Place the labels exactly as shown in these illustrations. • For best results, avoid repositioning a label once it has been applied to the vehicle.
H Battery Installation and Battery Clamp (Engine Cover) Assembly IMPORTANT! Use only a Power Wheels® Type H 6 Volt battery with a Power Wheels® 25 Amp fuse installed. Use of any other battery or fuse will damage your vehicle. Make sure that you charge the battery for at least 18 hours using the enclosed Power Wheels® Type H 6 Volt charger before operating your vehicle for the first time. Charge the battery for at least 14 hours after each use of the vehicle. Never charge the battery longer than 30 hours.
I Battery Care and Disposal Care Disposal If a battery leak develops, avoid contact with the leaking acid and place the damaged battery in a plastic bag. See information below for proper disposal. If acid comes in contact with skin or eyes, flush with cool water for at least 15 minutes and call a physician. If acid is internally ingested, give water, milk of magnesia or egg whites immediately. Never give emetics or induce vomiting. Call a physician.
J Rules for Safe Driving RIDING HAZARD WARNING Prevent Injuries and Deaths • Direct Adult Supervision Required • Keep Children Within Safe Riding Areas These areas must be: - away from swimming pools and other bodies of water to prevent drownings - generally level to prevent tipovers - away from steps, driveways, roads and alleys.
K L How to Operate Your Vehicle FWD 11 11 2 11 3 1 To Drive • Push the top button (FWD) on the FORWARD/REVERSE switch to drive forward 1 . • Press down on the foot pedal 2 . The vehicle will go forward at a maximum of 21/2 mph 3 . • Help your child practice steering to learn how far and how quickly to turn the steering wheel when driving forward.
M Problems and Solutions Guide IMPORTANT! If you experience a problem with your vehicle, first check the Problems and Solutions Guide below. If you still experience a problem, please contact Power Wheels® Consumer Relations, toll-free at 1-800-348-0751 between 8 AM and 6 PM (EST) Monday through Friday. Or, contact your local Power Wheels® authorized service center. For the location nearest you, please refer to the Authorized Service Center list beginning on page 25.
Problems and Solutions Guide Problem Vehicle was running but suddenly stopped Short run time Possible Cause Solution Loose wire or loose connectors Check all wires and connectors. Make sure the battery connector is tightly plugged into the motor harness connector, and that there are no loose wires around the motors. Wrong type or improperly installed fuse Make sure that the battery has a properly installed Power Wheels® 25 amp fuse before charging. Do not substitute parts.
Problems and Solutions Guide Problem Vehicle runs sluggishly Possible Cause Undercharged battery Solution Charge the battery. A new battery should have been charged for at least 18 hours before using the vehicle for the first time. After first-time use, recharge the battery for at least 14 hours after each use. Never charge the battery longer than 30 hours. Check all connectors. Make sure the battery connector is tightly plugged into the charger connector, and that the charger is plugged into the wall.
Problems and Solutions Guide Problem Vehicle constantly blows fuses Possible Cause Solution Wrong type of fuse used Your vehicle requires a Power Wheels® 25 amp fuse in the battery. Make sure the Power Wheels® 25 amp fuse is properly installed. Do not substitute parts. Child is switching between FORWARD and REVERSE without stopping. Teach your child to stop the vehicle before switching between FORWARD and REVERSE.
N Bumper-to-Bumper* Limited Warranty *One year limited warranty from the date of purchase on the Power Wheels® vehicle. Six month limited warranty on 6 volt battery. For the original purchaser, this one year limited warranty covers the Power Wheels® ride-on vehicle (purchased from Power Wheels®) against defects in materials and work-manship. The six month limited warranty applies only to the 6 volt battery included by Power Wheels® with the original purchase of the vehicle.
O Authorized Service Centers We are continually expanding our Authorized Service Center Network. Please check this listing for the Authorized Service Center nearest you. If there is not one in your area, please call Power Wheels® Consumer Relations at 1-800-348-0751. ALABAMA BIRMINGHAM - Frigid Service & Sales, 701 Graymont Ave. North, 35203, (205) 323-5831 BIRMINGHAM - Frigid Service & Sales, 1861 Centerpoint Rd., 35215, (205) 853-3952 BIRMINGHAM (HOMEWOOD) - Frigid Appliance Center, 154 West Valley Ave.
Authorized Service Centers SPRING HILL - National Floor Care, 5588 Commercial Way, 34606, (352) 686-6711, (800) 245-1946 DECATUR - Rexx Battery of Decatur, Inc., 1330 East Eldorado, 62521, (217) 422-0281 MARSHALLTOWN - Blink Electric Motors, Inc., Rear 116 N 1st Avenue, 50158, (515) 752-3036 ST. PETERSBURG - Keystone Electric, 4604 Central Avenue, 33711, (813) 321-1124 FAIRVIEW HEIGHTS - Rapid Rentals, 720 L:incoln Highway, 62087, (618) 632-0630 NORTH LIBERTY - Ace Electric, Inc.
Authorized Service Centers MARYLAND ABERDEEN - Burkheimer Garden Equipment, 651 Gilbert Road, 21001, (410) 734-4577 BALTIMORE - Colgate Hardware, 6711 Holabird Ave., 21222, (410) 633-6363 BERLIN - Myers Auto-Power Tool Rental Co., Inc., 10714 Ocean Gateway, 21811, (410) 641-3497 GAITHERSBURG - Waters Appliance Service, 216 E. Diamond Avenue, 20877, (301) 258-7500, (800) 225-5009 GLEN BURNIE - Taylor Rental, 7389 Baltimore Annapolis Blvd.
Authorized Service Centers MONTICELLO - Wayne’s Small Engine, 79 St.
Authorized Service Centers WINNER - Nelson’s Electronics Inc., 422 West 2nd Street P.O. Box 369, 57580, (605) 842-1611, (888) 842-1699 TENNESSEE CHATTANOOGA - Consumer Service Company, 2607 E. 47th Street, 37407, (423) 867-8629 DANDRIDGE- Save More Sales, 1291 W Hwy 25-70, 37725, (865) 397-1255 UTAH OREM - The Mending Shed, 1735 South State Street, 84058, (801) 225-8012, (800) 339-9297 SALT LAKE CITY - Appliance Service Center, Inc.
IMPORTANT! DO NOT use this vehicle for the first time until you have charged the battery for 18 hours. Remember to… ✔ Insert a 25 amp fuse (included) into the battery. ✔ Charge the battery immediately after each use. ✔ Charge the battery once a month during storage, even if the vehicle has not been used. Failure to follow these instructions will permanently damage your battery and void your warranty. Please refer to the Battery Care Section in this manual for more information.