MSDS

MATERIAL SAFETY DATA SHEET
NPCA
FOR COATINGS, RESINS AND RELATED MATERIALS
(Approved by US Department of Labor Essentially Similar to Form OSHA 20)
Date Issued 11/30/05
SECTION I
MANUFACTURER’S NAME
GARDNER ASPHALT CORPORATION.
STREET ADDRESS
4161 E 7
TH
AVENUE
CITY, STATE, AND ZIP CODE
TAMPA, FL 33605
EMERGENCY TELEPHONE NUMBER
1-800-424-9300
PRODUCT CLASS
ROOF CEMENT MASTIC A/F (WET/DRY) AKA
PLASTIC RF CEMENT/FLASHING CEMENT
MANUFACTURER’S CODE
IDENTIFICATION
0370-GA, 0375-GA
TRADE NAME
GARDNER, WEATHERSEAL, STA-KOOL, BLACKJACK
SECTION II- HAZARDOUS INGREDIENTS
INGREDIENT PERCENT
TLV
PPM
TLV
Mg/M3
LEL VAPOR
PRESSURE
PETROLEUM ASPHALT
CAS # - 8052-42-4
<40% 0.5
Fume
STODDARD SOLVENT
CAS #- 8052-41-3
<20% 100
CELLULOSE FIBER
CAS #- 9004-34-6
<10%
10*
SILICATE MINERAL
CAS #- 7631-86-9
<20%
10*
ADDITIONAL INFORMATION- * AS RESPIRABLE FRACTION OF DUST
Hazardous Materials Identification System (HMIS)
Health Flammability Reactivity Personal Protection
1 2 1 C
SECTION III – PHYSICAL DATA
BOILING RANGE: 300 ºF - 390ºF VAPOR DENSITY HEAVIER LIGHTER, THAN AIR
EVAPORATION RATE FASTER
SLOWER, THAN
ETHER
PERCENT VOTILE BY
VOLUME 60 %
WEIGHT PER GALLON
BY VOLUME 8.4 LBS
SECTION IV – FIRE AND EXPLOSION HAZARD DATA
DOT CATEGORY - NA FLASH POINT- 105ºF Minimum
EXTINGUISHING MEDIA- CO2, FOAM, & DRY CHEMICAL . DO NOT USE HALOGENATED EXTINGUISHING AGENTS.
UNUSUAL FIRE AND EXPLOSION HAZARDS- CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME
HEAT. PRODUCTS OF COMBUSTION MAY BE TOXIC.
SPECIAL FIRE FIGHTING PROCEDURES- WEAR MSHA/NIOSH APPROVED POSITIVE BREATHING APPARATUS IS
RECOMMENDED FOR FIREFIGHTERS. WATER MAY BE USED TO COOL CLOSED CONTAINERS, BUT MAY CAUSE
FROTHING, APPLY CAUTIOUSLY. HIGH PRESSURE STREAM WILL SPREAD FIRE. DO NOT USE HALOGENATED
EXTINGUISHING AGENTS!.