2009 Model Year Scheduled Maintenance Guide Vehicle Identification Number (VIN): Owner Name: Address: All rights reserved. Reproduction by any means, electronic or mechanical including photocopying, recording or by any information storage and retrieval system or translation in whole or part is not permitted without written authorization from Ford Motor Company. Ford may change the contents without notice and without incurring obligation.
FIND YOUR WAY Today’s vehicles are more sophisticated than ever and need to be properly maintained to help ensure they operate at the highest level. Additional Information Available on the Web @ www.genuineservice.com For lots of helpful tips and information on operating, maintaining, and servicing your Ford, Lincoln, or Mercury vehicle, visit www.genuineservice.com.
FIND YOUR WAY General Owner’s Information Table of Contents General Owner’s Information . . . . . . . . . . . . . . . . . . . . . . . . .2 General Maintenance Information . . . . . . . . . . . . . . . . . . . . . .4 Owner Checks and Services . . . . . . . . . . . . . . . . . . . . . . . . . .8 Keep It Genuine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9 Multi-Point Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GENERAL MAINTENANCE INFORMATION Get the most from your vehicle with routine maintenance Routine maintenance is the best way to help ensure you get the performance, dependability, long life and resale value you expect from your vehicle. This is exactly why we’ve put together the Scheduled Maintenance Guide. It outlines the services required to properly maintain your vehicle and when they should be performed.
GENERAL MAINTENANCE INFORMATION see appropriate schedule on page 42. Motorcraft Premium Gold Engine Coolant ❑ 6 years or 105,000 miles - change Premium Gold coolant (whichever comes first) ❑ After initial change - change Premium Gold coolant every 3 years or 45,000 miles (see page 49) Determine which maintenance schedule to follow It’s important to follow the maintenance schedule that most closely mirrors your driving habits and the conditions under which you drive.
GENERAL MAINTENANCE INFORMATION Exceptions Some exceptions for specific vehicles and special applications are outlined below. In addition, you will find further information under Exceptions on page 48. • Engine oil and Motorcraft Premium Gold Engine Coolant - time and mileage based interval If you’re unsure which maintenance schedule to follow, ask your Ford and Lincoln Mercury Dealership, or visit the Maintenance area of www.genuineservice.com.
GENERAL MAINTENANCE INFORMATION There are a lot of reasons why visiting your Ford or Lincoln Mercury Dealership for all your service needs is a great way to help keep your vehicle running great. Convenience Many Dealerships have extended evening and Saturday hours to make your service visit more convenient.
OWNER CHECKS AND SERVICES It is recommended that the following basic maintenance checks and inspections be performed at the designated time intervals. See your “Owner’s Guide” for more information. Check every month for all vehicles ❑ ❑ ❑ ❑ Check Check Check Check function of all interior and exterior lights. tires for wear and proper air pressure, including spare. engine oil fluid level. windshield washer fluid level.
KEEP IT GENUINE Factory Authorized Systems Checks In the event your vehicle experiences a component related concern, please contact your Ford, Lincoln or Mercury dealership. The Ford Motor Company Trained Technicians who work at Ford, Lincoln or Mercury dealerships are specifically trained to understand your vehicle. A proper repair begins with a thorough system check. Factory Authorized Systems Checks can ONLY be found at a Ford or Lincoln Mercury dealership.
KEEP IT GENUINE Tires Proper tire maintenance and replacement are critical to your vehicle’s performance and helps keep you and your passengers safe. Only use replacement tires and wheels that are the same size, load index, speed rating and type (such as P-metric versus LT-metric or all-season versus all-terrain) as those originally provided by Ford.
KEEP IT GENUINE Batteries Brakes Your Ford or Lincoln Mercury Dealership has the right brake parts for your vehicle and their factory-trained technicians know exactly how to install them. Ford Original Equipment and Motorcraft replacement brake pads, shoes, rotors and drums meet the stringent standards of Ford Motor Company engineers, and they’re also Federal Motor Vehicle Safety Standard (FMVSS) compliant.
KEEP IT GENUINE Oil & Lubricants It is important to follow a regular maintenance schedule for changing your vehicle’s oil and lubricants. Motorcraft Oils and Lubricants meet the stringent standards set by Ford Motor Company. Motorcraft Oils are formulated to reduce engine friction, improve fuel economy, and protect against deposits and wear. The American Petroleum Industry certifies them, so you know Motorcraft oil stands up to the tests of both Ford and independent engineers.
MULTI-POINT INSPECTION Parts Genuine Ford Collision Parts are designed, engineered, and warranted by Ford Motor Company. See your dealer for limited warranty details. They are manufactured to the same specifications as those on your vehicle when it was built. The right replacement parts will help maintain the value of your vehicle.
MULTI-POINT INSPECTION Be sure to ask your Ford or Lincoln Mercury Dealership Service Advisor or Technician about the multi-point vehicle inspection. It’s a comprehensive way to perform a thorough inspection of your vehicle. It’s your checklist that gives you immediate feedback on the overall condition of your vehicle. You’ll know what’s been checked, what’s okay, as well as those things that may require future or immediate attention.
NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 7,500 miles ❑ Change engine oil and replace oil filter ❑ Rotate tires, inspect tires for wear and measure ❑ ❑ DEALER VALIDATION: tread depth (vehicles with dual rear wheels should only rotate if unusual wear is noted) Inspect the wheels and related components for abnormal noise, wear, looseness, or drag Perform multi-point inspection (recommended) RO#: P&A CODE: DATE: MILEAGE: 15,000 miles ❑ Change engine oil and replace oil filter ❑ Replace cabin air fi
NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS Tires When your tires need to be replaced, consider visiting your Ford or Lincoln Mercury dealership for name-brand tires and people who know your vehicle. And if your Ford or Lincoln Mercury dealership sells the name-brand tire, they can also honor the tire manufacturer’s warranty.
NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 30,000 miles ❑ Change engine oil and replace oil filter ❑ Inspect automatic transmission fluid level on ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ DEALER VALIDATION: RO#: P&A CODE: DATE: MILEAGE: Normal Schedule Trucks, Fullsize Vans & SUVs ❑ ❑ ❑ ❑ vehicles if equipped with dipstick. Consult your dealer for particular requirements.
NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS Oil & Lubricants It is important to stick to a regular maintenance schedule for changing your vehicle’s oil and lubricants. Motorcraft Oils and Lubricants meet the stringent standards set by Ford Motor Company. Motorcraft Oils are formulated to reduce engine friction, improve fuel economy, and protect against deposits and wear. The American Petroleum Industry certifies them, so you know Motorcraft oil stands up to the tests of both Ford and independent engineers.
NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS Batteries The technicians at your Ford and Lincoln Mercury dealership can determine the health of your vehicle’s battery during any service visit. The Motorcraft Tested Tough Max Series with its “long-life” design outlasted other long-life batteries by up to 200%. That’s one reason why we stand behind this battery with a national 3 year, free-replacement and prorated-cost thereafter up to 100 months with unlimited mileage.
NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 52,500 miles ❑ Change engine oil and replace oil filter ❑ Rotate tires, inspect tires for wear and measure ❑ ❑ DEALER VALIDATION: tread depth (vehicles with dual rear wheels should only rotate if unusual wear is noted) Inspect the wheels and related components for abnormal noise, wear, looseness, or drag Perform multi-point inspection (recommended) RO#: P&A CODE: DATE: MILEAGE: 60,000 miles ❑ Change engine oil and replace oil filter ❑ Change automatic tr
NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS Brakes Technicians at your Ford or Lincoln Mercury dealer can install the right brake parts for your vehicle. Ford Original Equipment and Motorcraft replacement brake pads, shoes, rotors, and drums meet the stringent standards of Ford Motor Company engineers.
NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 75,000 miles ❑ Change engine oil and replace oil filter ❑ Replace cabin air filter (if equipped) ❑ Inspect steering linkage, ball joints, suspension, ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ tie rod ends, driveshaft, and U-joints (lubricate if equipped with Zerk fittings) Inspect engine cooling system and hoses Inspect brake pads, shoes, rotors, drums, brake lines and hoses and parking brake system.
NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 90,000 miles ❑ Change engine oil and replace oil filter ❑ Inspect automatic transmission fluid level on ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ DEALER VALIDATION: RO#: P&A CODE: DATE: MILEAGE: 97,500 miles ❑ ❑ ❑ ❑ Change engine oil and replace oil filter Rotate tires, inspect tires for wear and measure tread depth (vehicles with dual rear wheels should only rotate if unusual wear is noted) Inspect the wheels and related components for abnormal noise, wear, looseness, or dr
NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 105,000 miles ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ Change engine oil and replace oil filter Change manual transmission fluid (except Escape) Replace cabin air filter (if equipped) Replace PCV valve on all light trucks under 6,000 lbs.
NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 120,000 miles ❑ Change engine oil and replace oil filter ❑ Replace cabin air filter (if equipped) ❑ Replace climate-controlled seat filters (if equipped) ❑ Replace engine air filter ❑ Replace fuel filter (except Escape, Mariner, ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ DEALER VALIDATION: RO#: P&A CODE: DATE: MILEAGE: Scheduled Maintenance 25 2009 Scheduled Maintenance Guide (smg) Scheduled Maintenance Guide, 2nd Printing USA (fus) Normal Schedule Trucks, Fullsize Van
NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 127,500 miles ❑ Change engine oil and replace oil filter ❑ Rotate tires, inspect tires for wear and measure ❑ ❑ DEALER VALIDATION: tread depth (vehicles with dual rear wheels should only rotate if unusual wear is noted) Inspect the wheels and related components for abnormal noise, wear, looseness, or drag Perform multi-point inspection (recommended) RO#: P&A CODE: DATE: MILEAGE: 135,000 miles ❑ Change engine oil and replace oil filter ❑ Replace cabin air
NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 142,500 miles ❑ Change engine oil and replace oil filter ❑ Rotate tires, inspect tires for wear and measure ❑ ❑ DEALER VALIDATION: tread depth (vehicles with dual rear wheels should only rotate if unusual wear is noted) Inspect the wheels and related components for abnormal noise, wear, looseness, or drag Perform multi-point inspection (recommended) RO#: P&A CODE: DATE: MILEAGE: Tires When your tires need to be replaced, consider visiting your Ford or Lin
NORMAL SCHEDULE TRUCKS, FULLSIZE VANS & SUVS 150,000 miles ❑ Change engine oil and replace oil filter ❑ Change Motorcraft Premium Gold Engine Coolant ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ (see Exceptions on page 48 and Premium Gold Coolant Change Record on page 49) Replace cabin air filter (if equipped) Replace climate-controlled seat filter (if equipped) Replace engine air filter Replace fuel filter (except Escape, Mariner, F-Series [non Super Duty], Expedition/Navigator [short wheel base only], E-Se
NORMAL SCHEDULE CARS & CUVS Brakes Technicians at your Ford or Lincoln Mercury dealer can install the right brake parts for your vehicle. Ford Original Equipment and Motorcraft replacement brake pads, shoes, rotors, and drums meet the stringent standards of Ford Motor Company engineers. In addition, all Ford Original Equipment replacement brake pads, shoes, rotors, and drums are vehicle tested for durability and noise suppression while being Federal Motor Vehicle Safety Standard (FMVSS) compliant.
NORMAL SCHEDULE CARS & CUVS 15,000 miles ❑ Change engine oil and replace oil filter ❑ Replace cabin air filter (if equipped) ❑ Inspect and lubricate steering linkage, ball joints, ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ suspension, tie rod ends, driveshaft and U-joints (lubricate if equipped with Zerk fittings) Inspect engine cooling system and hoses Inspect brake pads, shoes, rotors, drums, brake lines and hoses and parking brake system.
NORMAL SCHEDULE CARS & CUVS 22,500 miles ❑ Change engine oil and replace oil filter ❑ Rotate tires, inspect tires for wear and measure ❑ ❑ DEALER VALIDATION: tread depth Inspect the wheels and related components for abnormal noise, wear, looseness, or drag Perform multi-point inspection (recommended) RO#: P&A CODE: DATE: MILEAGE: 30,000 miles ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ DEALER VALIDATION: RO#: P&A CODE: DATE: MILEAGE: Scheduled Maintenance 31 2009 Scheduled Maintenance Guide (smg) Scheduled Maint
NORMAL SCHEDULE CARS & CUVS 37,500 miles ❑ Change engine oil and replace oil filter ❑ Rotate tires, inspect tires for wear and measure ❑ ❑ DEALER VALIDATION: tread depth Inspect the wheels and related components for abnormal noise, wear, looseness, or drag Perform multi-point inspection (recommended) RO#: P&A CODE: DATE: MILEAGE: 45,000 miles ❑ Change engine oil and replace oil filter ❑ Replace cabin air filter (if equipped) ❑ Inspect and lubricate steering linkage, ball joints, ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ su
NORMAL SCHEDULE CARS & CUVS Batteries The technicians at your Ford and Lincoln Mercury dealership can determine the health of your vehicle’s battery during any service visit. The Motorcraft Tested Tough Max Series with its “long-life” design outlasted other long-life batteries by up to 200%. That’s one reason why we stand behind this battery with a national 3 year, free-replacement and prorated-cost thereafter up to 100 months with unlimited mileage.
NORMAL SCHEDULE CARS & CUVS 60,000 miles ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ Change engine oil and replace oil filter Replace climate-controlled seat filter (if equipped) Replace cabin air filter (if equipped) Replace engine air filter (except Focus with PZEV engine) Replace fuel filter (Crown Victoria, Grand Marquis, Town Car and Mustang) Inspect and lubricate steering linkage, ball joints, suspension, tie rod ends, driveshaft and U-joints (lubricate if equipped with Zerk fittings) Inspect engine cooling system
NORMAL SCHEDULE CARS & CUVS 75,000 miles ❑ Change engine oil and replace oil filter ❑ Replace cabin air filter (if equipped) ❑ Inspect and lubricate steering linkage, ball joints, ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ suspension, tie rod ends, driveshaft and U-joints (lubricate if equipped with Zerk fittings) Inspect engine cooling system and hoses Inspect brake pads, shoes, rotors, drums, brake lines and hoses and parking brake system.
NORMAL SCHEDULE CARS & CUVS 90,000 miles ❑ Change engine oil and replace oil filter ❑ Replace climate-controlled seat filter (if equipped) ❑ Replace engine air filter (except Focus with PZEV engine) ❑ Replace cabin air filter (if equipped) ❑ Replace fuel filter (Crown Victoria, Grand Marquis, Town Car and Mustang) ❑ Replace spark plugs ❑ Inspect and lubricate steering linkage, ball joints, ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ suspension, tie rod ends, driveshaft and U-joints (lubricate if equipped with Zerk fittings) Insp
NORMAL SCHEDULE CARS & CUVS 105,000 miles ❑ Change engine oil and replace oil filter ❑ Change Motorcraft Premium Gold Engine Coolant ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ (see Exceptions on page 48 and Premium Gold Coolant Change Record on page 49) Replace cabin air filter (if equipped) Replace PCV valve (except 3V engines) Inspect and lubricate steering linkage, ball joints, suspension, tie rod ends, driveshaft and U-joints (lubricate if equipped with Zerk fittings) Inspect engine cooling system and hoses Inspect brake
NORMAL SCHEDULE CARS & CUVS 120,000 miles ❑ Change engine oil and replace oil filter ❑ Replace climate-controlled seat filter (if equipped) ❑ Replace engine air filter (except Focus with PZEV engine) ❑ Replace cabin air filter (if equipped) ❑ Replace fuel filter (Crown Victoria, Grand Marquis, Town Car and Mustang) ❑ Inspect and lubricate steering linkage, ball joints, ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ suspension, tie rod ends, driveshaft and U-joints (lubricate if equipped with Zerk fittings) Inspect engine cooling sy
NORMAL SCHEDULE CARS & CUVS Oil & Lubricants It is important to stick to a regular maintenance schedule for changing your vehicle’s oil and lubricants. Motorcraft Oils and Lubricants meet the stringent standards set by Ford Motor Company. Motorcraft Oils are formulated to reduce engine friction, improve fuel economy, and protect against deposits and wear. The American Petroleum Industry certifies them, so you know Motorcraft oil stands up to the tests of both Ford and independent engineers.
NORMAL SCHEDULE CARS & CUVS 135,000 miles ❑ Change engine oil and replace oil filter ❑ Replace cabin air filter (if equipped) ❑ Inspect and lubricate steering linkage, ball joints, ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ suspension, tie rod ends, driveshaft and U-joints (lubricate if equipped with Zerk fittings) Inspect engine cooling system and hoses Inspect brake pads, shoes, rotors, drums, brake lines and hoses and parking brake system.
NORMAL SCHEDULE CARS & CUVS 150,000 miles ❑ Change engine oil and replace oil filter ❑ Change Motorcraft Premium Gold Engine Coolant ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ ❑ DEALER VALIDATION: RO#: P&A CODE: DATE: MILEAGE: Normal Schedule Cars & CUVs ❑ ❑ ❑ (see Exceptions on page 48 and Premium Gold Coolant Change Record on page 49) Change automatic transmission fluid Replace automatic transmission fluid filter (except 6F50, AWF-21 and FNR5 transaxles) Change manual transmission fluid Replace rear axle lubrica
SPECIAL OPERATING CONDITIONS Items Needing Special Attention If you operate your Ford/Lincoln/Mercury primarily in one of the more demanding Special Operating Conditions listed below, you will need to have some items maintained more frequently. If you only occasionally operate your vehicle under these conditions, it is not necessary to perform the additional maintenance. For specific recommendations, see your Ford or Lincoln Mercury Dealership Service Advisor or Technician.
SPECIAL OPERATING CONDITIONS Extensive idling and/or low-speed driving for long distances as in heavy commercial use such as delivery, taxi, patrol car or livery Every 5,000 miles Inspect brake system Rotate tires, inspect tires for wear and measure tread depth Inspect the wheels and related components for abnormal noise, wear, looseness, or drag Lubricate control arm and steering ball joints (if equipped with zerk fittings) Every 5,000 miles or 6 months Inspect and lubricate U-joints Every 5,000 miles, 6 m
SPECIAL OPERATING CONDITIONS Crown Victoria Police Interceptor & Taxi, and Executive Series Town Car equipped with Engine Idle Hour Meter Every 5,000 miles Inspect brake system Rotate tires, inspect tires for wear and measure tread depth Inspect the wheels and related components for abnormal noise, wear, looseness, or drag Lubricate control arm and steering ball joints (if equipped with zerk fittings) Every 5,000 miles or 6 months Inspect and lubricate U-joints Every 5,000 miles, 6 months or Change engine o
SPECIAL OPERATING CONDITIONS Example: When the odometer has accumulated 3,000 miles and the idle meter shows 61 hours, a 5,000 mile oil change interval will have been reached: 3,000 road miles + (61 idle hours x 33 miles/idle hour) = 5,013 miles.
SPECIAL OPERATING CONDITIONS Off-road operation Every 5,000 miles or 6 months Change engine oil and replace oil filter Rotate tires, inspect tires for wear and measure tread depth Inspect the wheels and related components for abnormal noise, wear, looseness, or drag Every 30,000 miles Change automatic transmission/transaxle fluid (not required on 6R60/6R75/TorqShift transmissions) Replace wheel bearing grease and grease seals on 4x2 front wheel bearings (if non-sealed bearings) Every 50,000 miles Change man
SPECIAL OPERATING CONDITIONS Special Operating Conditions Log DEALER VALIDATION: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER VALIDATION: RO#: DATE: P&A CODE: MILEAGE: DEALER VALIDATION: P&
EXCEPTIONS In addition, there are several exceptions to the Normal Schedule. They are listed below: Normal Vehicle Axle Maintenance ❑ Rear axles and power take off (PTO) units containing synthetic lubricant and light duty trucks equipped with Ford-design axles are lubricated for life. These lubricants are not to be checked or changed unless a leak is suspected, service is required or the axle assembly has been submerged in water.
PREMIUM GOLD COOLANT CHANGE RECORD Current mileage goes here => Add 45,000 miles to the current miles + 45,000 Next change due at this mileage => Or Today’s date goes here => Add 3 years + 00 / 00 / 03 Date of next change => whichever comes first Dealer Stamp Current mileage goes here => Add 45,000 miles to the current miles + 45,000 Next change due at this mileage => Or Today’s date goes here => Add 3 years + 00 / 00 / 03 Date of next change => whichever comes first Dealer Stamp Current mileage goes he