User's Manual
Table Of Contents
- Section 1 Introduction
- 1.1 Purpose of This Manual
- 1.2 General Description
- 1.3 General Specifications
- Section 2 Installation / Initial Turn-On
- 2.1 Introduction
- 2.2 Installation Checkboxes
- 2.3 Transmitter Cabinet Placement
- 2.4 Transmitter AC Connection
- 2.5 Signal and Ground Connections
- 2.6 Interlock Connections
- 2.7 3 Port Patch Panel
- 2.8 Motorized RF Switch Connections
- 2.9 Install PA and PS Modules
- 2.10 Initial Turn-On
- 2.11 Parallel Remote Control Connections
- 2.12 Remote Status Outputs, J15 & J16
- Section 3 Operation/ Adjustments
- 3.1 Introduction
- 3.2 Transmitter Control Panel
- 3.3 Graphical User Interface (GUI)
- 3.4 GUI Home Page
- 3.5 Drive Chain Main Menu
- 3.6 Power Amp Main Menu
- 3.7 Output Main Menu
- 3.8 Power Supply Main Menu
- 3.9 System Main Menu
- 3.10 GUI Menu Structures
- Section 4 Theory of Operation
- 4.1 Introduction
- 4.2 Block Diagram Descriptions
- 4.3 Transmitter Control System
- 4.4 Transmitter RF System
- 4.5 Power Supplies
- Section 5 Replacement Procedures
- 5.1 Introduction
- 5.2 PA Module Removal
- 5.3 PA Module Pallet Replacement
- 5.4 Power Supply Module Replacement
- 5.5 Circulator Removal/Replacement
- 5.6 Blower Assembly Removal
- Section 6 ISP (In-System Programming)
- 6.1 Introduction
- 6.2 Installing the ISP Program
- 6.3 ISP Procedures
- Section 7 Parts List
- 7.1 Parts List Index
7-4 888-2687-001 10/19/07
WARNING: Disconnect primary power prior to servicing.
Ranger ™ Mobile Series
Section 7 Parts List
614 0930 000 TERM BLK, 2C MODULAR 283 2.0 EA #TB1
620 0573 000 CONN, ANCHOR INS 1-5/8 2.0 EA (PART OF RF CHAIN)
620 2109 000 JACK, BNC 75 OHM BULKHEAD 1.0 EA A1J2
620 2381 000 ELBOW 1-5/8 50 OHM FLANGE 2.0 EA (PART OF RF CHAIN)
620 3188 000 ADAPTER, 1-5/8" 1.0 EA
620 3268 000 CABLE, COAX, 7/16" PLUG 1.0 EA W13
620 3269 000 DIR COUPLER, 1-5/8", UHF 1.0 EA DC1
620 3274 000 DIR COUPLER, 1-5/8", UHF 1.0 EA DC3
646 0973 000 *LABEL, 230V 1.0 EA #AC1
646 1698 000 NAMEPLATE, DOMED, HARRIS LOGO 1.0 EA
646 1710 001 NAMEPLATE, DOMED, "RANGER" 1.0 EA
700 1413 000 ATTENUATOR 40DB, 1KW 1.0 EA AT1
822 0900 016 PIN, ALIGNMENT 3.0 EA # PA1
827 6893 001 PLATE 3.0 EA GROUNDING BLOCKS
843 5560 001 WIRING DIAGRAM, RANGER 0.0 EA
843 5560 080 WAVECRIMP MARKING CHART 0.0 EA
917 2413 500 RAIL, CARRIER, 3.0" 1.0 EA TB2
917 2456 081 SPACER 8.0 EA
917 2567 003 DIN RAIL, CUT LENGTH 108MM 1.0 EA TB1
917 2570 003 CABLE RANGER CABINET 1.0 EA
917 2570 007 CABLE FAN TRAY 1.0 EA
917 2570 008 CABLE PA TO SPLITTER 1.0 EA W17
917 2570 017 RANGER SOFTWARE PACKAGE 1.0 EA
922 1297 014 BRACKET, CABLE SUPPORT 1.0 EA # A6
922 1300 031 RAIL, SUPPORT 1.0 EA # A6
922 1340 001 STANDOFF, MOV BOARD 2.0 EA # A8
922 1340 005 CABLE CIRCULATOR TO LOAD 1.0 EA W15
922 1340 006 RESTRAINT 1.0 EA (USED AS GND STRAP)
943 5494 069 MOUNTING SCREW PA REJECT SINK 2.0 EA (2 PER HEATSINK #404-0902-000)
943 5494 236 PLATE, REAR SHELL RIGHT MTG. 2.0 EA #357-0103-000
943 5494 237 PLATE, REAR SHELL LEFT MTG 2.0 EA #357-0103-000
943 5494 291 SCREW SHOULDER 6-32 6.0 EA (2 EA REQ’D FOR PA1, 4 REQ’D FOR
PS1)
943 5494 614 TRAY, GLOVE 1.0 EA
943 5560 006 DOOR, REAR ASSY. 1.0 EA
943 5560 011 RETAINER, FILTER REAR DOOR 1.0 EA
943 5560 014 RAIL, EIA LEFT FRONT 1.0 EA
943 5560 015 RAIL, EIA RIGHT FRONT 1.0 EA
943 5560 016 RAIL, EIA LEFT REAR 1.0 EA
943 5560 017 RAIL, EIA RIGHT REAR 1.0 EA
943 5560 018 ANGLE, EIA SUPPORT 1.0 EA
943 5560 019 PANEL, MODULE 1.0 EA (PART OF MODULE CAGE)
943 5560 020 ANGLE, EIA FRONT 2.0 EA
943 5560 021 PLATE, MOV MOUNTING 1.0 EA
943 5560 023 ANGLE, REAR RIGHT GASKET 2.0 EA
943 5560 024 SADDLE ASSY 3.0 EA USED TO MOUNT RF COMPONENTS
943 5560 026 PLATE, CABINET TOP 1.0 EA
943 5560 027 COVER, MOV SAFETY 1.0 EA # A8
943 5560 028 DIVIDER, POWER SUPPLY 1.0 EA
943 5560 029 PANEL, POWER SUPPLY 1.0 EA
943 5560 031 PLATE, POWER CONECTOR 1.0 EA
943 5560 039 STRAP, GROUND 1.0 EA
943 5560 040 DIVIDER, LEFT AIR 1.0 EA
943 5560 041 DIVIDER, RIGHT AIR 1.0 EA