AGM Sealed 6V 415Ah Manual

800.522.8191 (Toll Free)Page 16
6.6 - BATTERY REPLACEMENT INSTRUCTIONS
Aslongasitissafetodoso,chargethesetofbatteriesbeforereplacingthefailed
onestomakesurethegoodbatteriesarefullycharged.
Ifpossible,replacefailedbatterieswithgoodbatteriesaroundthesameagefrom
anotherpieceofequipment.Trytoavoidmixingnewbatteriesinequipmentwithold
batteries. Put all new batteries in the same piece of equipment.
7.1 - FULLRIVER PRODUCTS
FullriverBatteryproducessealed,maintenance-freebatteriesthatarenon-
hazardous,non-spillable.Duringnormaloperation,ourbatterieswillnotreleaseany
harmfulgasesandwillnotleakanyacidicelectrolyteintotheenvironment.
Fullriverbatteriesareclassiedassafeforair,sea,andgroundtransportation.They
meet all requirements of the International Air Transport Association (I.A.T.A.), the
InternationalCivilAviationOrganization(I.C.A.O.),theInternationalMaritime
DangerousGoods(I.M.D.G.),andtheDepartmentofTransportation(D.O.T.).
Morethan98%oftheleadinbatteriesisrecycled-placinglead-acidbatteriesatthe
topofthelistofmosthighlyrecycledconsumerproducts.Therecyclingloopofa
lead-acidbatterygoesonindenitely.
7.2 - FULLRIVER MANUFACTURING
FullriverBatterymanufacturesbatteriesinaccordancewithinternational
environmentalregulations.Wecontinuallyimproveourprocessinordertominimize
waste,recycleallwastethatisrecyclableanddiscardwastethatisnotrecyclablein
accordancewithlocaldisposalregulations.Westrictlyenforcetheuseofproper
ventilationandprotectivegear.Thisenforcementhelpsminimizeemployee
exposuretoleadatapointwellbelowsuggestedlevels.
7.3 - SOLAR SETTING RECOMMENDATIONS
FullriverBatteryhasasignicantpresenceandhistoryintheresidential,commercial,
andRVsolarmarkets.Fromthishistory,weprovidethefollowingrecommendations
onchargecontrollerandinvertersettings:
7.3.1 - VOLTAGE SETTINGS
Pleaseseetables6&7onPage11forbulk,absorption,andoatvoltage
recommendations.
RebulkVoltageshouldbesetlowenoughtonotcausetwochargecyclesinoneday,
typically12.0,24.0,or48.0V.ReoatVoltageshouldbesetslightlyunder100%OCV
or 12.7, 25.4, or 50.8V.
Testing & Your Clean-Green Energy Solution