COVE BY PASS FOREMOST Customer Service 1-888-620-3667 GORY THE MODEL NUMBER FOR YOU RECORDS HERE # Please visit us on YouTube and view our shower door installation videos. One may be available for your installation. READ THE INSTRUCTIONS CAREFULLY, familiarize yourself with all the parts as shown in the exploded view. The exploded view will also provide a helpful reference when relating to the location of the various parts and how they are mounted. — @2014 Foremost Groups, Inc.
PARTS LIST.
STEP 1 Attach rollers to hanger clips on both panels. Rollers should be mounted so that the head of the mounting screw is on the same side of the panel as the screw head set into the hanger clip (see inset drawing). NOTE: The various holes in the hanger clip are used to fine tune the adjustment of the panel to make up for walls that are slightly out of square or plumb. For best results start with all rollers in the second hole from the top and then make adjustments as needed.
STEP 2 STEP 3 Measure opening on bottom and cut Place wall jamb down over bottom track so that the Bottom track 1/8" shorter than opening. back of the jamb is between the bottom track and the wall. Using a level to insure jamb is plumb, mark hole locations. Remove jamb and drill holes about 1 1/2" deep at each of the marked locations. NOTE: When drilling into ceramic, glass or stone use a 1/4" MASONRY drill bit. When installing on fiberglass or acrylic use a 1/8" drill bit and discard the wall plugs.
COVE BY-PASS FOREMOST Customer Service 1-888-620-3667 STEP 8 Use 1 1/2" screws to anchor wall bumper and bumper guide into center hole on each side. STEP 9 Measure opening at top of wall jamb, cut Top track (1) 1/16" shorter than opening. STEP 10 Place top track down over wall jambs as shown. SIDE VIEW STEP 11 Install outer Door panel by lifting up & into Top track (1) ( Do not lift by toque! bar, be careful not to bump panel against metal track.
COVE BY-PASS FOREMOST Customer Service 1-888-620-3667 STEP 12 Install inner door panel by lifting up & into Top track { Do not lift by towel bar ).
COVE BY-PASS FOREMOST Customer Service 1-888-620-3667 STEP 13 Install Towel bars (3). "\ [—TOWEL BAR SCREW TOWEL BAR WRENCH CLEAR SLEEVE CLEAR SLEEVE 1/8" DRILL BITS ~ 7 SIDE VIEW STEP 14 Position panel guide in center of Bottom track. Drill two 1/8" holes through screw holes in guide and into Bottom track. Position panels in guide as shown in inset drawing and attach guide to bottom track using 3/8" screws.
COVE BY-PASS FOREMOST Customer Service 1-888-620-3667 STEP 15 At last, Install safe slider clip (9). TRIM SAFE SLIDER CLIP IF NECESSARY C J SAFE SLIDER CLIP, CAULK ALL SIDES 240 FINAL STEP: Caulk both sides of the shower door SAFE SLIDER INSTALL ROD frame to seal. Keep the entire area dry fora minimum of 24 hours. Your installation is now complete. Thank you for choosing Foremost shower doors. if you have any questions or require any To install safe slider clip.