® TIO A M R NFO I T TA N se R nce O I M P efore u re refere b tu Read in for fu ta & re N INSTRUCTION MANUAL Mini-Trim
1 Carton Contents CONTENTS A 1 Pack of Spare Cutting Lines Electric Cable with moulded on plug Scraper Tool Instruction Manual Guarantee Card LIST OF INSTRUCTION MANUAL CONTENTS CONTENTS (1) SAFETY (2-4) USE (5-8) MAINTENANCE (9-10) GUARANTEE (11) CERTIFICATE OF CONFORMITY (12) & INSIDE BACK COVER IMPORTANT ! Please check the contents of the carton are correct BEFORE assembling your new Flymo product.
2 If not used properly this trimmer can be dangerous! This trimmer can cause serious injury to the operator and others, the warnings and safety instructions must be followed to ensure reasonable safety and efficiency in using this trimmer. The operator is responsible for following the warning and safety instructions in this manual and on the trimmer. Explanation of Symbols on the Mini-Trim SAFETY Warning Read the user instructions carefully to make sure you understand all the controls and what they do.
3 10. Avoid possible injuries to feet and hands from rotating cutting line. Always start the trimmer carefully with feet and hands well away from the cutting head. 11. Never pick up or carry a trimmer by the cable. 12. Do not lean over the trimmer guard objects may be thrown by the cutting line. 13. Remove the plug from the mains : SAFETY 7. Do not pull cable around sharp objects. 8. Always switch off at the mains before disconnecting any plug, cable connector or extension cable. 9.
4 CABLES IMPORTANT • Use only 1.00mm2 size cable up to 30 metres length maximum for trimmers and 60 metres length maximum for lawnmowers. Maximum rating: 1.00mm2 size cable, 10 amps 250 volts AC. 1. Flymo products are supplied with either an electric mains cable fitted with a female connector or with an electric mains cable wired directly into the product. THE MINI-TRIM IS SUPPLIED WITH AN ELECTRIC MAINS CABLE WIRED DIRECTLY INTO THE PRODUCT. SAFETY 2.
5 Product Rating Label B Your product is uniquely identified by a silver and black product rating label. To ensure you have full product information when obtaining spares or advice from one of our approved service centres, or if you need to contact our customer service department, you should make a note in the space provided of the information shown in fig.B. It will also be useful to make a note of the date and place of purchase before you return your guarantee card. Product Number . . . . . . . . . . . .
6 How to trim D • WARNING The use of eye protection is recommended. Do not lean over the trimmer guard whilst trimming, objects may be thrown by the cutting line. Do not allow cutting head to rest on the ground. Do not overload your trimmer. Overloading can be avoided by making sure the motor speed does not drop unduly. USE E Disconnect from the mains electricity supply before attempting any maintenance or adjustment. 1. Cut with cutting line at an angle using the tip. 2.
7 Removing the Cutting Line F 20 m m • WARNING 20 Disconnect from the mains electricity supply, before attempting any maintenance or adjustment. Cutting head continues to rotate after the trimmer has been switched off. m m G Removing broken or worn cutting line. Using the pip in the centre of the line, pull the line upwards and out of the cutting head. (Fig G) USE For best results, replace the cutting line when worn to no less than 20 mm from the edge of the cutting head.
8 Replacing the Cutting Line H Insert one end of the cutting line into the centre of the cutting head and push until the end of the line comes out at one end of the slot. (Fig. H) J Secure the centre piece of the cutting line into the centre of the cutting head and guide the other side of the cutting line along the slot until it is securely located as illustrated in Fig. J. USE Storing the spare cutting lines.
9 Caring for your Trimmer • WARNING Disconnect from the mains electricity supply, before attempting any maintenance or adjustment. Cutting head continues to rotate after the trimmer has been switched off. L After you have finished using your Flymo Trimmer follow the procedure below: 1. Disconnect from the mains electricity supply. M 2. Never clean your trimmer with water, cleaning fluids, or solvents, just remove debris with a suitable tool, a soft brush or dry cloth. 3.
10 Fault Finding Hints & Service Recommendations Fault Finding Hints Fails To Operate 1. Is the power turned on? 2. Check the fuse in the plug, if blown, replace. 3. Fuse continues to blow? Immediately disconnect from the mains electricity supply and consult your local approved Service Centre Poor Trimming. 1. Check length of line. If broken or worn to less than 20mm from the edge of the cutting head, replace line. See Removing & Replacing cutting line, page 7 & 8. 2.
11 Guarantee & Guarantee Policy Guarantee & Guarantee Policy If any part is found to be defective due to faulty manufacture within one year of original purchase, Flymo/Partner, through its Authorised Service Repairers will effect the repair or replacement to the customer free of charge providing: (a) The fault is reported directly to the Authorised Repairer. (b) Proof of purchase is provided. (c) The fault is not caused by misuse, neglect or faulty adjustment by the user.
12 Environmental Information Electrolux Outdoor Products are manufactured under an Environmental Management System (ISO 14001) using, where practical, components manufactured in the most environmentally responsible manner, according to company procedures, and with the potential for recycling at the end of the products’ life. • Packaging is recyclable and plastic components have been labelled (where practical) for categorised recycling.
Certificate of Conformity I, THE UNDERSIGNED: P. HOWELLS OF ELECTROLUX OUTDOOR PRODUCTS, AYCLIFFE INDUSTRIAL ESTATE, NEWTON AYCLIFFE, COUNTY DURHAM DL5 6UP ENGLAND Certify that the Trimmer 1. Category . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Electric 2. Make . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Flymo Conforms to the specifications of Directive 84/538/EEC Type of Cutting Device . . . . . . .
The use of eye protection is recommended to protect against objects thrown by the cutting line. Flymo Safety Glasses are available from most leading stockists GUIDE PRICE ONLY £3.49 GUIDE PRICE ONLY £3.49 Contact your nearest stockist or telephone (01325) 300303 for more details Electrolux Outdoor Products Aycliffe Industrial Estate NEWTON AYCLIFFE Co.
