Install Manual

ManualsBrandsGarmin International ManualsElectronicsRemote Control

GDL 69/69A Installation Manual Page 1-1

190-00355-02 Rev. F

1 GENERAL DESCRIPTION

1.1 Scope

The information in this manual is STC approved (STC #SA01487SE). Only the equipment interfaces

covered in this manual are within the scope of this STC. Other equipment may be suitable for use with

the GDL 69/69A, but use of such equipment is beyond the scope of this STC. Additional FAA approval

may be required if equipment not covered in this manual is used to interface to the GDL 69/69A.

This document describes the GDL 69/69A operating with software version 2.13 or later, and the optional

GRT 10/GRC 10 wireless remote system.

Refer to Section 6, Limitations for additional information.

It is possible for installers to seek evaluation and approval of an alternate installation by means of the

field approval process. This manual and all the data contained within may be used by the installer in

pursuit of a field approval.

1.2 Introduction

This manual presents mechanical and electrical installation requirements for installing the datalink

equipment used to deliver XM WX Satellite Weather™ to a variety of Garmin navigation systems. For

audio entertainment in the cockpit, the GDL 69A also provides XM Satellite Radio. If equipped with the

optional GRT 10/GRC 10 wireless remote system, passengers are able to remotely control the audio

functions of the GDL 69A datalink receiver using the GRC 10 wireless remote.

Equipment needed for receiving XM weather and radio:

 GDL 69/69A – (datalink receiver)

 GA37, GA 55, or GA55A (XM antenna)

 GRT 10 (transceiver) –optional

 GRC 10 (remote control) – optional

The datalink equipment will operate with any of the following systems or displays. For a complete list of

equipment see Table 1-1.

 400W/500W series displays

 400/500 series displays

 MX20 Multi-Function Display (MFD)

 GMX 200 MFD

 G1000 Integrated Cockpit System (GDU 104x)

The GDL 69/69A can be integrated into a variety of airframes under an appropriate TC or STC. Each

airframe installation may vary. Interconnect drawings and procedures that are approved by the aircraft-

manufacturer should be used during actual installation.

1.3 Equipment Description

The GDL 69/69A is an XM Satellite Radio data link receiver. The XM Satellite Radio antenna receives

the XM satellite signal and passes it to the GDL 69/69A. The GDL 69 is a weather data receiver and the

GDL 69A is a weather receiver with the addition of XM Satellite Radio audio entertainment. For display

of weather information and control of audio channel and volume, the GDL 69/69A may be interfaced to

the GMX 200 or MX20 MFD or 400/500, 400W/500W series units via an RS-232 bus or the GDU104x

via an Ethernet link. Audio volume and channel changes may also be controlled with mounted optional

switches located in the cabin or by remotely using the GRC 10 wireless remote. The GDL 69A may also

be interfaced to a Garmin audio panel for amplification and distribution of the audio signal.

Summary of content (14 pages)

PAGE 1
GENERAL DESCRIPTION 1.1 Scope The information in this manual is STC approved (STC #SA01487SE). Only the equipment interfaces covered in this manual are within the scope of this STC. Other equipment may be suitable for use with the GDL 69/69A, but use of such equipment is beyond the scope of this STC. Additional FAA approval may be required if equipment not covered in this manual is used to interface to the GDL 69/69A. This document describes the GDL 69/69A operating with software version 2.
PAGE 2
General Description Figure 1-1. GDL 69/69A Unit View The optional GRT 10/GRC 10 wireless remote system is for use by passengers in the aircraft to control the audio functions of the Garmin GDL 69A Datalink Receiver. The system consists of two components: (1) The GRT 10 Wireless Transceiver installed in the aircraft and connected to the GDL 69A serial port, and (2) the GRC 10 Wireless Remote with an LCD display.
PAGE 3
General Description Figure 1-3. GRC 10 Remote Control Unit View CAUTION Stow the GRC 10 in a secure location (i.e. glove box, seat back pocket, etc.) when not in use to prevent damage to the aircraft interior or injury to occupants caused by aircraft maneuvers. WARNING Do not use lithium batteries in the GRC 10. CAUTION When replacing batteries, use only new or fully charged batteries. Do not mix new and old batteries as this can cause battery leakage and damage to the unit. Do not mix battery types (i.
PAGE 4
General Description 1.4 Interfaced Equipment Accomplishment of installation of the GDL 69/69A under this STC requires previous or concurrent installation of the following equipment. If installing the model GDL 69, a control display unit is required. If installing a GDL 69A, a control display unit and audio panel is required; the GRT 10/GRC 10 wireless remote system is optional. OR OR OR Table 1-1.
PAGE 5
General Description 1.5 Audio Entertainment Installation Limitations The GDL 69A XM Satellite Radio audio entertainment and optional GRT 10/GRC 10 wireless remote system may be installed to all passenger locations for all aircraft on the STC Approved Model List (AML). XM audio entertainment to crew locations depends on aircraft installation, which must meet requirements of 14 CFR §23.1431(e). For purpose of this STC, 14 CFR §23.
PAGE 6
General Description 1.6 XM Satellite Radio Welcome to the Next Generation of Radio. America’s most popular satellite radio service gives you the power to choose what you want to hear - wherever and whenever you want it around the Continental United States.
PAGE 7
General Description 1.8 Technical Specifications The GDL 69/69A, GA 55, and GA55A antenna, and optional GRT 10/GRC 10 wireless remote system are PMA approved and there is no applicable TSO. The GA 37 and GA 57 GPS/WAAS – XM antennas are TSO authorized under TSO-C144, but the GA 57 is not recommended for new installations.
PAGE 8
General Description NOTE See Table 2-12 outlining weights for the GDL 69, GDL 69A, remote rack, modular rack, GRT 10 transceiver, and GRC 10 remote control. Table 1-6. GDL 69/69A Unit Dimensions Characteristic Width Height Depth (Rack w/ Connectors) Unit Weight (GDL 69A) Unit (GDL 69A) and Remote Rack Weight Specification 1.05 inches (2.66 cm) 6.15 inches (15.62 cm) 7.20 inches (18.26 cm) 1.86 lbs (0.84 kg) 2.83 lbs (1.27 kg) Table 1-7.
PAGE 9
General Description 8.26 [209.8] 1.48 [37.7] 7.9 [200.9] ANTENNA 6.43 [163.2] 6.91 [175.6] J1100 3.57 [90.7] CENTER OF GRAVITY 3.98 [101.1] CENTER OF GRAVITY 0.73 [18.6] 0.49 [12.4] 8.74 [221.9] 1.60 [40.53] 0.37 [9.40] 4.46 [113.22] 0.73 [18.49] Figure 1-4. GDL 69/69A Remote Rack Unit Dimensions 1.23 31.1 WITH DIMPLES 1.20 30.5 WITHOUT DIMPLES 7.26 184.4 ANTENNA 6.30 160.0 6.90 175.3 TYP 3.00 76.2 .60 15.2 .36 9.1 J10001 4.30 109.2 TYP 7.65 194.3 .48 12.2 TYP 8.73 221.8 .48 12.
PAGE 10
General Description 2.28 0.92 1.37 0.43 0.91 2.57 2.74 2.00 3.77 5.68 Figure 1-6. GRT 10 Transceiver Dimensions 0.68 2.46 5.00 1.16 1.20 Figure 1-7. GRC 10 Remote Control Dimensions Page 1-10 Rev.
PAGE 11
General Description General Antenna Requirements Garmin recommends the Garmin XM antenna shown in the Table 1-9 below. These antennas are approved with the certification of the GDL 69/69A. However, any equivalent XM antenna with specifications listed in Table 1-10 should work with the GDL 69/69A. Antennas must provide protection from direct lightning strikes. This STC does not support installations of equivalent antennas. Table 1-9.
PAGE 12
General Description 1.9 Reference Documents The following publications are sources of additional information for installing the GDL 69/69A and optional GRT 10/GRC 10 wireless remote system. Before installing the GDL 69/69A, the technician should read all referenced materials applicable to the installation along with this manual. Table 1-12.
PAGE 13
General Description 1.10.2.2 FCC Grant of Equipment Authorization GRT 10: FCC ID: IPH-01179 IC: 1792A-01179 NOTE This device complies with Part 15 of the FCC Rules. Operation is subject to the following conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. NOTE This device does not contain any user-serviceable parts.
PAGE 14
General Description 1.12 Warranty Statement Limited Warranty This Garmin product is warranted to be free from defects in materials or workmanship for two years (one year for GRC 10) from the date of purchase. Within this period, Garmin will at its sole option, repair or replace any components that fail in normal use. Such repairs or replacement will be made at no charge to the customer for parts or labor, provided that the customer shall be responsible for any transportation cost.