Installation Manual

www.fullriverbattery.com Page 15
3. Ifthesetrunsmorethan50%ofitsratedcapacity,thebatteriesaregoodand
the test is complete.
4. Ifthesetrunslessthan50%ofitsratedcapacity,reconnectthedischarger.
Whileunderthedischargeload,recordtheendofthedischargevoltagefor
each battery.
5. Thebatteriesthatare0.5Vlowerthanthehighestendofdischargevoltage
shouldbenoted.
6. Ifthesetdeliveredlessthan50%ofitsratedcapacity,andthesamebatteries
thatwerenotedinSTEP 3 of SECTION 6.2werealsotheonesnotedinSTEP 5
of SECTION 6.3,thosebatteriesaremostlikleyfailedandshouldbereplaced.
FollowthereplacementinstructionsinSECTION 6.5below.
7. Otherwise,pleasecontactyourlocalFullriverBatterydistributortoreview
yourdataindetail..Youcanalsoreachtechnicalsupportbycalling
[phone] or emailing [e-mail].Additionaltesting
mayberequireddependingonyourspecicapplication.
6.4 - OPTIONAL TEST
After completing SECTION 6.1andSECTION 6.2,followthesesteps:
1. Operatethevehicle/equipmentuntilbatteryperformancedecreases.
2. Recordvoltagesduringandafteroperation.
3. Recordtimeanddistanceofoperation.
4. Providethevoltage,timeanddistancedatatoaFullriverBatterydistributoror
to Fullriver Battery techincal support at [phone] or email
[e-mail].
5. Thisdatawillbeanalyzedincomparisontowhatisexpectedofthe
vehicle/equipment.
6.5 - BATTERY REPLACEMENT INSTRUCTIONS
Aslongasitissafetodoso,chargethesetofbatteriesbeforereplacingthefailed
onestomakesurethegoodbatteriesarefullycharged.
Ifpossible,replacefailedbatterieswithgoodbatteriesaroundthesameagefrom
anotherpieceofequipment.Trytoavoidmixingnewbatteriesinequipmentwithold
batteries.Putallnewbatteriesinthesamepieceofequipment.
Forbatteryreplacement,followtheinstallationinstructionsinSECTION 2.
Testing