SDS

Swift Response LLC.
MATERIAL SAFETY DATA SHEET
FLEX SEAL Liquid Rubber Sealant Coating
COMPLIES WITH OSHA’S HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200)
Product Name:
FLEX SEAL Liquid Rubber Sealant Coating
Product Number:
FS101
Date Prepared:
6/1/2011
Product Type:
AEROSOL
Date Printed:
6/23/2011
Formula:
Proprietary
Information Phone: [phone]
2
Supplier's Name:
Swift Response LLC.
Emergency Phone: [phone]
3
Supplier's Address:
454 NW 118th Ave,Coral Springs, FL 33071
0
DOT Ship Description:
CONSUMER COMMODITY, ORM-D
C
CHEMICAL NAME
CAS #
%WT
313/Chem
Skin
Carcinogen
PEL
TWA/TLV
0
0
0
0
0
0
0
0
Toluene
108-88-3
20-30
YES
NO
NO
100 ppm
100 ppm
Aliphatic Petroleum Distillate
8052-41-3
10-20
NO
NO
NO
500 ppm
100 ppm
Aliphatic Petroleum Solvent
64742-89-8
5-15
NO
NO
NO
300 ppm
300ppm
Calcium Carbonate
1317-65-3
1-10
NO
NO
NO
15 mg/m3*
10 mg/m3*
Carbon Black
1333-86-4
1-10
NO
NO
IARC 2B
3.5 mg/m3*
N/E
0
0
0
0
0
0
0
0
Liquefied Petroleum Gas
68476-86-8
20-40
NO
NO
NO
1000 ppm
1000 ppm
0
0
0
0
0
0
0
0
*exposure limits are for dust only.
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
Boiling Point:
>230°F
Specific Gravity (H2O=1)@70°F:
0.94
pH:
N/A
Solubility In Water:
Insoluble
Appearance/Odor:
Viscous, black liquid with solvent odor
Vapor Density(Air=1):
>1
Total VOC %:
70.13%
Vapor Pressure (can; psig @72°F):
45
Flash Point (Conc.):
60°F (T.O.C.)
Flammability (as per CSMA Flame Projection Test):
Extremely-Flammable Spray
Extinguishing Media:
Foam, CO2, Dry Media
Stability:
Material Stable.
Hazardous Polymerization:
Will not Occur.
KEEP OUT OF REACH OF CHILDREN.
NFPA Code 30B Rating:
Level 3 Aerosol.
For Industrial and Institutional use only.
0
Store in a cool, dry area away from heat or open flame.
0
Do not store at temperatures above 120° F.
0
PRIMARY ROUTES OF ENTRY & EFFECTS OF OVER EXPOSURE:
FIRST AID PROCEDURES:
SECTION I · PRODUCT IDENTIFICATION
HMIS Rating (Based on Aerosol Conc.):
0-Minimal 1-Slight 2-Moderate
3-Serious 4-Extreme
HEALTH:
FLAMMABILITY:
PHYSICAL HAZARD:
Personal Protection:
SECTION II · INGREDIENTS
SECTION III · PHYSICAL DATA
Aerosol Concentrate:
Total Contents:
SECTION IV · FIRE AND EXPLOSION DATA
Special Fire Fighting Procedures: Wear self-contained breathing apparatus and protective clothing. Cool fire exposed containers to prevent rupturing.
Unusual Fire and Explosion Hazards: Exposure to temperature above 120° F may cause bursting.
SECTION V · REACTIVITY DATA
Incompatibility: Avoid contact with strong oxidizing agents.
Hazardous Decomposition Products: Carbon Dioxide, Carbon Monoxides.
SECTION VI · STORAGE AND HANDLING
SECTION VII · HEALTH AND FIRST AID
Eyes: May cause severe irritation accompanied by stinging, tearing, and redness.
Skin: Frequent or prolonged contact may cause irritation possibly leading to dermatitis. May aggravate existing skin conditions.
Inhalation: Inhalation of mist can cause irritation of nasal and respiratory passages. Prolonged or repeated inhalation may cause irritation to the upper respiratory tract,
dizziness, nausea, headache, and other central nervous system effects. Abusive overexposure may cause liver abnormalities, kidney damage, lung damage, and spleen
Ingestion: Can cause gastrointestinal irritation, nausea, vomiting and diarrhea. Aspiration of material into the lungs can cause severe lung injury.
Eyes: Flush with large amounts of cool running water for at least 15 minutes while holding upper and lower lids open. If irritation persists get medical attention immediately.
Skin: Wash with soap and water. If irritation persists seek medical attention.
Inhalation: Remove to fresh air. Seek medical attention immediately. If breathing stops give artificial respiration.
Ingestion: Do not induce vomiting. Seek medical attention immediately.